2004 FORD THUNDERBIRD checking oil

WINDSHIELD WASHER FLUID
Add fluid to fill the reservoir if the
level is low. In very cold weather, do
not fill the reservoir completely.
Only use a washer fluid that meets
Ford specification WSB-M8B16–A2.
Refer to Lubricant specifications
in this chapter.
State or local regulations on volatile organic compounds may restrict the
use of methanol, a common windshield washer antifreeze additive.
Washer fluids containing non-methanol antifreeze agents should be used
only if they provide cold weather protection without damaging the
vehicle ’s paint finish, wiper blades or washer system.
If you operate your vehicle in temperatures below 4.5 °C (40 °
F), use washer fluid with antifreeze protection. Failure to use
washer fluid with antifreeze protection in cold weather could result in
impaired windshield vision and increase the risk of injury or accident.
Note: Do not put washer fluid in the engine coolant reservoir. Washer
fluid placed in the cooling system may harm engine and cooling system
components.
ENGINE OIL
Checking the engine oil
Refer to the scheduled maintenance guide for the appropriate intervals
for checking the engine oil.
1. Make sure the vehicle is on level ground.
2. Turn the engine off and wait a few minutes for the oil to drain into the
oil pan.
3. Set the parking brake and ensure the gearshift is securely latched in P
(Park).
4. Open the hood. Protect yourself from engine heat.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
165

5. Locate and carefully remove the
engine oil level indicator (dipstick).
6. Wipe the indicator clean. Insert the indicator fully, then remove it
again.
•If the oil level is between the MIN and MAX marks, the oil level is
acceptable. DO NOT ADD OIL.
• If the oil level is below the MIN
mark, add enough oil to raise the
level within the MIN-MAX range.
• Oil levels above the MAX mark may cause engine damage. Some oil
must be removed from the engine by a service technician.
7. Put the indicator back in and ensure it is fully seated.
Adding engine oil
1. Check the engine oil. For instructions, refer to Checking the engine
oil in this chapter.
2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
166

•Always dispose of automotive
batteries in a responsible manner.
Follow your local authorized
standards for disposal. Call your
local authorized recycling center
to find out more about recycling
automotive batteries.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
mileage intervals listed in the scheduled maintenance guide. The coolant
concentration should be maintained at 50/50 coolant and distilled water,
which equates to a freeze point of -36 °C (-34 °F). Coolant concentration
testing is possible with a hydrometer or antifreeze tester (such as the
Rotunda Battery and Antifreeze Tester, 014 –R1060). The level of coolant
should be maintained at the “cold full ”of “cold fill range ”level in the
coolant reservoir. If the level falls below, add coolant per the instructions
in the Adding engine coolant section.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly. A
50 –50 mixture of coolant and water provides the following:
• Freeze protection down to -36 °C (-34 °F).
• Boiling protection up to 129 °C (265 °F).
• Protection against rust and other forms of corrosion.
• Enables calibrated gauges to work properly.
LEAD
RETURN
RECYCLE
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Maintenance and Specifications
170

waxing .....................................157
wheels ......................................158
wiper blades ............................159
Climate control (see Air
conditioning or Heating) ............22
Console ........................................60
Controls power seat .................................74
steering column ........................45
Convertible ..................................50 cleaning .............................54, 160
installation of the boot .............51
lowering the convertible top ...50
raising the convertible top ......52
Coolant checking and adding ..............170
refill capacities ................174, 201
specifications ..................203, 205
Cruise control
(see Speed control) ....................42
Customer Assistance ................125 Ford accessories for your
vehicle .....................................162
Ford Extended Service
Plan ..........................................150
Getting assistance outside the
U.S. and Canada .....................154
Getting roadside assistance ...125
Getting the service you
need .........................................148
Ordering additional owner ’s
literature .................................155
The Dispute Settlement
Board .......................................150
Utilizing the
Mediation/Arbitration
Program ...................................153 D
Daytime running lamps
(see Lamps) ................................27
Defrost
rear window ..............................25
Dipstick automatic transmission
fluid ..........................................186
engine oil .................................165
Doors lubricant specifications ..........203
Driving under special
conditions ..................................120 through water .........................121
E
Emergencies, roadside jump-starting ..........................141
Emergency Flashers .................126
Emission control system ..........183
Engine ........................................205 cleaning ...................................158
coolant .....................................170
fail-safe coolant ......................174
idle speed control ...................168
lubrication
specifications ..................203, 205
refill capacities ........................201
service points ..........................164
Engine block heater .................112
Engine oil ..................................165 checking and adding ..............165
dipstick ....................................165
filter, specifications ........167, 201
recommendations ...................167
refill capacities ........................201
specifications ..................203, 205
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
213

K
Keyless entry systemautolock .....................................68
Keys positions of the ignition .........109
L
Lamps autolamp system .......................27
bulb replacement
specifications chart ..................31
daytime running light ...............27
headlamps .................................27
headlamps, flash to pass ..........28
instrument panel, dimming .....28
interior lamps .....................30 –31
replacing bulbs .......30, 32, 34 –37
Lane change indicator
(see Turn signal) ........................30
Lights, warning and indicator ....10 anti-lock brakes (ABS) ..........112
Load limits .................................121
Locks autolock .....................................68
doors ..........................................61
Lubricant specifications ...203, 205
Lumbar support, seats ...............74
M
Manual transmission fluid capacities ........................201
lubricant specifications ..........205
Master lighting switch ................27
Mirrors .........................................41 side view mirrors (power) .......41
Motorcraft parts ................179, 201 O
Octane rating ............................178
Oil (see Engine oil) ..................165
P
Parking brake ............................113
Parts (see Motorcraft parts) ....201
Power distribution box
(see Fuses) .......................131, 134
Power door locks ........................61
Power point .................................39
Power steering ..................114
–115
fluid, checking and adding ....185
fluid, refill capacity ................201
fluid, specifications .........203, 205
Power Windows ...........................40
R
Radio ............................................16
Rear window defroster ...............25
Relays ........................................127
Remote entry system .................64 illuminated entry ......................67
locking/unlocking doors ...........61
opening the trunk .....................65
Roadside assistance ..................125
S
Safety Belt Maintenance ............85
Safety belts
(see Safety restraints) .........76 –80
Safety defects, reporting ..........156
Safety restraints ....................76 –80
2004 Thunderbird (tbr)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
215