2004 HONDA CIVIC HATCHBACK check engine light

̵
ÌÌ Follow the Severe Maintenance
Schedule if you drive your vehicle
MAINLY under one or more of the
f ollowing conditions:
Extensive idling or long periods of
stop and go driving, such as a taxi or
a commercial delivery vehicle.
Driving with a roof rack, or driving
in mountainous conditions.
Driving less than 5 miles (8 km) per
trip or, in f reezing temperatures,
driving less than 10 miles (16 km)
per trip.
Driving in extremely hot [over 90°F
(32°C)] conditions.
Driving on muddy, dusty, or de-iced
roads.
Follow the
Maintenance Schedule f or Severe
Conditions.
Maint enance Canadian Owners
134 miles x 1,000
km x 1,000
((OOtthheerrwwiisseeaaddjjuussttoonnllyyiiffnnooiissyy))
((OOrreevveerryy22yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))Every 15,000 miles (24,000 km) (Use normal schedule
except in dusty conditions)
10 16
2032 304840645080 70
112 80
128 100160
Check oil and coolant at each fuel stop 130208
140224
Service the items listed at the indicated distance (or time, if given).
Every 10,000 miles (16,000 km)
Check inflation and condition once a month
Every 5,000 miles (8,000 km) or every 6 months, whichever comes first
((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
60 96 90
144 120192150240
((OOrreevveerryy33yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))Every 160,000 miles (256,000 km) 110 176
120,000 miles (192,000 km) or 10 years, then every 60,000 miles (96,000 km) or 5 years
Every 3 years (independent of mileage) See information on maintenance and
emission warranty on page .
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page 160)
Replace engine oil filter
Inspect front and rear brake wear
Lubricate all hinges, locks, and latches
Visually inspect the following items:
Tie rod ends, steering gear box, and boots
Suspension components, Driveshaft boots
Check parking brake adjustment
Inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system , Fuel lines and connections
Lights and controls/vehicle underbody
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace manual transmission fluid
Inspect idle speed
Replace engine coolant
Replace brake fluid :
132Maintenance Schedule for Severe Conditions
——y
y
()y
y

When the radiator and engine are
cool, relieve any pressure in the
cooling system by turning the
radiator cap counterclockwise,
without pressing down.
Remove the radiator cap by
pushing down and turning
counterclockwise.The coolant level should be up to
the base of the f iller neck. Add
coolant if it is low.
Pourthecoolantslowlyand
caref ully so you do not spill. Clean
up any spill immediately; it could
damage components in the engine
compartment.
Put the radiator cap back on and
tighten it.
Pour coolant into the reserve tank.
Fill it to half way between the MAX
and MIN marks. Put the cap back
on the reserve tank.
Do not add any rust inhibitors or
other additives to your vehicle’s
cooling system. They may not be
compatible with the coolant or
engine components. Check the f luid level in the
windshield washer reservoir at least
monthly during normal use.
The low washer
level indicator will light when the
level is low.
Fill the reservoir with a good-quality
windshield washer f luid. This
increases the cleaning capability and
prevents f reezing in cold weather.
When you ref ill the reservoir, clean
the edges of the windshield wiper
blades with windshield washer fluid
on a clean cloth. This will help to
condition them.
2. 3. 4. 5.
1.
On Canadian models:
Engine Coolant, Windshield Washers
Maint enance Windshield Washers
142 NOTICE:
RADIATOR CAP
Do not use engine antif reeze
or a vinegar/water solution in the
windshield washer reservoir. Antif reeze
can damage your vehicle’s paint, while
a vinegar/water solution can damage
the windshield washer pump. Use only
commercially-available windshield
washer f luid.
——y
y
()y
y

