2004 DODGE SPRINTER steering wheel

STARTING AND OPERATING 153
5
as the voltage reaches this level again
– the ABS is then
reactivated.
If ABS malfunctions, the other driving safety systems
are deactivated. The handling and braking
characteristics of your vehicle change. The other
braking and driving systems still function normally.
I
A nti-Lock Brake System (A BS)ABS prevents the wheels from locking at any speed
above about 5 mph (8 km/h), regardless of road
surface conditions. The vehicle remains steerable even
if the brakes are applied fully.
A light vibrating of the steering wheel and pulsating of
the brake pedal indicate that the ABS is working.
On slippery road surfaces, the ABS will respond even
with light brake pedal pressure because of the
increased likelihood of locking wheels. The pulsating
brake pedal can be an indication of hazardous road
conditions and works as a reminder to take extra care
while driving.
WARNING!
If the ABS indicator lamp- does not go out or
lights up again while driving, the ABS is malfunc-
tioning. If ABS malfunctions, the other driving
safety systems are deactivated. The vehicle’s brak-
ing characteristics may be affected. There is an in-
creased risk that your vehicle could skid in the
event of sharp braking. Have the malfunction
traced and repaired without delay by an autho-
rized Sprinter Dealer.
Adapt your speed and driving style to the
prevailing road, traffic and weather conditions.
Driving too fast increases the risk of an accident.
Freightliner-all.book Pag e 153 Monday, December 1, 2003 2:54 PM

STARTING AND OPERATING 163
5
STEERINGWhen the engine is not running, there is no power
assistance for the steering. Greater force will be
required to steer the vehicle.WHEELS AND TIRESCheck tires regularly for even tread wear, tread depth
(note legal requirements) and signs of external
damage.
Only use wheels and tires of the same size, make and
pattern.
Do not install tires that are not approved for the size
and type of wheel installed or the vehicle itself. Only
use those wheel sizes which were delivered to you by
your authorized Sprinter Dealer.
Use only wheels and tires which have been tested and
approved by the vehicle manufacturer.
Break in new tires at moderate speeds for a distance of
about 65 miles (about 100 km).
WARNING!
ESP cannot prevent the natural laws of physics
from acting on the vehicle, nor can it increase the
traction afforded.
The ESP cannot prevent accidents, including
those resulting from excessive speed in turns,
following another vehicle too closely, or
hydroplaning. Only a safe, attentive, and skillful
driver can prevent accidents.
The capabilities of an ESP equipped vehicle must
never be exploited in a reckless or dangerous
manner which could jeopardize the user’s safety
or the safety of others.If the vehicle is to be towed away with the front
wheels clear of the ground, or if the brakes are to be
tested on a brake dynamometer, do not put the key
in position 2 in the ignition lock because the ESP
would engage the brakes to stabilize the vehicle.If the ESP function is used for a prolonged period
of time, the rear axle brakes may fail due to
overheating.
Freightliner-all.book Pag e 163 Monday, December 1, 2003 2:54 PM

WHAT TO DO IN EMERGENCIES 187
6
VEHICLE TOOL KIT 1. Locked
2. Unlocked
The vehicle tool kit and the jack are located under the
hatch in the front passenger footwell.
CHA NGING THE TIREIf you get a flat tire while driving, gradually decrease
your speed. Hold the steering wheel firmly and slowly
move to a safe place on the side of the road. The
pressure of the spare wheel always has to be checked
regularly (at least after every tenth time at the filling
station).
Freightliner-all.book Pag e 187 Monday, December 1, 2003 2:54 PM

WHAT TO DO IN EMERGENCIES 201
6
If the Engine is DamagedFor towing distances up to 30 miles (about 50 km)
 Shift selector lever to "N" position.
 Do not exceed a towing speed of 30 mph (50 km / h).
For towing distances greater than 30 miles (about
50 km)
 Remove the propeller shafts leading to the drive
axles.
The vehicle can be towed without restriction.If the Transmission is Damaged Remove the propeller shafts leading to the drive
axles.
WARNING!
Do not tow the vehicle if the key cannot be turned
in the ignition lock.
If the key cannot be turned, the ignition lock re-
mains locked and the vehicle cannot be steered.
With the engine not running there is no power
assistance for the braking and steering systems.
In this case, it is important to keep in mind that a
considerably higher degree of effort is necessary
to brake and steer the vehicle.
The vehicle must not be towed with the front axle
raised and the key in position 2 in the ignition
lock as the drive wheels could then lock due to the
acceleration skid control (ASR) or the optional
Electronic Stability Program (ESP).
Freightliner-all.book Pag e 201 Monday, December 1, 2003 2:54 PM

204 MAINTAINING YOUR VEHICLE
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . 224Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . 224Steering Wheel and Gear Selector Lever . . . . 224Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Headliner and Shelf Below Rear Window . . . 224Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . 225Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . 225

Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225Standard Fuse and Relay Equipment . . . . . . . 226Relay Assignment, Standard Equipment . . . . 230Fuse and Relay Optional Equipment . . . . . . . 230

Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 233Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . 233Taillamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
License Plate Lamps
(Cargo/Passenger Vans Only) . . . . . . . . . . . . . 240Additional Brake Lamp
(Cargo/Passenger Vans Only) . . . . . . . . . . . . . 240Side-Mounted Turn Signals . . . . . . . . . . . . . . . 241Side-Marker Lamps,
Standing Lamps (Optional) . . . . . . . . . . . . . . . . 241Interior Lighting in Passenger Compartment
and Load Compartment . . . . . . . . . . . . . . . . . . 242Interior Lighting with Reading Lamp . . . . . . . 242Interior Lighting with Interior Sensor
Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243Exit Lamps (Optional) . . . . . . . . . . . . . . . . . . . . 243

Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244Recommended Fluids and Lubricants . . . . . . 245
Freightliner-all.book Pag e 204 Monday, December 1, 2003 2:54 PM

224 MAINTAINING YOUR VEHICLELight A lloy WheelsA wheel care product should be used for regular
cleaning of the light alloy wheels.
If possible, clean wheels once a week, using a soft
bristle brush and a strong spray of water.
Follow instructions on container.
NOTE: Use only acid-free cleaning materials. The acid
could lead to corrosion.Instrument ClusterUse a gentle dishwashing detergent or mild detergent
for delicate fabrics as a washing solution. Wipe with a
cloth moistened in lukewarm solution. Do not use
scouring agents.Steering Wheel and Gear Selector LeverWipe with a damp cloth and dry thoroughly or clean
with a leather care product.
Cup HolderUse a gentle dishwashing detergent or mild detergent
for delicate fabrics as a washing solution. Wipe with a
cloth moistened in lukewarm solution. Do not use
scouring agents.Seat BeltsThe webbing must not be treated with chemical
cleaning agents. Use only clear, lukewarm water and
soap. Do not dry the webbing at temperatures above
176
°F (+80
°C) or in direct sunlight.
Headliner and Shelf Below Rear WindowClean with soft bristle brush, or use a dry-shampoo
cleaner in case of excessive dirt.UpholsteryUsing aftermarket seat covers or wearing clothing that
have the tendency to give off coloring (e.g. when wet
WARNING!
Do not bleach or dye seat belts as this may severe-
ly weaken them. In a crash they may not be able to
provide adequate protection.
Freightliner-all.book Pag e 224 Monday, December 1, 2003 2:54 PM

264 INDEXCleaning
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . . . . 225
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . 224
Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 224
Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . . . 225
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Steering Wheel and Gear Selector Lever . . . . . . . 224
Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Comfort Tire Pressures . . . . . . . . . . . . . . . . . . . . . . . . 169
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 79
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 256
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 256
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Prepare for the Appointment . . . . . . . . . . . . . . . . 256Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . 93
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Diesel Fuels for Use at Very Low Temperatures. . . 171
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 106
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Draining Fuel Filter with Water Separator . . . . . . . 175
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Fuse and Relay Optional Equipment . . . . . . . . . . 230
Freightliner-all.book Pag e 264 Monday, December 1, 2003 2:54 PM

270 INDEXSeats
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Armrest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Driver’s and Front Passenger’s Seat. . . . . . . . . . . . 54
Folding Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Head Restraint. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Lumbar Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Rear Seat Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Security System with Towing and Passenger
Compartment Protection . . . . . . . . . . . . . . . . . . . . . . . 19
Audible Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Switching off the Alarm . . . . . . . . . . . . . . . . . . . . . . 20
Visual Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Selector Lever Position . . . . . . . . . . . . . . . . . . . . . . . . 141
Service Products . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Disposal of Service Products . . . . . . . . . . . . . . . . . 208
Skid Control, Acceleration . . . . . . . . . . . . . . . . . . . . . 155
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Snow Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170Spare Wheel Location . . . . . . . . . . . . . . . . . . . . . . . . . 189
Special Maintenance Requirements . . . . . . . . . . . . . 251
Speed Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Sprinter Original Parts . . . . . . . . . . . . . . . . . . . . . . . . 207
SRS Malfunction Indicator Lamp . . . . . . . . . . . . . . . . 40
Standard Fuse and Relay Equipment . . . . . . . . . . . . 226
Starter Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Stopping the Engine . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Suggestions For Obtaining Service For
Your Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Sun Roof
Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Mechanical Operation . . . . . . . . . . . . . . . . . . . . . . . 75
Sun Roof, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Switch Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Switch,Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
TTachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Freightliner-all.book Pag e 270 Monday, December 1, 2003 2:54 PM