2004 JEEP WRANGLER flat tire

WHAT TO DO IN EMERGENCIES
CONTENTS
mHazard Warning Flasher.................210
mIf Your Engine Overheats................210
mChanging A Flat Tire...................211
NTool Kit Location.....................211
NJack Location........................211NSpare Tire Location....................213
NTire Changing Procedures...............213mJump Starting.........................216
mTowing A Disabled Vehicle...............2196

Control to maximum heat, the Mode Control to floor, and
the Fan Control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads ªHº,
pull over and stop the vehicle. Idle the vehicle with
the air conditioner turned off until the pointer drops
back into the normal range. If the pointer remains on
the ªHº, and you hear continuous chimes, turn the
engine off immediately, and call for service.
CHANGING A FLAT TIRE
Tool Kit Location
The jack handle driver and jack extension are located in a
kit that is stored on the floor board to the right of the
front passenger seat. On some models, this tool kit is
under the carpeting in the same location.
Jack Location
The jack and lug wrench are stored under the front
passenger seat.
WHAT TO DO IN EMERGENCIES 211
6

To remove the jack from its stowage position, carefully
release the rubber strap from the bracket. Turn the thumb
screw counterclockwise to loosen jack and then remove it
from the bracket.
WARNING!
Always store the jack, lug wrench, jack handle
driver, jack extension, and spare, flat or damaged tire
securely in the proper place. Never leave them loose
in the vehicle where they could become dangerous
projectiles during a quick stop or collision.
WARNING!
The jack is designed to use as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes, unless suitable sup-
ports are placed under the vehicle as a safety mea-
sure. The vehicle should be jacked on a firm level
surface only. Avoid ice or slippery areas.
CAUTION!
Never use your vehicle jack on the bumpers, sills or
underbody of your vehicle. Damage may result.
Place your vehicle jack only under an axle and in the
positions shown for ªTire Changing Procedures.º
212 WHAT TO DO IN EMERGENCIES

²Get everyone out of the vehicle before you jack it up.
If the jack should fall, someone in the vehicle could be
hurt.
²Block tire diagonally oppo-
site tire to be changed to pre-
vent forward and backward
vehicle movement.
Instructions
1. Remove spare tire, jack and tools from stored location.
2. Before raising vehicle, loosen lug nuts on wheel with
flat tire.
3. Assemble the jack and jacking tools as shown. Connect
jack handle driver (1) to extension (2) then to lug wrench
(3).4. Operate jack from the front or the rear of the vehicle.
Place the jack under the axle tube, as shown.
214 WHAT TO DO IN EMERGENCIES

5. Use a clockwise rotation to raise the jack. Raise vehicle
just enough to be able to remove flat tire and install spare
tire.
6. Remove lug nuts and wheel.
7. Position spare wheel/tire on vehicle and install lug
nuts with cone-shaped end toward wheel. Lightly tighten
nuts clockwise. To avoid the risk of forcing the vehicle off
the jack, do not tighten the nuts fully until the vehicle has
been lowered.
8. Lower the vehicle by using a counterclockwise rota-
tion to lower the jack.
9. Finish tightening the lug nuts securely in crisscross
pattern as shown. Tighten to 85-110 ft. lbs. (115-149 N´m).10. Remove jack assembly and wheel blocks.
11. Secure jack, lug wrench, jack handle driver, jack
extension, and tire in proper locations.
WARNING!
Carefully follow these tire changing warnings to
help prevent personal injury or damage to your
vehicle:
WHAT TO DO IN EMERGENCIES 215
6

