2004 NISSAN PATHFINDER brake fluid

deformation, rot or loose connections.
Underbody:
The underbody is frequently exposed to corro-
sive substances such as those used on icy roads
or to control dust. It is very important to remove
these substances, otherwise rust will form on the
floor pan, frame, fuel lines and around the ex-
haust system. At the end of winter, the under-
body should be thoroughly flushed with plain
water, being careful to clean those areas where
mud and dirt may accumulate. For additional
information, see “Cleaning exterior” in the “7.
Appearance and care” section.
Windshield washer fluid*:
Check that there is adequate fluid in the tank.When performing any inspection or maintenance
work on your vehicle, always take care to prevent
serious accidental injury to yourself or damage to
the vehicle. The following are general precau-
tions which should be closely observed.
WARNING

Park the vehicle on a level surface,
apply the parking brake securely and
block the wheels to prevent the ve-
hicle from moving. For a manual
transmission, move the shift lever to
Neutral. For an automatic transmis-
sion, move the selector lever to the P
(Park) position.

Be sure the ignition key is in the OFF
or LOCK position when performing
any replacement or repair.

If you must work with the engine
running, keep your hands, clothing,
hair and tools away from moving fans
belts and any other moving parts.

It is advisable to secure or remove
any loose clothing and any jewelry,such as rings, watches, etc. before
working on your vehicle.

Always wear eye protection when-
ever you work on your vehicle.

If you must run the engine in an
enclosed space such as a garage, be
sure there is proper ventilation for
exhaust gases to escape.

Never get under the vehicle while it is
supported only by a jack. If it is nec-
essary to work under the vehicle,
support it with safety stands.

Keep smoking materials, flame and
sparks away from fuel and battery.

Your vehicle is equipped with an au-
tomatic engine cooling fan. It may
come on at any time without warning,
even if the ignition key is in the OFF
position and the engine is not run-
ning. To avoid injury, always discon-
nect the negative battery cable be-
fore working near the fan.

On gasoline engine models with theMAINTENANCE PRECAUTIONS
Maintenance and do-it-yourself
8-5


04.3.9/R50-D/V5


WARNING

When engine is running, keep hands,
jewelry, and clothing away from any
moving parts such as fan and drive
belt.

Automatic transmission fluid is poi-
sonous and should be stored care-
fully in marked containers out of the
reach of children.
TEMPERATURE CONDITIONS FOR
CHECKINGThe fluid level should be checked using the HOT
range (L & H marks) on the dipstick at fluid
temperatures between 122 and 176°F (50 and
80°C) after the vehicle has been driven approxi-
mately 5 minutes in urban areas after the engine
is warmed up. The level can be checked at fluid
temperatures between 86 and 122°F (30 and
50°C) using the COLD range on the dipstick for
reference, after the engine is warmed up but
before driving. However, the fluid level must be
rechecked using the HOT range.
1. Park the vehicle on a level surface and set the
parking brake.
2. Start the engine and then move the selector
lever through each gear range, ending in P.
3. Check the fluid level with the engine idling.
4. Expand the spring stopper and remove the
dipstick. Wipe it clean with lint-free paper.
5. Re-insert the dipstick into the charging pipe
as far as it will go.
6. Remove the dipstick and note the reading.
If the level is on the low side of either range, add
fluid to the charging pipe.7. When inserting the dipstick, set it so that the
spring stopper presses the upper part of the
dipstick rubber to lock the dipstick.
CAUTION

Do not overfill.

Use only Nissan Matic D (Continental
U.S. and Alaska) or Canada Nissan
automatic transmission fluid.
Dexron
TMIII/Mercon
TM
or equivalent
may also be used. Outside the conti-
nental US and Alaska contact a
NISSAN dealer for more information
regarding suitable fluids, including
recommended brand(s) of Dexron
TM
III/Mercon
TM
automatic transmission
fluid.
If the vehicle has been driven for a long
time at high speeds, or in city traffic in hot
weather, or if it is being used to pull a
trailer, the fluid level cannot be read accu-
rately. You should wait until the fluid has
cooled down (about 30 minutes).
SDI1120
AUTOMATIC TRANSMISSION
FLUID8-14
Maintenance and do-it-yourself


