To replace the battery:
1. Twist a thin coin between the two
halves of the remote entry
transmitter near the key ring. DO
NOT TAKE THE RUBBER COVER
AND CIRCUIT BOARD OFF THE
FRONT HOUSING OF THE
REMOTE ENTRY TRANSMITTER.
2. Do not wipe off any grease on the
battery terminals on the back
surface of the circuit board.
3. Remove the old battery.
4. Insert the new battery. Refer to the diagram inside the remote entry
transmitter for the correct orientation of the battery. Press the battery
down to ensure that the battery is fully seated in the battery housing
cavity.
5. Snap the two halves back together.
Note:Replacement of the battery will notcause the remote transmitter
to become deprogrammed from your vehicle. The remote transmitter
should operate normally after battery replacement.
Replacing lost remote entry transmitters
If you would like to have your remote entry transmitter reprogrammed
because you lost one, or would like to buy additional remote entry
transmitters, you can either reprogram them yourself, or take all
remote entry transmitters to your authorized dealer for
reprogramming.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Locks and Security
66
Wheel lug nut torque specifications
Retighten the lug nuts to the specified torque at 800 km (500 miles)
after any wheel disturbance (tire rotation, changing a flat tire, wheel
removal, etc.).
Bolt size Wheel lug nut torque*Nm Lb-ft
M12 x 1.5 115-156 85-115
* Torque specifications are for nut and bolt threads free of dirt and
rust. Use only Ford recommended replacement fasteners.
When a wheel is installed, always remove any corrosion, dirt or
foreign materials present on the mounting surfaces of the wheel
or the surface of the front disc brake hub and rotor that contacts the
wheel. Installing wheels without correct metal-to-metal contact at the
wheel mounting surfaces can cause the wheel nuts to loosen and the
wheel to come off while the vehicle is in motion, resulting in loss of
control.
JUMP STARTING YOUR VEHICLE
The gases around the battery can explode if exposed to flames,
sparks, or lit cigarettes. An explosion could result in injury or
vehicle damage.
Batteries contain sulfuric acid which can burn skin, eyes and
clothing, if contacted.
Do not attempt to push-start your vehicle. Automatic
transmissions do not have push-start capability; doing so may
damage the catalytic converter.
Preparing your vehicle
Your battery is located in the trunk of your vehicle.
When the battery is disconnected or a new battery is installed, the
transmission must relearn its shift strategy. As a result, the transmission
may have firm and/or soft shifts. This operation is considered normal and
will not affect function or durability of the transmission. Over time, the
adaptive learning process will fully update transmission operation to its
optimum shift feel.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Roadside Emergencies
141
BATTERY
Your vehicle is equipped with a
Motorcraft maintenance-free battery
which is located in the luggage
compartment, next to the spare tire.
Your battery is designed to purge any battery gases to the outside of the
vehicle by means of a vent hose. This vent hose MUST be attached at all
times. Replacement batteries must be of the same vented design.
If your battery has a cover/shield, make sure it is reinstalled
after the battery has been cleaned or replaced.
Your battery normally does not require additional water during its life of
service. For longer, trouble-free operation, keep the top of the battery
clean and dry. Make certain that the vent hose is attached. Also, make
certain the battery cables are always tightly fastened to the battery
terminals.
If you see any corrosion on the battery or terminals, remove the cables
from the terminals and clean with a wire brush. You can neutralize the
acid with a solution of baking soda and water.
Batteries normally produce explosive gases which can cause
personal injury. Therefore, do not allow flames, sparks or lighted
substances to come near the battery. When working near the battery,
always shield your face and protect your eyes. Always provide proper
ventilation.
When lifting a plastic-cased battery, excessive pressure on the
end walls could cause acid to flow through the vent caps,
resulting in personal injury and/or damage to the vehicle or battery.
Lift the battery with a battery carrier or with your hands on opposite
corners.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
168
A
Accessory delay ..........................40
Air bag supplemental restraint
system ....................................86, 94and child safety seats ..............87
description ..........................86, 94
disposal ......................................97
driver air bag ......................88, 95
indicator light .....................89, 96
operation .............................88, 95
passenger air bag ...............88, 95
passenger deactivation
switch ........................................90
side air bag ................................94
Air cleaner filter .......186 –187, 201
Air conditioning ..........................22
Antifreeze
(see Engine coolant) ................170
Anti-lock brake system
(see Brakes) ......................112 –113
Anti-theft system ........................72 arming the system ....................72
disarming a triggered system ..72
Audio system (see Radio) .........16
Automatic transmission driving an automatic
overdrive .................................116
fluid, adding ............................186
fluid, checking ........................186
fluid, refill capacities ..............201
fluid, specification ..................205
Auxiliary power point .................39
Axle lubricant specifications ..203, 205
refill capacities ........................201
B
Battery .......................................168 acid, treating emergencies .....168
jumping a disabled battery ....141
maintenance-free ....................168
replacement, specifications ...201
servicing ..................................168
BeltMinder ...................................81
Brakes ........................................112 anti-lock ...........................112 –113
anti-lock brake system (ABS)
warning light ...........................112
fluid, checking and adding ....186
fluid, refill capacities ..............201
fluid, specifications .........203, 205
lubricant specifications ..203, 205
parking ....................................113
shift interlock ..........................115
Bulbs ............................................30
C
Capacities for refilling fluids ....201
Cassette tape player ...................16
Cell phone use ............................60
Certification Label ....................206
Changing a tire .........................136
Child safety restraints ................97 child safety belts ......................97
Child safety seats ......................100 attaching with tether straps ..104
in front seat ............................101
in rear seat ..............................101
LATCH .....................................107
Cleaning your vehicle engine compartment ..............158
instrument panel ....................160
interior .....................................161
interior trim ............................160
plastic parts ............................159
washing ....................................157
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
Index
212