2004 DODGE SPRINTER brake

MAINTAININ G YOUR VEHICLE 245
7
Recommended Fluids and LubricantsComponent Recommended Fluid
Brake Use brake fluid approved to MB 331.0, or a DOT 4 brake fluid with:
minimum
dry boiling point (ERBP) 500°F, minimum wet boiling point
(WERBP) 356°F, maximum viscosity 1500 mm
2/s, conforming to FMVSS 116
and ISO 4925.
Coolant Use coolant approved to MB 325.0, such as Valvoline GO5, or an equivalent
Extended Life Coolant.
Engine Use engine oils approved to MB 228.3 or MB 228.5 that are also licensed to
API CI-4.
Automatic Transmission Use ATF approved to MB 236.10, MB 236.12. Synthetic Dexron III®
Automatic Transmission Fluid may be substituted.
Power Steering No fluid service required. Use Power Steering Fluid approved to MB 341.
Dexron III® Automatic Transmission Fluid may be substituted.
Rear Axle Use oils approved to MB 235.0, such as Shell Spirax MB 90. Reduced axle
durability may result if an unapproved product is used.
Freightliner-all.book Pag e 245 Monday, December 1, 2003 2:54 PM

MA INTENA NCE SCHEDULES
CONTENTS
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248

Maintenance - Without ASSYST Maintenance
Computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 249Maintenance Intervals . . . . . . . . . . . . . . . . . . . . 249

Maintenance - With ASSYST Maintenance
Computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250

Regular Check-Ups. . . . . . . . . . . . . . . . . . . . . . . . . 250

Special Maintenance Requirements . . . . . . . . . . . 251Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Dust Filter for Heating/Ventilation
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251

Engine Oil Change and Filter Replacement . . . . 251Once a Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251

Scope of Work for Maintenance service . . . . . . . 252Oil Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 252Additional Maintenance Work . . . . . . . . . . . . . 254Additional Maintenance Work
After ... Years . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Freightliner-all.book Pag e 247 Monday, December 1, 2003 2:54 PM

250 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
MA INTENA NCE - WITH A SSYST MA INTENA NCE
COMPUTERASSYST provides you with information on the best
possible timing for maintenance work.
NOTE: The engine manufacturer strongly
recommends the use of synthetic engine oils, such as
Mobil 1 SAE 0W-40.
When the next maintenance service is due, this will be
indicated in the multi-function display with the
symbol
9 Oil service
9 Maintenance service - displayed in km/miles
or days.
9
If the display shows the number of days, the symbol
È will also appear in the multi-function display.
You should have the maintenance performed within
the stated period/distance.
The service indicator will be reset by your Sprinter
Dealer after an oil service and/or maintenance service
has been performed.
REGULA R CHECK-UPSTo maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on
a regular basis (i.e., weekly or whenever the vehicle is
refueled). Check:
 Engine oil level
 Brake system, clutch mechanism – fluid level
 Battery – acid level
 Windshield washer system and headlamp cleaning
system – fluid level
 Mechanical assemblies (e. g. ,engine, transmission,
etc.) – check for leaks
 Condition of tires and tire pressures
 All exterior lights
Freightliner-all.book Pag e 250 Monday, December 1, 2003 2:54 PM

MAINTENANCE SCHEDULES 251
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SPECIAL MAINTENANCE REQUIREMENTSIf bodies built by manufacturers other than
DaimlerChrysler Corporation are fitted to the vehicle, the
maintenance requirements and lubrication intervals
specified by the body manufacturer must be adhered to,
in addition to all standard maintenance requirements.Brake FluidOnly use brake fluids approved by the manufacturer
(DOT 4 plus). Information about brake fluids is
available from your Sprinter Dealer.CoolantHave the corrosion inhibitor/antifreeze concentration
in the coolant checked before the onset of winter (once
a year in countries with high prevailing temperatures).
Have the coolant renewed every five years or 100,000
miles.Dust Filter for Heating/Ventilation ReplacementThe dust filter and the tailgate interior filter are
renewed during routine maintenance service.
However, if operating conditions are dusty, these
filters should be renewed more frequently.
ENGINE OIL CHA NGE A ND FILTER
REPLACEMENTIn a minimum, change the engine oil and oil filter once
a year - even if the vehicle mileage per year is extremly
low. For standard oil service schedules, please see the
chapter oil service and maintenance service.Once a YearSelect the viscosity of the engine oil (SAE classes)
according to the outside air temperature.
Only use engine oil approved by DaimlerChrysler
Corporation if following the ASSYST system
guidelines.
Information is available from your Sprinter Dealer.
If the fuel used has a sulphur content exceeding 0.05 %
by weight, the service intervals should be split in half.
If the sulphur content of the fuel used is between 0.3%
and 0.8% by weight, the service intervals should be
split in half (i.e. every 5,000 miles instead of every
10,000 miles).
Freightliner-all.book Pag e 251 Monday, December 1, 2003 2:54 PM