04.3.9/R50-D/V5


WARNING
Use only new fluid from a sealed con-
tainer. Old, inferior or contaminated
fluid may damage the brake and clutch
systems. The use of improper fluids can
affect the vehicle’s stopping ability.
CAUTION
Do not spill the fluid on painted sur-
faces. This will damage the paint. If fluid
is spilled, wash the surface with water.
BRAKE FLUIDCheck the fluid level in the reservoir. If the fluid
level is below the MIN. line or the brake warning
light comes on, add Genuine NISSAN Super
Heavy Duty Brake Fluid or equivalent DOT 3
fluid up to the MAX. line.
If fluid must be added frequently, the system
should be thoroughly checked by your NISSAN
dealer.
CLUTCH FLUIDCheck the fluid level in the reservoir. If the fluid
level is below the MIN. line, add Genuine
NISSAN Super Heavy Duty Brake Fluid or
equivalent DOT 3 fluid up to the MAX. line.
If fluid is added frequently, the system should be
thoroughly checked by your NISSAN dealer.
SDI0847
SDI0844
BRAKE AND CLUTCH FLUID8-16
Maintenance and do-it-yourself


04.3.9/R50-D/V5


Capacity (Approximate)
Recommended specifications
US
measureImp
measureLiter
Manual transmission— — — API GL-4 Viscosity SAE 75W-85
Differential gear oil (exc. LSD)— — — API GL-5 Viscosity SAE 80W-90*1
Limited-slip differential (LSD) gear oil — — —Only LSD gear oil:
API GL-5 and SAE 80W-90*1 approved for Nissan LSD*2
Automatic transmission fluid
Refill to the proper oil level according to the instructions
in the “8. Maintenance and do-it-yourself” section.Nissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6
Power steering fluid (PSF)Genuine NISSAN PSF or equivalent*5
All-mode 4WD transfer fluidNissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6
Transfer fluidNissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6 or API GL-4 Viscosity SAE 75W-90
Brake and clutch fluidGenuine Nissan Super Heavy Duty Brake Fluid*4 or equivalent
DOT 3 (U.S. F.M.V.S.S. No. 116)
Propeller shaft grease— — — NLGI No. 2 (Lithium soap base)
Multi-purpose grease— — — NLGI No. 2 (Lithium soap base)
Air conditioning system refrigerant— — — HFC-134a (R-134a)*4
Air conditioning system lubricants———Nissan A/C System Oil Type S or exact equivalent*4
*1: For hot areas, viscosity SAE 90 is suitable for ambient temperatures above 0°C (32°F).
*2: Contact your NISSAN dealer for a list of approved oils.
*3: Available in mainland U.S. through your NISSAN dealer.
*4: See “Vehicle identification” later in this section for air conditioner specification label.
*5: For Canada, NISSAN Automatic Transmission Fluid (ATF), DEXRON
TMIII/MERCON
TMor equivalent ATF may also be used.
*6: Dexron
TMIII/Mercon
TM
or equivalent may also be used. Outside the continental U.S. and Alaska contact an authorized NISSAN dealer for more information regarding
suitable fluids, including recommended brand(s) of DEXRON
TMIII/MERCON
TMAutomatic Transmission Fluid.
Technical and consumer information
9-3


04.3.9/R50-D/V5


When going down a hill, shift into a lower
gear and use the engine braking effect.
When going up a long grade, downshift the
transmission to a lower gear and reduce
speed to reduce chances of engine overload-
ing and/or overheating.
However, for long steep grades, do not stay in
1st or 2nd gear when driving above 35 MPH (56
km/h).

If the engine coolant rises to an extremely
high temperature when the air conditioning
system is on, turn off the air conditioner.
Coolant heat can be additionally vented by
opening the windows, switching the fan con-
trol to high and setting the temperature con-
trol to the HOT position.

Trailer towing requires more fuel than normal
circumstances.

Avoid towing a trailer for the first 500 miles
(805 km).

Have your vehicle serviced more often than at
intervals specified in the recommended Main-
tenance Schedule in the “NISSAN Service
and Maintenance fluid”.

