2004 MAZDA MODEL MPV wheel

8-30
Maintenance and Care
Owner Maintenance
Form No. 8S06-EA-03H

Replacing a Wheel
When replacing a wheel, make sure the
new one is the same as the original factory
wheel in diameter, rim width, and offset.
Proper tire balancing provides the best
riding comfort and helps reduce tread
wear. Out-of-balance tires can cause
vibration and uneven wear, such as
cupping and flat spots.
Using a Wrong-Sized Wheel:
Using a wrong-sized wheel is
dangerous. Braking and handling
could be affected, leading to loss of
control and an accident. Always use
wheels of the correct size on your
vehicle.
A wrong-sized wheel may adversely
affect:
•Tire fit
•Wheel and bearing life
•Ground clearance
•Snow-chain clearance
•Speedometer calibration
•Headlight aim
•Bumper height
WARNING
CAUTION
J16R_8S06-EA-03H_Edition1.book Page 30 Wednesday, July 9, 2003 4:19 PM

8-47
Maintenance and Care
Appearance Care
Form No. 8S06-EA-03H

Underbody Maintenance
Road chemicals and salt used for ice and
snow removal and solvents used for dust
control may collect on the underbody. If
not removed, they will speed up rusting
and deterioration of such underbody parts
as fuel lines, frame, floor pan, and exhaust
system, even though these parts may be
coated with anti-corrosive material.
Thoroughly flush the underbody and
wheel housings with lukewarm or cold
water at the end of each winter. Try also to
do this every month.
Pay special attention to these areas
because they easily hide mud and dirt. It
will do more harm than good to wet
down the road grime without removing
it.
The lower edges of doors, rocker panels,
and frame members have drain holes that
should not be clogged. Water trapped
there will cause rusting.

Aluminum Wheel Maintenance
A protective coating is provided over the
aluminum wheels. Special care is needed
to protect this coating. Don’t use steel wool, abrasive
cleaners, or strong detergents
containing highly alkaline or caustic
agents on chrome-plated or anodized
aluminum parts. This may result in
damage to the protective coating and
cause discoloration or paint
deterioration.
CAUTION
Driving with Wet Brakes:
Driving with wet brakes is dangerous.
Increased stopping distance or the
vehicle pulling to one side when
braking could result in a serious
accident. Light braking will indicate
whether the brakes have been
affected. Dry the brakes by driving
very slowly and applying the brakes
lightly until brake performance is
normal.
NOTE
•Don’t use a wire brush or any
abrasive cleaner, polishing
compound, or solvent on aluminum
wheels. They may damage the
coating.
•Only use a mild soap or neutral
detergent and always use a sponge
or soft cloth to clean the wheels.
Rinse thoroughly with lukewarm or
cold water. Also, be sure to clean
the wheels after driving on dusty or
salted roads. This helps prevent
corrosion.
•Avoid washing your vehicle in an
automatic car wash that uses high-
speed or hard brushes.
•If your aluminum wheels lose
luster, wax the wheels.
WARNING
J16R_8S06-EA-03H_Edition1.book Page 47 Wednesday, July 9, 2003 4:19 PM

9-15
Customer Information and Reporting Safety Defects
Form No. 8S06-EA-03H
Uniform Tire Quality Grading System (UTQGS)
This information relates to the tire grading system developed by the U.S. National
Highway Traffic Safety Administration for grading tires by tread wear, traction, and
temperature performance.

Tre a d We a r
The tread wear grade is a comparative rating based on the wear rate of the tire when tested
under controlled conditions on a specified government test course.
For example, a tire graded 150 would wear one-and-a-half times as well on the government
course as a tire graded 100.
The relative performance of tires depends upon the actual conditions of their use, however,
and may depart significantly from the norm because of variations in driving habits, service
practices and differences in road characteristics and climate.

Traction-AA, A, B, C
The traction grades, from highest to lowest, are AA, A, B, and C. These grades represent
the tire’s ability to stop on wet pavement as measured under controlled conditions on
specified government test surfaces of asphalt and concrete. A tire marked C may have poor
traction performance.

