2004 HONDA PILOT check oil

µµ
To thoroughly f lush the
transmission, the technician
should drain and ref ill it with
Honda ATF-Z1 (Automatic
Transmission Fluid), then drive
the vehicle f or a short distance.
Do this three times. Then drain
and ref ill the transmission a f inal
time.
Insert the dipstick all the way back
into the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your Honda dealer. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule. Replace the
belt at 60,000 miles (100,000 km) if
you regularly drive your vehicle in
one or more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Frequently tow a trailer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
6.
Maint enance
Timing Belt
Dif f erential Oil
A utomatic T ransmission Fluid, Dif f erential Oil, T iming Belt
177
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

Let the vehicle sit f or a minute.
Open the hood, and check the oil
level (see page ). An engine
very low on oil can lose pressure
during cornering and other driving
maneuvers.
If necessary, add oil to bring the
level back to the full mark on the
dipstick (see page ).
Start the engine, and watch the oil
pressure light. If it does not go out
within ten seconds, turn off the
engine. There is a mechanical
problem that needs to be repaired
bef ore you can continue driving.
(Seeon page
).
This light should never
come on when the engine is
running. If it starts f lashing or stays
on, the oil pressure has dropped very
low or lost pressure. Serious engine
damage is possible and you should
take immediate action. Saf ely pull of f the road, and shut
of f the engine. Turn on the hazard
warning lights.
If the charging system
indicator comes on brightly
when the engine is running, the
battery is not being charged.
Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly.
Go to a service station or garage
where you can get technical
assistance.
1.
2.
3.
4.
171
127
208
L ow Oil Pressure Indicator
Emergency T owingCharging System Indicator
T aking Care of t he Unexpect ed
L ow Oil Pressure L ight, Charging System Indicator
206
NOTICE:
Running the engine with low
oil pressure can cause serious
mechanical damage almost immediately.
Turn of f the engine as soon as you can
saf ely get the vehicle stopped.

CONT INUED
BatteryCharging System ...........................
Indicator .48, 206
............................
Jump Starting .202
..............................
Maintenance .193
............................
Specif ications .219
..............................
Bef ore Driving .123
....................................
Belts,Seat .8,16
...........................
Beverage Holders .77
..................................
Booster Seats .39 Brakes
...........
Anti-lock System (ABS) . 145
.............
Break-in, New Linings . 124
...........................................
Fluid .178
....................
Bulb Replacement .182
.........................................
Parking .75
.................
System Indicator . 49,208
........................
Wear Indicators .145
.............................
Braking System .144
.................
Break-in, New Vehicle . 124
..
Brightness Control, Instruments . 59
........................
Brights, Headlights .58
Bulb Replacement ..............................
Brake Lights .182
................
Front Parking Lights . 181
........
Front Side Marker Lights . 183
.................................
Headlights .180
........
High-mount Brake Lights . 182
.................................
Rear Bulbs .182
............................
Specif ications .219
.............
Turn Signal Light . 181,182
..............................
Bulbs, Halogen .180
...
Accessories and Modif ications . 129
ACCESSORY (Ignition Key .......................................
Position) .64
..............
Accessory Power Sockets . 77
....................
Additives, Engine Oil . 172
...............................
Airbag (SRS) .9, 19
.....
Airbags, Additional Infomation . 19
...
Additional Safety Precautions . 24
.............................
Airbag Service .24
How the Side Airbag Of f ......................
Indicator Works .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .20
...
How Your Side Airbags Work . 22
........................
SRS Components .19
................
Air Conditioning System . 82
.......................
Rear A/C Control .87
.......................
Air Pressure, Tires .188
......................................
Antif reeze .174
Anti-lock Brakes (ABS) ....................
Indicator Light .49, 146
...................................
Operation .145
..............
Anti-thef t, Audio System . 102 .
Anti-thef t Steering Column Lock . 64
..................................
Audio System .88
...
Automatic Seat Belt Tensioners . 18
...
Automatic Lighting Off Feature . 58
.............
Automatic Speed Control . 116
..............
Automatic Transmission . 138
..........................
Capacity, Fluid .218
...............
Checking Fluid Level . 176
.......................................
Shif ting .138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 139
....................
Shif t Lock Release . 141
Index
A
B
I

