2004 FORD E SERIES Owners Manual

Page 145 of 240

FORD E SERIES 2004 4.G Owners Manual 4. Apply the parking brake and turn
the engine off.
5. Block the wheel that is diagonally
opposite the tire you are changing.
On E-450 vehicles, the parking
brake is on the transmission.
Therefore, th

Page 146 of 240

FORD E SERIES 2004 4.G Owners Manual •non-chassis cab vehicles:jack
is located in the rear right-hand
side of the cargo area.
•E-350 chassis cab vehicles(if
equipped):jack is strapped to a
bracket behind the driver’s seat.
2004 Eco

Page 147 of 240

FORD E SERIES 2004 4.G Owners Manual 7. Use the tapered end of the lug nut wrench to unscrew wheel
ornaments attached by retaining screws. Remove any wheel trim. Insert
the tapered end of the lug nut wrench behind wheel covers or hubcaps

Page 148 of 240

FORD E SERIES 2004 4.G Owners Manual Rear axle jacking points - All
models except E-350 Dual Rear
Wheel (DRW) and E-450:
Rear axle jacking points - E-350
Dual Rear Wheel (DRW) and
E-450:
Front axle jacking points:
Place the jack under th

Page 149 of 240

FORD E SERIES 2004 4.G Owners Manual If your vehicle has single rear wheels, thread the lug nuts on the studs
with the beveled face toward the wheel.
If your vehicle has dual rear wheels, thread the two element swiveling
lug nuts on the

Page 150 of 240

FORD E SERIES 2004 4.G Owners Manual 2. Slide the wheel partially under the vehicle and install the retainer
through the wheel center. Pull on the cable to align the components at
the end of the cable.
3. Turn the jack handle clockwise u

Page 151 of 240

FORD E SERIES 2004 4.G Owners Manual On all two-piece flat wheel nuts,
apply one drop of motor oil between
the flat washer and the nut. Do not
apply motor oil to the wheel nut
threads or the wheel stud threads.
When a wheel is installed,

Page 152 of 240

FORD E SERIES 2004 4.G Owners Manual 1.Use only a 12–volt supply to start your vehicle.
2. Do not disconnect the battery of the disabled vehicle as this could
damage the vehicle’s electrical system.
3. Park the booster vehicle close