When making a turn, your trailer wheels will
be closer to the inside of the turn than your
vehicle wheels. To compensate for this, makea larger than normal turning radius during the
turn.

Crosswinds and rough roads will adversely
affect vehicle/trailer handling, possibly caus-
ing vehicle sway. When being passed by
larger vehicles, be prepared for possible
changes in crosswinds that could affect ve-
hicle handling. If swaying does occur, firmly
grip the steering wheel, steer straight ahead,
and immediately (but gradually) reduce ve-
hicle speed. This combination will help stabi-
lize the vehicle. Never increase speed.

Be careful when passing other vehicles.
Passing while towing a trailer requires con-
siderably more distance than normal passing.
Remember the length of the trailer must also
pass the other vehicle before you can safely
change lanes.

To maintain engine braking efficiency and
electrical charging performance, do not use
sixth gear (manual transmission) or fifth posi-
tion (automatic transmission).

Avoid holding the brake pedal down too long
or too frequently. This could cause the brakes
to overheat, resulting in reduced braking ef-
ficiency.
When towing a trailer, the transmission
oil/fluid should be changed more fre-quently. For additional information, see
the “8. Maintenance and do-it-yourself”
section earlier in this manual.
FLAT TOWINGTowing your vehicle with all four wheels on the
ground is sometimes called flat towing. This
method is sometimes used when towing a ve-
hicle behind a recreational vehicle, such as a
motor home.
CAUTION

Failure to follow these guidelines
can result in severe transmission
damage.

Whenever flat towing your vehicle,
always tow forward, never backward.

DO NOT tow any automatic transmis-
sion vehicle with all four wheels on
the ground (flat towing). Doing so
WILL DAMAGE internal transmission
parts due to lack of transmission lu-
brication.

For emergency towing procedures re-
fer to “Towing Recommended by
9-22
Technical and consumer information


04.3.9/R50-D/V5


10 Index
A
ABS (Anti-lock brake system)................................ 5-34
Air bag warning labels ............................................. 1-21
Air bag warning light .................................... 1-21, 2-13
Air cleaner housing filter.......................................... 8-20
Air conditioner
Air conditioner operation ..................................... 4-2
Air conditioner service ............................. 4-2, 4-12
Air conditioner specification label .................. 9-14
Air conditioning system refrigerant and lubricant
recommendations ...................................... 4-12, 9-7
Heater and air conditioner controls.................. 4-2
Servicing air conditioner...................................... 4-2
Air flow charts............................................................... 4-5
Alcohol, drugs and driving......................................... 5-5
Anchor point locations, Top tether strap ............ 1-43
Antenna ........................................................................ 4-29
Anti-lock Brake System (ABS) .............................. 5-34
Anti-lock brake warning light .................................... 2-9
Appearance care
Exterior appearance care .................................... 7-2
Interior appearance care ..................................... 7-3
Armrest ........................................................................... 1-9
Ashtray (See cigarette lighter and ashtray) ........ 2-29
ATP warning light ...................................................... 2-10
Audible reminders ..................................................... 2-16
Audio operation precautions .................................. 4-14
Audio system .............................................................. 4-13Steering wheel audio controls ........................ 4-28
Autochanger, Compact Disc (CD) ....................... 4-26
Automatic
Automatic transmission fluid (ATF) ................ 8-14
Drive positioner ................................................... 3-17
Driving with automatic transmission ..... 5-7, 5-11
Seat positioner, seat .......................................... 3-17
Transmission park warning light ..................... 2-10
Transmission selector lever lock release ...... 5-14
Avoiding collision and rollover .................................. 5-5
B
Back door.................................................................... 3-10
Battery .......................................................................... 8-18
Battery saver system ......................................... 2-22
Battery replacement
Intelligent Key system .......................................... 3-8
Remote keyless entry system............................. 3-8
Before starting the engine ...................................... 5-10
Belts (See drive belts) ............................................. 8-19
Brake
Anti-lock brake system (ABS) ......................... 5-34
Brake and clutch fluid ....................................... 8-16
Brake booster ...................................................... 8-23
Brake fluid............................................................. 8-16
Brake pedal .......................................................... 8-22
Brake pedal check ............................................. 8-23
Brake system ....................................................... 5-34Parking brake check............................... 5-17, 8-22
Parking brake operation .................................... 5-17
Warning light ....................................................... 2-11
Break-in schedule ..................................................... 5-20
Brightness control, Instrument panel ................... 2-23
Bulbcheck/instrument panel .................................... 2-9
Bulbreplacement ............................................. 8-3, 8-27
C
Capacities and recommended fuel/lubricants...... 9-2
Car phone or CB radio............................................ 4-31
Cargo (See vehicle loading information)............. 2-37
Cargo net .................................................................... 2-37
Cassette player (See audio system) ........ 4-18, 4-25
Catalytic converter, Three way catalyst ................. 5-3
CD care and cleaning .............................................. 4-28
Child restraints ........................................................... 1-32
Installation on front passenger seat............... 1-44
Installation on rear seat center position........ 1-34
Installation on rear seat outboard
positions ................................................................ 1-36
Precautions on child restraints........................ 1-32
Top tether strap anchor point locations ....... 1-43
With top tether strap ......................................... 1-42
Child safety ................................................................. 1-25
Child safety rear door lock ........................................ 3-4
Chimes
Audible reminders............................................... 2-16