Î
................................
Cancel Button .117
............................
Capacities Chart .218
.............
Carbon Monoxide Hazard . 42
........................
Cargo, .131
Cassette Player ..............................................
Care .95
.....................................
Operation .98
..............
CAUTION, Explanation of . ii
...........................................
CD Care .95
.....................................
CD Changer .94
.........
CD Changer Error Message . 97
.........................................
CD Player .93
.............
CD Player Error Message . 96
........................
Certif ication Label .216
...................................
Chains, .192
....................
Changing a Flat Tire .197
Change Oil ........................................
How to .172
.............................
When to .164, 165
...
Charging System Indicator . 48,206
............
Checklist, Bef ore Driving . 136
..................
Childproof Door Locks . 65
.....................................
Child Saf ety .25
..............................
Booster Seats .39 ...................................
Child Seats .30
.....
Important Saf ety Reminders . 25
..........................................
Inf ants .29
..........................
Larger Children .38
.........................................
LATCH .33
......................
Risks with Airbags .26
.............................
Small Children .30
.........................................
Tethers .37
.........
Where Should a Child Sit? . 26
Child Seats .........................................
LATCH .33
...........................
Lower Anchors .33
..........
Tether Anchorage Points . 37
.................
Climate Control System . 86
.........................
Clock, Setting the .103
..............................................
Clock .103
.....................
Code, Audio System .102
........................
CO in the Exhaust .223
............
Cold Weather, Starting in . 137
.......................
Compact Spare .196
...................
Console Compartment . 77
...............
Consumer Inf ormation . 230
.............
Controls, Instruments and . 45
Coolant ........................................
Adding .174
....................................
Checking .127 .........................
Proper Solution .174
...................
Temperature Gauge . 55
Crankcase Emissions Control ........................................
System .223
................
Cruise Control Indicator . 51
............
Cruise Control Operation . 116
.....................................
Cup Holders .77
....
Customer Service Inf ormation . 230
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 46
................
Daytime Running Lights . 59
Daytime Running Lights .......................................
Indicator .51
.................................
Dead Battery .202
............
Def ects, Reporting Saf ety . 232
................
Def ogger, Rear Window . 60
..........
Def rosting the Windows . 83,85
....................................
Dimensions .218
...............
Dimming the Headlights . 58
Dipstick ..........
Automatic Transmission . 176
..................................
Engine Oil .127
..........................
Directional Signals .58
how to carry
tires tire
Index
C
D
II

.....................................
Fan, Interior .82
Features, Comfort and ................................
Convenience .81
....................
Filling the Fuel Tank . 125
Filters ...............................................
Oil .172
.............
Flashers, Hazard Warning . 59
...................
Flat Tire, Changing a . 197
Fluids ..........
Automatic Transmission . 176
..........................................
Brake .178
..........................
Power Steering .179
..................
Windshield Washer . 175
FM Stereo Radio .....................................
Reception .91
...................
Folding the Third Seat . 71
..........................
Four-way Flashers .59
............................
Front Airbags .10, 19
Front Seat ................................
Adjusting .68, 69
.........................................
Heaters .67
.....................................
Airbags .9, 19
........
Disc Brake Wear Indicators . 145
.....................
Disposal of Used Oil .173
Doors ..............
Locking and Unlocking . 65
....................
Lockout Prevention . 65
......................
Power Door Locks .65
..........
DOT Tire Quality Grading . 220
...........
Driver and Passenger Safety . 5
...........................................
Driving .135
....................................
Economy .128
...................................
DVD Player .104
........
DVD Player Error Message . 112
..............................
Economy, Fuel .128
Emergencies ............................
Jump Starting .202
.......................................
Towing .208
..............
Hazard Warning .59
............
Emergencies on the Road . 195
.............
Battery, Jump Starting . 202
...........
Brake System Indicator . 208
................
Changing a Flat Tire . 197
.....
Charging System Indicator . 206
..................
Checking the Fuses . 210 .....
Low Oil Pressure Indicator . 206
...
Malf unction Indicator Lamp . 207
..................
Overheated Engine . 204
...........................
Emergency Brake .75
......................
Emergency Flashers .59
......................
Emergency Towing .208
.......................
Emissions Controls .223
.............
Emissions Testing, State . 226
Engine ....
Coolant Temperature Gauge . 55
.............................. 137
Malf unction Indicator ................................
Lamp .48, 207
........
Oil Pressure Indicator . 48,206
..............
Oil, What Kind to Use . 171
...............................
Overheating .204
............................
Specif ications .219
............................
Speed Limiter .140
.......................................
Starting .137
.
Evaporative Emissions Controls . 223
...............................
Exhaust Fumes .42
Exhaust Gas Recirculation ........................................
System .224
Expectant Mothers, Use of Seat ........................................
Belts by .15
CONT INUED
Button If it won’t start
Index
E F
III

