2004 MERCEDES-BENZ C320 COUPE coolant

335 Technical data
Fuels, coolants, lubricants, etc.
When switching fuels, make sure:

Fuel level is below half full.


Fuel level is above reserve (reserve
warning lamp is not lit).


Amount of added fuel is more than
5 gallons (20 liters).


Ignition is off during refill.


Immediately after refueling engine is
started and operated for at least five
minutes.
These precautions and recommendations
are supposed to prevent any difficulties
when starting and operating the engine
which otherwise may be experienced be-
fore the engine has fully adapted to the dif-
ferent fuel.
If in spite of these recommendations the
engine does not perform properly, adding
more gasoline (at least 3 gallons
[12 liters]) to the fuel may improve the en-
gine behavior.Cold weather performance
It is possible that starting times will signif-
icantly increase at temperatures below
32°F (0°C). At low temperatures the use
of a block heater is recommended (see
your authorized Mercedes-Benz Center for
further information). Rough idling may also
be experienced at such temperatures be-
fore the engine is fully warmed up.
Hot weather performance
At ambient temperatures above 95°F
(35°C) start times may increase and be ac-
companied by a rough idle following the
start.Cruising range
E85 fuel contains less energy per gallon
than gasoline. To ensure that engine per-
formance with Ethanol fuel is similar to
that when using gasoline, the engine must
burn more Ethanol fuel. As a result, it is to
be expected that the fuel consumption will
increase when using E85 compared to gas-
oline operation.
Maintenance
Please inform your Mercedes-Benz Center
if you use or have used E85 fuel when your
vehicle is delivered for maintenance or re-
pairs.
!E85 fuel is unsuitable for use when am-
bient temperatures fall below 14°F
(-10°C).
iUse of E85 may reduce your driving
range.

336 Technical dataFuels, coolants, lubricants, etc.Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Service Booklet for
replacement interval.
Coolant system design and coolant used
stipulate the replacement interval. The
replacement interval published in the Ser-
vice Booklet is only applicable if MB 325.0
anticorrosion/antifreeze solution or other
Mercedes-Benz approved products of
equal specification (see Factory Approved
Service Products pamphlet) are used to re-
new the coolant concentration or bring it
back up to the proper level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]).If you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.
If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure the mixture is
in accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.

337 Technical data
Fuels, coolants, lubricants, etc.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze agent.Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantityModel
Approx. freeze protection–35°F (–37°C)
–49°F (–45°C)
C230Kompressor
3.0 US qt (2.8 l)
3.3 US qt (3.1 l)
C320
3.4 US qt (3.2 l)
3.8 US qt (3.6 l)

338 Technical dataFuels, coolants, lubricants, etc.Windshield washer system and headlamp cleaning system
Both the windshield and headlamp washer
systems are supplied from the windshield
washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx.

6.4 US qt (6.0 l) in vehicles with head-
lamp cleaning system*


3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system

Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed windshield washer sol-
vent/antifreeze, depending on ambient
temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
[40 ml “S” to 1 gallon (4 liters) water]
For temperatures below freezing point use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent/antifreeze:


1 part “S” to 100 parts solvent
[40 ml “S” to 1 gallon (4 liters) solvent].
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You can be seriously burned.

347 Index
A
ABS 23, 73, 341
Malfunction indicator lamp 258
Messages in display 268
Warning lamp 258
Accelerator position, automatic
transmission 145
Accident
In case of 51
Activating
Air conditioning (cooling) 156
Air recirculation mode 154
Anti-theft alarm system 78
Central locking (control system) 129
Climate control 151
Defrost 154
Easy-entry/exit feature 130
ESP 77
Exterior headlamps 48
Exterior lamps 99
Hazard warning flasher 102Headlamps 48
High beams 102
Ignition 31
Immobilizer 78
Rear fog lamp 100
Rear window defroster 149
Seat heater* 94
Tow-away alarm 79
Windshield wipers 49
Adding
Coolant 241
Engine oil 239
Additional turn signals 293
Adjustable air outlets
Rear passenger compartment 158
Adjusting 32
Air distribution 153
Air volume 153
Backrest tilt 33, 35
Exterior rear view mirror 40Head restraint height 34, 36, 91
Head restraint tilt 34, 36
Head restraints 92
Instrument cluster illumination 105
Interior rear view mirror 39
Manual seat 33
Mirrors 39
Rear seat head restraints 91
Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 35
Seat height 33, 35
Seats 32
Steering column height 38
Steering column length 38
Steering wheel 37
Air conditioner (cooling)
Turning off 156
Turning on 156
Air conditioner refrigerant 332