You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run.When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
thefusesareOK,thereis
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ).
If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page
).
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See
on page .
Check the transmission interlock.
The clutch pedal must be pushed
all the way to the f loor or the
starter will not operate.
Check these things:
Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):
173185
162
173
Nothing Happens or the Starter
Motor Operates Very Slowly
Emergency T owing
Jump Starting T aking Care of t he Unexpect ed
If theEngineWon’tStart
171
——y


y
()y
y

In this case, the starter motor’s
speed sounds normal, or even f aster
than normal, when you turn the
ignition switch to START (III), but
the engine does not run.Do you have f uel? Check the f uel
gauge; the warning light may not
be working.
There may be an electrical
problem, such as no power to the
f uel pump. Check all the f uses
(see page ).
Are you using a properly coded
key? An improperly coded key will
cause the immobilizer system
indicator in the dash panel to blink
rapidly(seepage ).
Are you using the proper starting
procedure? Ref er to
on page . If youfindnothingwrong,youwill
need a qualif ied technician to f ind
the problem. See
on page .
123 65 181
185
T he Starter Operates Normally
Starting the
Engine Emergency
Towing
If theEngineWon’tStart
T aking Care of t he Unexpect ed
172
——y

y
()y
y

µ
´ ´
Although this seems like a simple
procedure, you should take several
precautions.
Connect the second jumper cable
to the negative ( ) terminal on
the booster battery. Connect the
other end to the grounding strap
as shown. Do not connect this
jumper cable to any other part of
the engine.
If the booster battery is in another
vehicle, have an assistant start
that vehicle and run it at a fast idle.
Open the hood, and check the
physical condition of the battery.
In very cold weather, check the
condition of the electrolyte. If it
seems slushy or like ice, do not try
jump starting until it thaws.
Turn of f all the electrical
accessories: heater, A/C, stereo
system, lights, etc. Put the
transmission in Neutral and set
the parking brake.
Connect one jumper cable to the
positive ( ) terminal on your
battery. Connect the other end to
the positive ( ) terminal on the
booster battery.
1. 2. 3.
4. 5.
Jump Starting
T aking Care of t he Unexpect ed
173
NOTICE:
A battery can explode if you do
not follow the correct procedure,
seriously injuring anyonenearby.
Keep all sparks, open flames,
and smoking materials away
from the battery. If a battery sits in extreme
cold, the electrolyte inside can f reeze.
Attempting to jump start with a f rozen
battery can cause it to rupture.
——y


y
()y
y

Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are of f .
Remove the cover f rom the f use
box.
Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Remove the screws with a
phillips-head screwdriver.
The vehicle’s f uses are located in
two fuse boxes. The interior fuse
box is located underneath the
steering column. To open it, turn the
knobsasshown.
If something electrical in your
vehicle stops working, check f or a
blown f use f irst. Determine f rom the
chart on pages and ,or the
diagram on the f use box lid, which
f uses control that device. Check
those fuses first, but check all the
f uses bef ore deciding that a blown
f use is the cause. Replace any blown
f uses, and check if the device works.
The under-hood f use box is located
in the back of the engine
compartment on the lef t side. To
open it, push the tabs as shown. 1. 2. 3.
183 184
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
181
UNDER-HOOD
INTERIOR
FUSE
BLOWN
——y