MAINTENANCE SCHEDULES 253
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Check fluid levels for the following systems, correct
as necessary.
Should there be a loss of fluid which cannot be
explained by regular use, trace and eliminate
the cause.
Engine cooling system
Check corrosion inhibitor/antifreeze,
refill as necessary.
Hydraulic brake system
Battery
Windscreen washer system
Engine
Fuel filter renewal
Air cleaner with maintenance indicator:
Check degree of contamination.
Air cleaner filter element renewed as
necessary.Chassis and body
Trailer coupling:
Check operation, play and retaining fixtures
Secondary rubber springs:
Visual check
Tire pressures:
Correct as necessary, including spare tyre
Check thickness of brake pads
Brake test
Check condition of brake disks. Brake disks renewal as
necessary
– as a separate order
Check condition of steering mechanism
Heating/ventilation dust filter renewal
Freightliner-all.book Pag e 253 Monday, December 1, 2003 2:54 PM

262 INDEXAnti-Lock Brake System (ABS) Indicator Lamp . . . 152
Appearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Armrest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
ASSYST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 249
ASSYST Maintenance Computer . . . . . . . . . . . . . . . 103
Automatic Lock Feature . . . . . . . . . . . . . . . . . . . . . . . . 15
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . 139
Accelerator Position . . . . . . . . . . . . . . . . . . . . . . . . 140
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139
Maneuvering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Selector Lever Manually Unlocking. . . . . . . . . . . 144
Selector Lever Position . . . . . . . . . . . . . . . . . . . . . . 141
Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Auxiliary Heat Exchanger . . . . . . . . . . . . . . . . . . . . . 129
Auxiliary Heater
Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Timer Auxiliary Heater (Water and
Air Heater) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Tips for Coping with Problems . . . . . . . . . . . . . . 130Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . 217
Disconnecting the Battery . . . . . . . . . . . . . . . . . . . 216
Reconnecting the Battery . . . . . . . . . . . . . . . . . . . . 217
Replacing Batteries in Remote Keyless Entry . . . . 18
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . . . . 95
Belt Tensioners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . . . 176
Body Builder Guideline . . . . . . . . . . . . . . . . . . . . . . . 183
Brake Assist System (BAS) . . . . . . . . . . . . . . . . . . . . . 160
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Brake Fluid Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . 211
Brake Indicator Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 148
Brake Pad Wear Indicator. . . . . . . . . . . . . . . . . . . . . . 147
Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Fluid Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Brake System, Anti-Lock . . . . . . . . . . . . . . . . . . . . . . 153
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212Freightliner-all.book Pag e 262 Monday, December 1, 2003 2:54 PM

INDEX 263
10
Service Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Bulbs
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
CCapacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244
Care of Vehicle
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Headlamps, Taillamps, Turn Signal Lenses . . . . 222
Vehicle Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Care of vehicle
Paintwork, painted body components . . . . . . . . 221
Power washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Tar stains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Catalytic Converter . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Central Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Central Locking Switch. . . . . . . . . . . . . . . . . . . . . . . . . 13
Locking and Unlocking . . . . . . . . . . . . . . . . . . . . . . 15
Locking Status Display . . . . . . . . . . . . . . . . . . . . . . 14To Program the Automatic Lock Feature . . . . . . . 15
Chains, Snow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Changing a Bulb
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Interior Lighting with Interior Sensor
Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
Side-Mounted Turn Signal . . . . . . . . . . . . . . . . . . 241
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Changing the Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Checking Coolant Level . . . . . . . . . . . . . . . . . . . . . . . 213
Checking Weights of Vehicle and Trailer. . . . . . . . . 179
Cigar Lighter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76Freightliner-all.book Pag e 263 Monday, December 1, 2003 2:54 PM

INDEX 265
10
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Relay Assignment, Standard Equipment . . . . . . 230
Standard Fuse and Relay Equipment . . . . . . . . . 226
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Electronic Brake Force Distribution . . . . . . . . . . . . . 155
Electronic Brake Force Distribution Lamp. . . . . . . . 148
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 157
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 6
Emission Related Component . . . . . . . . . . . . . . . . . . 208
Emissions Control System . . . . . . . . . . . . . . . . . . . . . 183
Engine Break-in Recommendations . . . . . . . . . . . . . . 46
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Engine Control Unit Indicator Lamp . . . . . . . . . . . . . 99
Engine Coolant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Engine Oil Consumption . . . . . . . . . . . . . . . . . . . . . . . 47
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Indicator in Instrument Cluster . . . . . . . . . . . . . . 108
Engine Oil Level - Display in Instrument Cluster . 105
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . . . 97Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Engine oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Engine Speed, Maximum . . . . . . . . . . . . . . . . . . . . . . 136
Engine, Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Exhaust Gas, Inhalation of . . . . . . . . . . . . . . . . . . . . . . 48
FFog Lamp Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Folding Seat at Partition . . . . . . . . . . . . . . . . . . . . . . . . 57
Fording . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Front Seat Passenger Airbag . . . . . . . . . . . . . . . . . . . . 42
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . . . . 170
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . 176
Diesel Fuels for Use at Very Low
Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Draining Fuel Filter with Water Separator . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . 170
Freightliner-all.book Pag e 265 Monday, December 1, 2003 2:54 PM