2004 DODGE SPRINTER coolant temperature

MAINTAININ G YOUR VEHICLE 213
7
Have the coolant renewed at least every five years or
after 100,000 miles.
When the coolant is renewed, the new coolant should
contain 50% antifreeze/corrosion inhibitor by volume.
This corresponds to antifreeze protection down to -
37 °C/-35°F.
Do not exceed a proportion of about 55 % by volume
(antifreeze protection down to about -45 °C/-49 °F) as
the heat dissipation properties then deteriorate.
In the event of coolant loss, do not add water only, but
sufficient antifreeze/corrosion inhibitor to maintain
the correct concentration.
The water in the coolant must satisfy certain
requirements. These are often met by tap supply
drinking water.
The water must be specially prepared if the water
quality does not come up to the required standards.
Have the corrosion inhibitor/antifreeze concentration
in the coolant checked at the outset of winter,
respectively once a year in countries with high
prevailing temperatures.A regular check is included in the maintenance service.
Checking Coolant LevelCoolant reservoir (1)
The cooling system is pressurized. Only check the
coolant level with the vehicle parking on a level surface
and with the engine switched off.
– Wait until the coolant temperature has dropped
below 194 °F (+90 °C).
Freightliner-all.book Pag e 213 Monday, December 1, 2003 2:54 PM

214 MAINTAINING YOUR VEHICLE
 Open the hood.
 At first, only turn the radiator cap to the first detent
to release the pressure from the cooling system.
Only then should the radiator cap be removed
completely.
 To add coolant:
If the engine is cold:
Add coolant until the coolant level reaches the base
area which is visible through the filler opening (area
moistened).
If the engine is already at its regular operating
temperature:
Add coolant until the coolant level is about 0.6 inch
WARNING!
In order to avoid any possibly serious burns:
 If you see flames or smoke coming from the
engine compartment, or if the coolant
temperature gauge indicates that the engine is
overheated, do not open the hood. Move away
from the vehicle and do not open the hood until
the engine has cooled. If necessary, call the fire
department.
 Do not remove pressure cap on coolant reservoir
if engine temperature is above 194 °F (+90 ×C).
Allow engine to cool down before removing cap.
The coolant reservoir contains hot fluid and is
under pressure.
 Using a rag, slowly open cap approximately 1/2
turn to relieve excess pressure. If opened
immediately, scalding hot fluid and steam will
be blown out under pressure.
 Do not spill antifreeze on hot engine parts.
Antifreeze contains ethylene glycol which may
burn if it comes into contact with hot engine
parts.
 Check coolant level only with the engine
switched off and the key in position 0 in the
ignition lock.
Freightliner-all.book Pag e 214 Monday, December 1, 2003 2:54 PM

MAINTAININ G YOUR VEHICLE 215
7
(1.5 cm) above the base area which is visible
through the filler opening.
 Replace and tighten the radiator cap.
If a large quantity of coolant has been lost, or if smaller
amounts are lost at regular intervals, have the engine
cooling system examined by an authorized Sprinter
Dealer.
For coolant composition and water quality, contact
your Sprinter Dealer.
WINTER OPERATIONHave your vehicle winterized by an authorized
Sprinter Dealer before the onset of winter.
 Have the engine oil changed, if the engine oil filled
is not approved for winter use.
 Coolant: antifreeze/anti-corrosion concentration in
the coolant checked.
 Windshield washer system: add winter concentrate
to the washer fluid.
 Battery: the battery will lose capacity as
temperatures drop. Only a well-charged battery will
ensure reliable engine starting even at low outside
temperatures.
 Tires: fit M+S radial tires, taking note of the
maximum permissible speed of the tires fitted.
Freightliner-all.book Pag e 215 Monday, December 1, 2003 2:54 PM

MAINTENANCE SCHEDULES 251
8M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SPECIAL MAINTENANCE REQUIREMENTSIf bodies built by manufacturers other than
DaimlerChrysler Corporation are fitted to the vehicle, the
maintenance requirements and lubrication intervals
specified by the body manufacturer must be adhered to,
in addition to all standard maintenance requirements.Brake FluidOnly use brake fluids approved by the manufacturer
(DOT 4 plus). Information about brake fluids is
available from your Sprinter Dealer.CoolantHave the corrosion inhibitor/antifreeze concentration
in the coolant checked before the onset of winter (once
a year in countries with high prevailing temperatures).
Have the coolant renewed every five years or 100,000
miles.Dust Filter for Heating/Ventilation ReplacementThe dust filter and the tailgate interior filter are
renewed during routine maintenance service.
However, if operating conditions are dusty, these
filters should be renewed more frequently.
ENGINE OIL CHA NGE A ND FILTER
REPLACEMENTIn a minimum, change the engine oil and oil filter once
a year - even if the vehicle mileage per year is extremly
low. For standard oil service schedules, please see the
chapter oil service and maintenance service.Once a YearSelect the viscosity of the engine oil (SAE classes)
according to the outside air temperature.
Only use engine oil approved by DaimlerChrysler
Corporation if following the ASSYST system
guidelines.
Information is available from your Sprinter Dealer.
If the fuel used has a sulphur content exceeding 0.05 %
by weight, the service intervals should be split in half.
If the sulphur content of the fuel used is between 0.3%
and 0.8% by weight, the service intervals should be
split in half (i.e. every 5,000 miles instead of every
10,000 miles).
Freightliner-all.book Pag e 251 Monday, December 1, 2003 2:54 PM