..................................................
Keys .62
......................................
Low Fuel .51
........................
Low Oil Pressure .48
...........................
Side Airbag Of f .48
...............................................
SRS .48
Turn Signal and Hazard ...................................
Warning .50
..........................................
VTM- 4 .52
..............................
Washer Level .51
.........
Indicators, Instrument Panel . 47
.........................
Inf ant Restraint .26, 29
................................
Inf ant Seats .26, 29
...................
Inf lation, Proper Tire . 188
...................................
Inside Mirror .74
.............................
Inspection, Tire .189
........................
Instrument Panel .2 ,46
........
Instrument Panel Brightness . 59
........................................
Introduction . i
.................
Jacking up the Vehicle . 198
.......................................
Jack, Tire .197
................................
Jump Starting .202 .......................
Label, Certif ication .216
.................
Lane Change, Signaling . 58
..................
Lap/Shoulder Belts . 12,17
...........
LATCH Anchorage System . 33
.................................................
Light .79
.............................................
Lights .180
....................
Bulb Replacement .180
.......................................
Indicator .47
.........................................
Parking .58
..................................
Turn Signal .58
....................................
Load Limits .132
......
LOCK (Ignition Key Position) . 64
Locks .......
Anti-thef t Steering Column . 64
............................
Fuel Fill Door .125
....................................
Glove Box .78
....................
Lockout Prevention . 65
.................................
Power Door .65
........................
Low Coolant Level .127
.........................
Low Fuel Indicator .51 ...
Low Oil Pressure Indicator . 48,206
.................................
Lower Anchor .33
...
Lubricant Specif ications Chart . 218
..............
Luggage, .131
...................
Neutral Gear Position . 139
..................
New Vehicle Break-in . 124
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 216
..................................
Maintenance .159
Owner’s Maintenance ...................................
Checks .163
.................................
Record .167-169
......................
Required Indicator .53
..........................................
Saf ety .160
.............................
Schedule .164-166
.
Malf unction Indicator Lamp . 48,207
..............
Manual Seat Adjustments . 69
...............................
Meters, Gauges .54
.................................
Modif ications .130
CONT INUED
Storing (Cargo)
Index
J K
L
M
N
V