04.3.9/R50-D/V5


Seat belt warning light and chime ................. 2-13
Cigarette lighter and ashtray .................................. 2-29
Circuit breaker, Fusible link .................................... 8-24
Cleaning exterior and interior .......................... 7-2, 7-3
Clock ............................................................................ 2-28
Clutch fluid.................................................................. 8-16
Coin box ...................................................................... 2-30
Cold weather driving ................................................ 5-37
Compact Disc (CD) changer operation .............. 4-26
Compact Disc (CD) player (See audio
system) ......................................................................... 4-19
Compact spare tire ................................................... 8-39
Compass display ......................................................... 2-7
Console box................................................................ 2-34
Controls
Heater and air conditioner controls.................. 4-2
Steering wheel audio controls ........................ 4-28
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Checking engine coolant level........................... 8-8
Corrosion protection ................................................... 7-4
Cover, Tonneau cover .............................................. 2-37
Cruise control............................................................. 5-18
Cup holders ................................................................ 2-32
CVT, Transmission selector lever lock
release .......................................................................... 5-14
D
Daytime running light system ................................. 2-24
Dimensions and weights ......................................... 9-11
Door open warning light .......................................... 2-11Drive belts ................................................................... 8-19
Drive positioner, Automatic..................................... 3-17
Driving
All-mode four wheel drive (4WD) .................. 5-25
Cold weather driving ......................................... 5-37
Driving with automatic transmission ..... 5-7, 5-11
Driving with manual transmission .......... 5-8, 5-16
On-pavement and offroad driving ..................... 5-4
Part time four wheel drive (4WD) .................. 5-21
Precautions when starting and driving ............ 5-2
Safety precautions ................................................ 5-5
E
Economy, Fuel............................................................ 5-20
Electric sunroof .......................................................... 2-40
Emission control information label ........................ 9-13
Emission control system warranty......................... 9-24
Engine
Before starting the engine................................ 5-10
Break-in schedule............................................... 5-20
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Changing engine oil ........................................... 8-12
Changing engine oil filter ................................. 8-13
Checking engine coolant level........................... 8-8
Checking engine oil level ................................. 8-11
Coolant temperature gauge ............................... 2-4
Engine block heater ........................................... 5-39
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-8
Engine oil .............................................................. 8-11
Engine oil and oil filter recommendation......... 9-6Engine oil viscosity ............................................... 9-6
Engine serial number ......................................... 9-13
Engine specifications ........................................... 9-9
If your vehicle overheats ................................... 6-11
Starting the engine............................................. 5-10
Event data recorders ................................................ 9-26
Exhaust gas (Carbon monoxide).............................. 5-2
F
F.M.V.S.S. certification label................................... 9-13
Filter
Air cleaner housing filter ................................... 8-20
Changing engine oil filter ................................. 8-13
Flashers (See hazard warning flasher switch) ... 2-25
Flat tire............................................................................ 6-2
Flat tire, Low tire pressure warning system .......... 5-3
Flat towing .................................................................. 9-22
Floor mat cleaning ....................................................... 7-4
Fluid
Automatic transmission fluid (ATF) ................ 8-14
Brake and clutch fluid ....................................... 8-16
Brake fluid............................................................. 8-16
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-8
Engine oil .............................................................. 8-11
Power steering fluid ........................................... 8-15
Window washer fluid ......................................... 8-17
FM-AM radio with cassette player and Compact
Disc (CD) player........................................................ 4-16
FM-AM-SATELLITE radio with cassette
player and Compact Disc (CD) player/CD
changer ........................................................................ 4-23