y
()y
y

Bulb Replacement..........................
Back-up Lights . 149
..................................
Stop Light . 149
................
Front Parking Lights . 148
........
Front Side Marker Lights . 147
.................................
Headlights . 145
.........
High-mount Brake Light . 150
.................
License Plate Lights . 152
..................
Side Marker Lights . 147
...........
Side Turn Signal Lights . 151
............................
Specif ications . 191
....................
Turn Signal Lights . 146
..............................
Bulbs, Halogen . 145
.........
Cables, Jump Starting With . 173
............................
Capacities Chart . 190
.............
Carbon Monoxide Hazard . 47
...........................
Cargo Area Cover . 75
........................
Cargo, . 117
Cassette Player
............................................
Care . 102
...................................
Operation . 101
..............
CAUTION, Explanation of . ii
...........................................
CD Care . 97 .....................................
CD Changer . 96
.........
CD Changer Error Message . 99
.........................
CD Error Message . 98
.........................................
CD Player . 96
........................
Certif ication Label . 188
...................................
Chains, tires . 161
Change Oil
........................................
How to . 139
......................................
When to . 133
....................
Changing a Flat Tire . 167
...
Charging System Indicator . 52, 177
Checking
.....................
Battery Condition . 162
................................
Brake Fluid . 144
...............................
Clutch Fluid . 144
..........................
Engine Coolant . 114
..................................
Engine Oil . 113
..........................................
Fuses . 181
...................
Transmission Fluid . 143
............
Checklist, Bef ore Driving . 122
.....................................
Child Saf ety . 29
..............................
Booster Seats . 44
...................................
Child Seats . 36
.....
Important Saf ety Reminders . 31
..........................................
Inf ants . 34
............................
Large Children . 43 .........................................
LATCH . 38
......................
Risks with Airbags . 30
.............................
Small Children . 35
.........................................
Tethers . 39
.........
Where Should a Child Sit? . 30
..............................................
Clock . 104
.........................
Clock, Setting the . 104
...................................
Clutch Fluid . 144
........................
CO in the Exhaust . 194
............
Cold Weather, Starting in . 123
.......................
Compact Spare . 166
...................
Console Compartment . 83
.............
Controls, Instruments and . 49
Coolant
........................................
Adding . 141
....................................
Checking . 114
.........................
Proper Solution . 141
...................
Temperature Gauge . 57
Crankcase Emissions Control ........................................
System . 194
...............................
Cruise Control . 105
........
Cruise Control Indicator . 54, 105
.....................................
Cup Holders . 83
how to carry tire
Index
C
II
——y


y
()yy

CONT INUED
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 50
................
Daytime Running Lights . 61
Daytime Running Lights
.......................................
Indicator . 53
...........
Dead Battery, What to Do . 173
............
Def ects, Reporting Saf ety . 202
..........................
Def og and Def rost . 89
................
Def ogger, Rear Window . 62
................
Def rosting the Windows . 89
....................................
Dimensions . 190
...............
Dimming the Headlights . 61
Dipstick
..................................
Engine Oil . 113
..........................
Directional Signals . 61
Disabled, Towing Your Vehicle
..................................................
If . 185
........
Disc Brake Wear Indicators . 127
.....................
Disposal of Used Oil . 140
Doors
..............
Locking and Unlocking . 67
..........
DOT Tire Quality Grading . 192
Downshif ting, 5-speed Manual
.............................
Transmission . 124 ...........
Driver and Passenger Safety . 5
...........................................
Driving . 121
....................................
Economy . 114
..............................
Economy, Fuel . 114
............
Emergencies on the Road . 165
.............
Battery, Jump Starting . 173
...........
Brake System Indicator . 179
................
Changing a Flat Tire . 167
.....
Charging System Indicator . 177
..................
Checking the Fuses . 181
.....
Low Oil Pressure Indicator . 177
...
Malf unction Indicator Lamp . 178
..................
Overheated Engine . 174
...........................
Emergency Brake . 80
......................
Emergency Flashers . 62
......................
Emergency Towing . 185
.......................
Emissions Controls . 194Engine
Coolant Temperature .......................................
Gauge . 58
.............................. 171
Malf unction Indicator ................................
Lamp . 53, 178 ........
Oil Pressure Indicator . 52, 177
..............
Oil, What Kind to Use . 138
...............................
Overheating . 174
............................
Specif ications . 190
...................
Engine Speed Limiter . 125
.
Evaporative Emissions Controls . 194
...............................
Exhaust Fumes . 47
Expectant Mothers, Use of Seat
........................................
Belts by . 17
.....................................
Fan, Interior . 86
Features, Comfort and
................................
Convenience . 85
....................
Filling the Fuel Tank . 111
Filter
...............................................
Oil . 139
5-speed Manual Transmission ...............
Checking Fluid Level . 143
................................
Shif ting the . 124
.............
Flashers, Hazard Warning . 62
...................
Flat Tire, Changing a . 167
If it won’t start
Index
E
F
D
III
——y

y
()y
y