Hoses.............................. 243
Master Cylinder...................... 244
Parking............................ 175
Warning Light....................... 119
Brakes............................... 177
Brake/Transmission Interlock.............. 166
Break-In Recommendations, New Vehicle...... 39
Bulb Replacement...................... 257
Calibration, Compass..................... 47
Capacities, Fluid....................... 258
Caps, Filler
Fuel............................... 200
Power Steering....................... 236
Car Washes........................... 249
Carpeting............................. 252
Cassette Tape and Player Maintenance....... 148
Cassette Tape Player.........126,130,132,140,142
Catalytic Converter..................... 232
Caution, Exhaust Gas..................... 40
CD Changer........................133,138
CD Player......................128,135,137
CD Player Maintenance.................. 149Cellular Phone......................... 149
Chains, Tire........................... 196
Changing A Flat Tire.................... 213
Chart, Tire Sizing....................... 185
Check Engine Light..................... 118
Child Restraint.....................29,33,36
Child Restraint Tether Anchors............. 33
Cigar Lighter........................... 62
Climate Control........................ 149
Clock................................ 120
Clutch Interlocking Ignition System......160,165
Compact Disc Maintenance............... 149
Compact Disc Player.................... 140
Compass.............................. 46
Compass Calibration..................... 47
Compass Variance....................... 48
Console............................... 65
Console, Floor.......................... 65
Contract, Service....................... 282
Converter, Catalytic..................... 232
Cooling System........................ 239
Adding Coolant (Antifreeze)............. 241
Coolant Capacity..................... 258
INDEX 289
10

Hood Release.......................... 55
Hoses............................242,243
Hydraulic Clutch Fluid.................. 246
Ignition
Key ................................ 11
Illuminated Entry....................... 15
Infant Restraint.......................29,30
Inflation Pressure Tires................... 192
Inside Rearview Mirror................... 46
Instrument Cluster...................... 115
Instrument Panel and Controls............. 114
Interior Appearance Care................. 252
Interior Fuses.......................... 254
Interior Lights.......................... 56
Intermittent Wipers...................... 58
Introduction............................ 4
Jack Location.......................... 211
Jack Operation......................... 214
Jacking Instructions..................... 214
Jump Starting......................... 216Key, Programming....................... 13
Key Release Button...................... 11
Key, Replacement....................... 13
Key, Sentry............................ 12
Key-In Reminder........................ 12
Keys................................. 11
Lane Change and Turn Signals............. 116
Lap Belts.............................. 17
Lap/Shoulder Belts...................... 17
LATCH (Lower Anchors and Tether
for CHildren)........................... 33
Lead Free Gasoline...................... 197
Lighter, Cigar.......................... 62
Lights................................ 56
Airbag...........................29,118
Anti-Lock........................... 119
Anti-Lock Warning.................... 119
Brake Warning....................... 119
Check Engine........................ 118
Check Gauges........................ 118
Cruise.............................. 116
INDEX 293
10

Tire and Loading Information Placard....... 188
Tire Identification Number (TIN)........... 187
Tire Markings......................... 184
Tire Safety Information................... 184
Tires ................................ 191
Air Pressure......................... 192
Alignment.......................... 195
Alignment and Balance................. 195
Balancing........................... 195
Chains............................. 196
Changing........................ 211,213
General Information................... 191
High Speed......................... 193
Inflation Pressures.................... 192
Jacking............................. 214
Load Capacity....................... 188
Pressure Label....................... 192
Radial............................. 193
Replacement......................... 194
Rotation............................ 196
Sizes............................... 185
Spare Tire........................... 213
Spinning............................ 193Tread Wear Indicators.................. 194
Wheel Nut Torque.................... 215
To Open Hood.......................... 55
Torque Converter Clutch................. 170
Towing...........................202,219
Disabled Vehicle...................... 219
Recreational......................... 205
Trailering........................... 202
Trac-Lok Rear Axle...................... 173
Trailer Towing......................... 202
Hitches............................. 197
Transfer Case.......................... 247
Four-Wheel-Drive Operation............. 170
Maintenance......................... 247
Transmission
Automatic.......................... 165
Maintenance......................245,246
Manual............................. 163
Shifting............................ 163
Transporting Pets........................ 39
Tread Wear Indicators................... 194
Trip Odometer......................... 119
Trip Odometer Reset Button............... 119
298 INDEX