350 Index
Warning lamp 259
Break-in period 222
Bulbs, replacing 293
Additional turn signals 293
Brake lamps 294
Fog lamps 293
Front lamps 293
High beam 293
High mounted brake lamp 294
License plate lamps 294, 299
Low beam 293
Parking lamps 293, 294, 296, 297
Rear fog lamp 294
Rear fog lamps 298
Side marker lamps 294, 298
Standing lamps 293, 294, 296, 297
Tail lamp assemblies 294, 298
Turn signal lamps 293, 294
Button
Audio system 162C
CAC (Customer Assistance Center) 341
Calling up
Range (distance to empty) 134
Service indicator 250
CAN system 341
Capacities
Fuels, coolants, lubricants, etc. 330
Cargo compartment
Lighting 104
Cassette operation
Playing cassettes 172
Cassette player
Operating 116
Catalytic converter 231
CD changer* 175
CD operation 175
CD player
Operating 116
Center console 25Lower part 26
PASS.AIRBAG OFF indicator
lamp 263
Upper part 25
Centigrade
Setting temperature units 123
Central locking
From inside 88
Switch 88
Switching on/off
(control system) 129
Unlocking from inside 88
Central locking switch 88
Changing
Batteries (SmartKey) 290
Key setting 129
Changing CDs 175
Charging
Vehicle battery 308
CHECK ENGINE
malfunction indicator lamp 260
Check gas cap
Message in display 277

351 Index
Checking
Coolant level 235, 241
Oil level 235, 237
Tire inflate pressure 235
Vehicle lighting 235
Child safety 65
Airbags 58
Infant and child
restraint systems 62, 65
LATCH child seat mounts 70
Child seat mounts see LATCH child seat
mounts 70
Cigarette lighter 204
Cleaning
Cup holder 255
Gear selector lever 255
Hard plastic trim items 255
Headlamps 148
Headliner and shelf
below rear window 255
Instrument cluster 255
Leather upholstery 256
Light alloy wheels 254MB Tex upholstery 256
Plastic and rubber parts 256
Seat belts 255
Steering wheel 255
Upholstery 256
Windows 254
Windshield 50
Wiper blades 254
Wood trims 256
Climate control 150
Adjusting 153
Defogging windshield 153
Defrosting 154
Rear window defroster 149
Setting the temperature 153
Clock 23, 122
Closing
Glove box 200
Hood 237
power window with SmartKey 188Roller sunblind for the
sliding/pop-up roof 189
Side windows 187
Sliding/pop-up roof 190, 292
Trunk lid 86
Windows 186
Windows with SmartKey 188
Closing sliding/pop-up roof
In an emergency 292
Cockpit 20, 341
Cockpit management and data system
(COMAND*) 342
Collapsible tire 342
COMAND* 342
COMAND* see separate operating instruc-
tions
Combination switch 102
High beam flasher 102
Turn signals 48
Windshield wipers 49
Consumer information 339
Control and operation of radio
transmitters 230
Control system 109, 342

352 Index
AUDIO menu 114
Convenience submenu 129
Display digital speedometer 114
Functions 110, 113
Instrument cluster submenu 122
Lighting submenu 125
Malfunction memory menu 117
Menus 112, 113, 343
Multifunction display 109
Multifunction steering wheel 110
NAV menu 117
Selecting radio system 115
Settings menu 118
Standard display menu 114
Submenus 111, 113
TEL* menu 134
Trip computer menu 132
Vehicle submenu 128
Convenience submenu 129
Activating easy-entry/exit
feature 130Setting key dependency 131
Setting parking position for
exterior rear view mirror 132
Coolant 241, 336
Adding 241
Anticorrosion/antifreeze
quantity 336
Capacities 330
Checking level 241
Messages in display 271, 272
Temperature 232
Temperature indicator 106
Warning lamp 272
Coolant level
Checking 235, 241
Cruise control 194, 342
Canceling 195
Driving downhill 195
Driving uphill 195
Fine adjustment 196
Message in display 274
Saving current speed 195Setting speeds 196
Cruise control lever 194
Cruising range, fuel 335
Cup holder
Cleaning 255
In front seat armrest 201
Customer Assistance Center (CAC) 341
D
Daytime running lamp mode 100
Setting 125, 126
Deactivating
Air conditioning (cooling) 156
Air recirculation mode 155
Alarm 79
Anti-theft alarm system 79
Central locking (control system) 129
Climate control 151
Cruise control 195
Defrost 154
ESP 76