2004 MITSUBISHI ENDEAVOR radio removal

CONSOLE ASSEMBL
Y . Remove left and right A-pillar trim panels.
Remove hood lock release handle.
3. Remove end panel. See Fig. 8
. Remove driver-side knee bolster. Remove fog
light switch. Remove steering column upper and lower covers. Remove
combination meter assembly. Remove center panel assembly. Remove air
vents. Remove radio panel. Remove AC-heater control assembly.
4. Remove hazard warning switch. Remove console meter hood. Remove multi-
center display unit. Remove audio components. Remove glove box assembly.
Remove left and right speaker covers. Remove speakers. Disconnect
clockspring and steering column switch connectors. Remove photo sensor and
photo sensor clamp.
5. Remove interior temperature sensor. Disconnect passenger-side air bag module
connector. Remove left and right center instrument panel brackets. Disconnect
remaining electrical connectors. Remove instrument panel nuts and bolts.
Remove instrument panel.
6. To install, reverse removal procedure. Tighten NEW steering wheel nut and
drive
r-side air ba
g module bolts to s
pecification. Activate air ba
g system.

2004 Mitsubishi Endeavor Limited
2004 ACCESSORIES/SAFETY EQUIPMENT Mitsubishi - Air Bag Restraint Systems

Fig. 153: Identifying Special Tools

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
RADIO WITH TAPE PLAYER AND CD PLAYER REMOVAL AND INSTALLATION Fig. 154: Removing/Installing Radio With Tape Player And CD Player
2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA
.
REMOTE CONTROLLED RADIO SWITCH REMOVAL AND INSTALLATION Fig. 155: Removing/Installing Remote Controlled Radio Switch

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
REMOVAL SERVICE POINT << A >> REMOTE CONTROLLED RADIO SWITCH REMOVAL Use a tool to hold the tabs on the remote controlled radio switch, and push out the
switch b
y your fin
ger.
WARNING:
Before removing the air bag module, refer to AIR BAG RESTRAINT SYSTEMS
).
When removing and installing the steering
wheel, do not let it bump against the air bag
module.

2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

Fig. 157: Measuring Resistance Value Between Terminal

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
Fig. 158: Identifying Switch Position

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
SPEAKER REMOVAL AND INSTALLATION Instrument Panel
2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

Quarter Trim Pane
l
Fig. 161: Removing/Installing Speaker

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
AMPLIFIER REMOVAL AND INSTALLATION
2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

Fig. 162: Removing/Installing Amplifier

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
REMOVAL SERVICE POINTS << A >> AMPLIFIER REMOVAL Move the audio amplifier wiring harness to one side, and then maneuver out the
audio amplifier.
2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

Fig. 164: Installing Amplifier

Courtesy of MITSUBISHI MOTOR SALES OF AMERICA.
ANTENNA REMOVAL AND INSTALLATION
2004 Mitsubishi Endeavor LS
2004 BODY & ACCESSORIES Radio With Tape Player & Cd Player - Endeavor

2004 Mitsubishi ENDEAVOR 04 - Body > STRUCTURE : BODY [Part 162000 ]
TSB No: 94 NHTSA ID: , June 01, 2003 : Replacement:
Summary: wind deflector installation to reduce wind turbulence inside the vehicle when
driving with the sunroof open. *tt

2004 Mitsubishi ENDEAVOR 04 - Radio CD Player > EQUIPMENT : ELECTRICAL :
RADIO/TAPE DECK/CD ETC. [Part 353400 ]
TSB No: 0354005 NHTSA ID: , May 01, 2003 : Replacement:
Summary: improper alignment between the cd player and the cd opening on the center
instrument panel may cause difficulty ejecting cds. *tt

2004 Mitsubishi ENDEAVOR 04 - Tires > TIRES [Part 190000 ]
TSB No: 93 NHTSA ID: , May 01, 2003 : Replacement:
Summary: tire pressure monitoring system (tpms). *tt

2004 Mitsubishi ENDEAVOR 04 - Body > STRUCTURE : BODY [Part 162000 ]
TSB No: 93 NHTSA ID: , May 01, 2003 : Replacement:
Summary: undercoating appearance. *tt

2004 Mitsubishi ENDEAVOR 04 - Trailer Hitch > TRAILER HITCHES [Part 210000 ]
TSB No: 0300009 NHTSA ID: , May 01, 2003 : Replacement:
Summary: tow hitch torque specification. *tt

2004 Mitsubishi ENDEAVOR 04 - Electrical System > ELECTRICAL SYSTEM [Part
110000 ]
TSB No: 0352A002 NHTSA ID: , May 01, 2003 : Replacement:
Summary: center instrument panel removal. *tt

2004 Mitsubishi ENDEAVOR 04 - Labels > EQUIPMENT : OTHER : LABELS [Part
355100 ]
TSB No: 93 NHTSA ID: , May 01, 2003 : Replacement:
Summary: immobilizer engine control unit (ecu) serial number sticker. *tt