Temperature-A, B, C
The temperature grades A (the highest), B, and C, represent the tire’s resistance to the
generation of heat and its ability to dissipate heat when tested under controlled conditions
on a specified indoor laboratory test wheel.
Sustained high temperature can cause the material of the tire to degenerate and reduce tire
life, and excessive temperatures can lead to sudden tire failure.
Grade C corresponds to a level of performance which all passenger vehicle tires must meet
under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A represent
higher levels of performance on the laboratory test wheel than the minimum required by
law.
Uniform Tire Quality Grading System (UTQGS)
The traction grade assigned to this tire is based on braking (straight ahead) traction
tests and does not include acceleration cornering (turning), hydroplaning, or peak
traction characteristics.
WARNING
J16R_8S06-EA-03H_Edition1.book Page 15 Wednesday, July 9, 2003 4:19 PM

10-5
Specifications
Form No. 8S06-EA-03H

Capacities
(Approximate Quantities)
Check oil and fluid levels with dipsticks or reservoir gauges.

Dimensions
*1With license plate holder*217 inch wheel vehicle*3Rear drum brake*4Rear disc brake

We i g h t s

Air Conditioner
ItemUnit
L US qt Imp qt
Engine oilWith oil filter replacement 5.7 6.0 5.0
Without oil filter replacement 5.2 5.5 4.6
CoolantWith rear heater 12.0 12.7 10.6
Without rear heater 10.2 10.8 9.3
Automatic transaxle fluid 9.7 10.3 8.5
Washer fluidWith 4-Seasons package 5.5 5.8 4.8
Without 4-Seasons package 2.2 2.3 1.9
Fuel tank 75 19.8 (US gal) 16.5 (Imp gal)
Item Model
Overall lengthWithout GFX Package
4,807mm (189.3 in), 4,821mm (189.8 in)
*1
With GFX Package
4,813mm (189.5 in), 4,833mm (190.3 in)*1
Overall width 1,830mm (72.1 in)
Overall height
1,745 mm (68.7 in), 1,755 mm (69.1 in)*2
Front tread 1,540mm (60.6 in)
Rear tread
1,545mm (60.8 in)*3, 1,550mm (61.0 in)*4
Wheelbase 2,840mm (111.8 in)
Item Weight
GVWR (Gross Vehicle Weight Rating) 2,386kg (5,260 lb)
GAWR (Gross Axle Weight Rating)Front 1,189kg (2,621 lb)
Rear 1,218kg (2,685 lb)
Refrigerant complies with SAE J639 Maximum operating charge
HFC134a (R-134a)Front air-conditioner 0.6 kg (21.2 oz)
Front and rear air-conditioner 0.8 kg (28.2 oz)
J16R_8S06-EA-03H_Edition1.book Page 5 Wednesday, July 9, 2003 4:19 PM

10-7
Specifications
Form No. 8S06-EA-03H

Tires
Check the tire pressure label for tire size and inflation pressure. Refer to Tire Inflation
Pressure on page 8-27.
Standard tire
*1Steel wheel*2Aloy wheel
Temporary spare tire

Fuses
Refer to the fuse rating on page 8-38.
NOTE
The tires have been optimally matched with the chassis of your vehicle.
When replacing tires, Mazda recommends that you replace tires of the same type
originally fitted to your vehicle. For details, contact an Authorized Mazda Dealer.
Item Model
Tire size 205/65R15 94H 215/60R16 95H P215/60R17 95H
Rim size
15×6JJ
*1, 15×6J*216×6-1/2J 17×7J
Inflation pressure
240 kPa (35 psi or lb/po2) 240 kPa (35 psi or lb/po2) 240 kPa (35 psi or lb/po2)
Tire size Inflation pressure
T135/90D15 420 kPa (60 psi)
J16R_8S06-EA-03H_Edition1.book Page 7 Wednesday, July 9, 2003 4:19 PM