04.3.9/R50-D/V5

10-2

Replacement ............................................... 8-3, 8-27
Vanity mirror light ................................................ 2-44
Warning/indicator lights and audible
reminders ..................................................... 2-9, 2-14
Loading information (See vehicle loading
information) ................................................................. 9-14
Lock
Back door lock .................................................... 3-10
Door locks ............................................................... 3-2
Glass hatch lock ................................................. 3-11
Glove box lock..................................................... 2-33
Power door lock .................................................... 3-2
Lockout protection....................................................... 3-4
Low fuel warning light .............................................. 2-12
Low tire pressure warning light ............................. 2-12
Low tire pressure warning system ................. 5-3, 6-2
Luggage hooks .......................................................... 2-35
Luggage rack ............................................................. 2-38
Luggage side console box...................................... 2-34
M
Maintenance
Battery ................................................................... 8-18
General maintenance ........................................... 8-2
Inside the vehicle................................................... 8-3
Maintenance precautions .................................... 8-5
Maintenance requirements.................................. 8-2
Outside the vehicle............................................... 8-2
Seat belt maintenance ...................................... 1-32
Malfunction indicator lamp (MIL) ........................... 2-14
Manual front seat adjustment ................................... 1-2
Meters and gauges ..................................................... 2-3Meters and gauges, Instrument brightness
control .......................................................................... 2-23
Mirror
Inside mirror ......................................................... 3-16
Outside mirror control ....................................... 3-16
Outside mirrors ................................................... 3-16
N
Net, Cargo net ........................................................... 2-37
New vehicle break-in ................................................ 5-20
Nissan Vehicle Immobilizer System ...................... 2-17
Engine start............................................................. 5-9
O
Odometer ....................................................................... 2-3
Oil
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine oil ........................................... 8-12
Checking engine oil level ................................. 8-11
Engine oil .............................................................. 8-11
Engine oil viscosity ............................................... 9-6
Outside mirror control .............................................. 3-16
Outside mirrors .......................................................... 3-16
Outside temperature display..................................... 2-6
Overdrive switch........................................................ 5-15
Overheat, If your vehicle overheats ...................... 6-11
Owner’s Manual/Service Manual order
information................................................................... 9-27P
Parking
Brake check ......................................................... 8-22
Parking brake check .......................................... 5-17
Parking brake operation .................................... 5-17
Parking on hills .................................................... 5-17
Parking/parking on hills ........................................... 5-32
Personal lights............................................................ 2-43
Phone, Car phone or CB radio ............................. 4-31
Power
Front seat adjustment .......................................... 1-4
Power door lock .................................................... 3-2
Power outlet ......................................................... 2-28
Power steering fluid ........................................... 8-15
Power steering system ...................................... 5-33
Power windows................................................... 2-39
Pre-tensioner seat belt system .............................. 1-20
Precautions
Audio operation ................................................... 4-14
Braking precautions ........................................... 5-34
Child restraints .................................................... 1-32
Cruise control ...................................................... 5-18
Cruise control operations ................................. 5-20
Driving safety .......................................................... 5-5
Maintenance ........................................................... 8-5
On-pavement and offroad driving ..................... 5-4
Seat belt usage ................................................... 1-24
Supplemental restraint system ........................ 1-10
When starting and driving .................................. 5-2
Push starting .............................................................. 6-11


04.3.9/R50-D/V5

10-4