Page 248 of 272

248 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
INTRODUCTIONThis is intended as a guide to the service requirements
of your vehicle.
It contains all necessary instructions concerning
service intervals and operations which have to be
carried out.
Scope and frequency of maintenance work primarily
depend on the vehicle's operating conditions.
In the interest of maintaining the vehicle's operating
safety, the specified work should be performed
regularly and in good time.
Our vehicles are subject to ongoing development.
Technical progress may also affect the scope of service
work performed.
"Daily vehicle checks" before starting a journey are the
responsibility of the driver.
WA RRA NTYThe Sprinter Dealer network is at your disposal for
maintenance work. Each of these workshops has the
equipment and tools, the specially trained, skilled and
experienced personnel and receives regular technical
instruction from DaimlerChrysler Corporation to
ensure that your vehicle is inspected and maintained
thoroughly and in accordance with the latest
procedures.
Please follow the instructions given in this Owner’s
Manual and ensure that they are observed, even if you
hand the vehicle over to a third party for use or care. By
not observing these instructions you may void your
warranty rights.
If the specified oil and maintenance services are not
carried out regularly or at the time intervals specified,
a decision as to the validity of a warranty claim can
only be made after DaimlerChrysler Corporation has
investigated your claim.
Freightliner-all.book Pag e 248 Monday, December 1, 2003 2:54 PM
Page 250 of 272

250 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
MA INTENA NCE - WITH A SSYST MA INTENA NCE
COMPUTERASSYST provides you with information on the best
possible timing for maintenance work.
NOTE: The engine manufacturer strongly
recommends the use of synthetic engine oils, such as
Mobil 1 SAE 0W-40.
When the next maintenance service is due, this will be
indicated in the multi-function display with the
symbol
9 Oil service
9 Maintenance service - displayed in km/miles
or days.
9
If the display shows the number of days, the symbol
È will also appear in the multi-function display.
You should have the maintenance performed within
the stated period/distance.
The service indicator will be reset by your Sprinter
Dealer after an oil service and/or maintenance service
has been performed.
REGULA R CHECK-UPSTo maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on
a regular basis (i.e., weekly or whenever the vehicle is
refueled). Check:
Engine oil level
Brake system, clutch mechanism – fluid level
Battery – acid level
Windshield washer system and headlamp cleaning
system – fluid level
Mechanical assemblies (e. g. ,engine, transmission,
etc.) – check for leaks
Condition of tires and tire pressures
All exterior lights
Freightliner-all.book Pag e 250 Monday, December 1, 2003 2:54 PM
Page 251 of 272

MAINTENANCE SCHEDULES 251
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SPECIAL MAINTENANCE REQUIREMENTSIf bodies built by manufacturers other than
DaimlerChrysler Corporation are fitted to the vehicle, the
maintenance requirements and lubrication intervals
specified by the body manufacturer must be adhered to,
in addition to all standard maintenance requirements.Brake FluidOnly use brake fluids approved by the manufacturer
(DOT 4 plus). Information about brake fluids is
available from your Sprinter Dealer.CoolantHave the corrosion inhibitor/antifreeze concentration
in the coolant checked before the onset of winter (once
a year in countries with high prevailing temperatures).
Have the coolant renewed every five years or 100,000
miles.Dust Filter for Heating/Ventilation ReplacementThe dust filter and the tailgate interior filter are
renewed during routine maintenance service.
However, if operating conditions are dusty, these
filters should be renewed more frequently.
ENGINE OIL CHA NGE A ND FILTER
REPLACEMENTIn a minimum, change the engine oil and oil filter once
a year - even if the vehicle mileage per year is extremly
low. For standard oil service schedules, please see the
chapter oil service and maintenance service.Once a YearSelect the viscosity of the engine oil (SAE classes)
according to the outside air temperature.
Only use engine oil approved by DaimlerChrysler
Corporation if following the ASSYST system
guidelines.
Information is available from your Sprinter Dealer.
If the fuel used has a sulphur content exceeding 0.05 %
by weight, the service intervals should be split in half.
If the sulphur content of the fuel used is between 0.3%
and 0.8% by weight, the service intervals should be
split in half (i.e. every 5,000 miles instead of every
10,000 miles).
Freightliner-all.book Pag e 251 Monday, December 1, 2003 2:54 PM
Page 252 of 272
252 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
SCOPE OF WORK FOR MA INTENA NCE SERVICE
Oil ServiceOil change
Engine:
Oil change and filter replacement
Check fluid levels of the following system, refill as
necessary.
If fluid is lost, trace and eliminate cause – as a separate
order.
Power-assisted steering
Lubrication work:
Trailer tow hitch (original equipment)
Maintenance
ASSYST maintenance computer resetFunction check
Signalling system,
warning and indicator lamps
Headlamps, exterior lighting
Windscreen wipers,
windscreen washer system
Check for leaks and damage.
Check for abrasion points and ensure that
lines are correctly routed!
All assemblies:
Engine, transmission, transfer case, front axle, rear
axle, steering, power steering pump
All lines and hoses, sensor cables
Rubber boots on front axle drive shafts,
rubber boots on front axle suspension ball joints, shock
absorbersFreightliner-all.book Pag e 252 Monday, December 1, 2003 2:54 PM
Page 254 of 272
254 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
A dditional Maintenance WorkAutomatic transmission once only at 80,000 miles/
128000km
Oil and filter change
During every second maintenance service
Air cleaner without maintenance indicator:
Air cleaner filter element renewal
Check poly-V-belt for wear and signs of damage
During every sixth maintenance service
Rear axle
A dditional Maintenance Work A fter ... YearsEvery 3 years
Air cleaner filter element renewal
(note installation date
)
Every 5 years or 100,000 miles
Coolant renewal
Note coolant composition
Freightliner-all.book Pag e 254 Monday, December 1, 2003 2:54 PM
Page 268 of 272

268 INDEXLock, Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Locking, Central. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Lumbar Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55MMaintenance Computer . . . . . . . . . . . . . . . . . . . . . . . 103
Maintenance Intervals. . . . . . . . . . . . . . . . . . . . . . . . . 249
Maintenance Schedules
Additional Maintenance Work
After ... Years . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Dust Filter for Heating/Ventilation
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Engine Oil Change and Filter Replacement . . . . 251
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Oil Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 252
Once a Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Regular Check-Ups. . . . . . . . . . . . . . . . . . . . . . . . . 250
Scope of Work for Maintenance service . . . . . . . 252
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
With ASSYST Maintenance Computer . . . . . . . . 250Without ASSYST Maintenance Computer . . . . . 249
Maximum Engine Speed. . . . . . . . . . . . . . . . . . . . . . . 136
Mechanical Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Mechanical Sun Roof Operation . . . . . . . . . . . . . . . . . 75
Mirror Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Mirrors
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Mopar® Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Multi-Function Indicator . . . . . . . . . . . . . . . . . . . . . . . 87
Multifunction Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . 66
OOccupant Restraints . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Opening/Closing doors . . . . . . . . . . . . . . . . . . . . . . . . 23
Operation, Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Ornamental Moldings . . . . . . . . . . . . . . . . . . . . . . . . . 222
Outlet, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Outside Temperature Display . . . . . . . . . . . . . . . . . . . 91
Freightliner-all.book Pag e 268 Monday, December 1, 2003 2:54 PM
Page:
< prev 1-8 9-16 17-24