11-5
Index
Form No. 8S06-EA-03H
O
Odometer and Trip Meter ................ 5-21
Outside Mirrors
................................ 3-33
Overhead Console
............................ 6-49
Overhead Lights
............................... 6-42
Overheating
...................................... 7-15
Overloading
...................................... 4-11
P
Paint Damage ................................... 8-43
Parking Brake
..................................... 5-5
Parking in an Emergency
................... 7-2
Power Door Locks
........................... 3-10
Power Sliding Doors
........................ 3-13
Power Steering
................................. 5-14
Fluid
.......................................... 8-16
Power Windows
............................... 3-19
Push-Starting
.................................... 7-21
R
Rear Console .................................... 6-51
Rear Door Child Safety Locks
......... 3-12
Rear Quarter Windows
.................... 3-22
Rear Window Defroster
................... 5-38
Rear Window Washer
...................... 5-38
Rear Window Wiper
........................ 5-38
Rearview Mirror
............................... 3-34
Recreational Towing
........................ 7-23
Registering Your Vehicle in
A Foreign Country
........................... 9-12
Rocking the Vehicle
........................... 4-9
S
Safety Defects, Reporting ................9-17
Seat Belt System
2-point type
...............................2-37
3-point type
...............................2-33
Automatic locking
.....................2-32
Emergency locking
...................2-32
Extender
....................................2-39
Pregnant women
........................2-31
Pretensioner and load
limiting
......................................2-35
Seat belt precautions
.................2-30
Warning beep
............................2-40
Warning light
............................2-40
Seats
Flat folding
................................2-28
Front seat
(Electrically operated seats)
........2-8
Front seat
(Manually operated seats)
...........2-3
Second-row seats
.......................2-13
Third-Row Seat
.........................2-20
Second-row seats
..............................2-13
Security System
Immobilizer system
...................3-28
Theft-deterrent system
..............3-31
Service Publications
.........................9-18
Shopping Bag Hooks
........................6-52
Side Extention Sunvisors
.................6-41
Spare Tire and Tool Storage
...............7-3
Specifications
...................................10-4
Speedometer
.....................................5-21
SRS Air Bags
How the Air Bags Work
............2-63
Supplemental restraint systems
precautions
................................2-56
Starting the Engine
.............................5-3
Steering Wheel
.................................3-33
Horn
..........................................5-39
J16R_8S06-EA-03H_Edition1.book Page 5 Wednesday, July 9, 2003 4:19 PM

11-6
Index
Form No. 8S06-EA-03H
S
Storage Box ..................................... 6-50
Storage Compartments
..................... 6-49
Cargo securing loops
................ 6-51
Eyeglass holder
......................... 6-49
Front console
............................ 6-50
Glove box
................................. 6-50
Overhead console
..................... 6-49
Rear console
............................. 6-51
Shopping bag hooks
................. 6-52
Storage box
............................... 6-50
Under seat tray
.......................... 6-50
Sunroof/Moonroof
........................... 3-25
Sunshade
.......................................... 3-27
Sunvisors
.......................................... 6-41
T
Tachometer ...................................... 5-22
Temporary Spare Tire
...................... 8-29
Theft-Deterrent System
................... 3-31
Third-row seat
.................................. 2-20
Tiedown
Hook
......................................... 7-23
Tires
Flat tire
........................................ 7-3
Inflation pressure
...................... 8-27
Replacement
............................. 8-29
Rotation
.................................... 8-28
Snow tires
................................. 4-10
Spare tire and tool storage
.......... 7-3
Specifications
........................... 10-7
Tire chains
................................ 4-10
Uniform tire quality
grading system (UTQGS)
......... 9-15
Tool
.................................................... 7-3
Towing
Description
............................... 7-22
Emergency towing
.................... 7-22
T
Recreational towing .................. 7-23
Trailer towing
........................... 4-12
Traction Control System (TCS)
....... 5-18
TCS indicator light
.................... 5-18
TCS OFF indicator light
........... 5-19
TCS OFF switch
....................... 5-19
Trailer Towing
................................. 4-12
Trip Meter
........................................ 5-21
Turn and Lane-Change Signals
........ 5-35
U
Under Seat Tray ............................... 6-50
V
Vanity Mirrors .................................. 6-41
Vehicle Information Labels
............. 10-2
W
Warning Lights ................................ 5-24
ABS
........................................... 5-29
Air bag system
.......................... 5-29
Brake system
............................. 5-26
Charging system
....................... 5-27
Check engine
............................. 5-28
Door-ajar
................................... 5-30
Engine oil pressure
.................... 5-28
Front seat belt pretensioner
system
....................................... 5-29
Immobilizer system
................... 5-30
Low fuel
.................................... 5-30
Seat belt
..................................... 5-30
Warranty
............................................. 9-9
Washer Fluid
.................................... 8-18
Weights
............................................ 10-5
Wheel Replacement
......................... 8-30
J16R_8S06-EA-03H_Edition1.book Page 6 Wednesday, July 9, 2003 4:19 PM