...
Octane Requirement, Gasoline . 124
.........................................
Odometer .54
...............................
Odometer, Trip .54
....................
Of f -Highway Driving . 155
...................
Of f -Road Precautions . 155
Oil ........................
Change, How to .172
..............
Change, When to . 164,165
......................
Checking Engine .127
..............
Pressure Indicator . 48,206
Selecting Proper Viscosity ......................................
Chart .171
...........
ON (Ignition Key Position) . 64
Onboard Ref ueling Vapor ................................
Recovery .223
..............................
Outside Mirrors .74
....................
Overheating, Engine .204
....
Owner’s Maintenance Checks . 163 ...................
Radiator Overheating . 204
Radio/CD Sound ..........................................
System .88
..........................
Readiness Codes .226
.................................
Rear A/C Unit .87
............
Rear Audio Control Panel . 107
........
Rear Entertainment System . 104
..
Rear Lights, Bulb Replacement . 182
............................
Rear View Mirror .74
.................
Rear Window Def ogger . 60
.
Rear Window Wiper and Washer . 57
.........
Reclining the Seat Backs . 68,69
...........
Reclining the Second Seats . 70
................
Reclining the Third Seat . 71
.............................
Reminder Lights .47
................
Remote Audio Controls . 101
.................
Remote Control (RES) . 109
.......................
Remote Transmitter .66
Replacement Inf ormation ..............
Dust and Pollen Filter . 185
................
Engine Oil and Filter . 172
.................................
Floor Mats .185
..........................................
Fuses .210
................................
Light Bulbs .180
..............
Panel Brightness Control . 59
........................
Park Gear Position .139 ...........................................
Parking .143
.................................
Parking Brake .75
Parking Brake and Brake System ...............................
Indicator .49, 208
.................................
Parking Lights .58
..
Parking Over Things that Burn . 225
............................
Playing the Radio .88
....................................
Playing a CD .93
....................
Playing a CD Changer . 94
.................................
Playing a Tape .98
.............................
PGM-FI System .224
..........................
Power Door Locks .65
................
Power Seat Adjustments . 68
.................
Power Socket Locations . 76
..............................
Power Windows .73
.........
Pregnancy, Using Seat Belts . 15
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 16
.....
Advice f or Pregnant Women . 15
........................
Protecting Children .25
.....................
General Guidelines .25
...........................
Protecting Inf ants .29
...........
Protecting Larger Children . 38
.............
Protecting Small Children . 30
Index
O
P R
VI

....
START (Ignition Key Position) . 64
.......................
Starting the Engine .137
In Cold Weather at High ..................................
Altitude .137
................
With a Dead Battery . 202
..............
State Emissions Testing . 226
........
Steam Coming f rom Engine . 204
Steering Wheel ..................................
Adjustment .61
.............
Anti-theft Column Lock . 64
...............................
Buttons .101, 116
.....................
Stereo Sound System .88
....................
Storing Your Vehicle .194
..........................
Sunglasses Holder .78
..........................................
Sun Visor .79
Supplemental Restraint System ......................................
Servicing .24
.........................
SRS Indicator .23 ,48
...................
System Components . 19
..................................
Synthetic Oil .172
......
Taillights, Changing Bulbs in . 182
.
Taking Care of the Unexpected . 195
......................................
Tape Player .98 Technical Descriptions
......
DOT Tire Quality Grading . 220
.....
Emissions Control Systems . 223
..........
State Emissions Testing . 226
Three Way Catalytic ...............................
Converter .225
.......................
Temperature Gauge .55
..........
Temperature, Inside Sensor . 87
....................
Temperature, Outside . 55
...................
Tensioners, Seat Belts . 18
........
Testing of Readiness Codes . 226
..............
Tether Anchorage Points . 37
............................
Thef t Protection .102
..
Three Way Catalytic Converter . 225
..........................
Time, Setting the .103
..................
Tilt the Steering Wheel . 61
....................................
Timing Belt .177
....................................
Tire Chains .192
.........
Tire, How to Change a Flat . 197
...............................................
Tires .188
..............................
Air Pressure .188
...................................
Balancing .190
.........................
Checking Wear .189
..........................
Compact Spare .196
......
DOT Tire Quality Grading . 220
......................................
Inf lation .188 ..................................
Inspection .189
..............................
Maintenance .190
...................................
Replacing .191
......................................
Rotating .190
...........................................
Snow .191
............................
Specif ications .219
................................
Tire Chains .192
..........................
Winter Driving .191
...................
Tools, Tire Changing . 197
Towing .....................................
A Trailer .147
................
Emergency Wrecker . 208
....
Equipment and Accessories . 151
.......................
Traction Devices .192
Your Vehicle Behind a ............................
Motorhome .154
.............................
Weight Limit .150
.............................
Trailer Loading .147
......................
Trailer Towing Tips .152
Transmission ...............
Checking Fluid Level . 176
...........................
Fluid Selection .176
..............
Identif ication Number . 216
.............
Shif ting the Automatic . 138
.....................................
Treadwear .220
.......................................
Trip Meter .54
Index
T
VIII