264 INDEXCleaning
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . . . . 225
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . 224
Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 224
Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . . . 225
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Steering Wheel and Gear Selector Lever . . . . . . . 224
Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Comfort Tire Pressures . . . . . . . . . . . . . . . . . . . . . . . . 169
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 79
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 256
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 256
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Prepare for the Appointment . . . . . . . . . . . . . . . . 256Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . 93
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Diesel Fuels for Use at Very Low Temperatures. . . 171
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 106
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Draining Fuel Filter with Water Separator . . . . . . . 175
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Fuse and Relay Optional Equipment . . . . . . . . . . 230
Freightliner-all.book Pag e 264 Monday, December 1, 2003 2:54 PM

INDEX 265
10
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Relay Assignment, Standard Equipment . . . . . . 230
Standard Fuse and Relay Equipment . . . . . . . . . 226
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Electronic Brake Force Distribution . . . . . . . . . . . . . 155
Electronic Brake Force Distribution Lamp. . . . . . . . 148
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 157
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 6
Emission Related Component . . . . . . . . . . . . . . . . . . 208
Emissions Control System . . . . . . . . . . . . . . . . . . . . . 183
Engine Break-in Recommendations . . . . . . . . . . . . . . 46
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Engine Control Unit Indicator Lamp . . . . . . . . . . . . . 99
Engine Coolant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Engine Oil Consumption . . . . . . . . . . . . . . . . . . . . . . . 47
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Indicator in Instrument Cluster . . . . . . . . . . . . . . 108
Engine Oil Level - Display in Instrument Cluster . 105
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . . . 97Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Engine oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Engine Speed, Maximum . . . . . . . . . . . . . . . . . . . . . . 136
Engine, Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Exhaust Gas, Inhalation of . . . . . . . . . . . . . . . . . . . . . . 48
FFog Lamp Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Folding Seat at Partition . . . . . . . . . . . . . . . . . . . . . . . . 57
Fording . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Front Seat Passenger Airbag . . . . . . . . . . . . . . . . . . . . 42
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . . . . 170
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . 176
Diesel Fuels for Use at Very Low
Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Draining Fuel Filter with Water Separator . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . 170
Freightliner-all.book Pag e 265 Monday, December 1, 2003 2:54 PM

266 INDEX
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . 173
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Fuse and Relay Optional Equipment . . . . . . . . . . . . 230
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Fuses, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
GGlove Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Lockable Glove Compartment . . . . . . . . . . . . . . . . 79HHazard Warning Flasher Switch . . . . . . . . . . . . . . . . 186
Head Restraint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Headlamp Range Control. . . . . . . . . . . . . . . . . . . . . . . 62
Headlamps, taillamps, turn signal lenses . . . . . . . . 222
Heated Rear Window . . . . . . . . . . . . . . . . . . . . . . . . . 114
Heater, Seat. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109, 111
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
How to Use this Manual . . . . . . . . . . . . . . . . . . . . . . . . . 4
Hydroplaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165Ignition
Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Starter Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Indicator Lamp Symbols . . . . . . . . . . . . . . . . . . . . . . . . 99
Inhalation of Exhaust Gas. . . . . . . . . . . . . . . . . . . . . . . 48
Installing a Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Instrument and Display Lighting . . . . . . . . . . . . . . . . 90
Instrument Cluster
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . 93
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Trip Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Instrument Cluster and Indicator Lamps. . . . . . . . . . 85
Instruments and Controls . . . . . . . . . . . . . . . . . . . . . . . 83Freightliner-all.book Pag e 266 Monday, December 1, 2003 2:54 PM

268 INDEXLock, Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Locking, Central. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Lumbar Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55MMaintenance Computer . . . . . . . . . . . . . . . . . . . . . . . 103
Maintenance Intervals. . . . . . . . . . . . . . . . . . . . . . . . . 249
Maintenance Schedules
Additional Maintenance Work
After ... Years . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Dust Filter for Heating/Ventilation
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Engine Oil Change and Filter Replacement . . . . 251
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Oil Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 252
Once a Year . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Regular Check-Ups. . . . . . . . . . . . . . . . . . . . . . . . . 250
Scope of Work for Maintenance service . . . . . . . 252
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
With ASSYST Maintenance Computer . . . . . . . . 250Without ASSYST Maintenance Computer . . . . . 249
Maximum Engine Speed. . . . . . . . . . . . . . . . . . . . . . . 136
Mechanical Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Mechanical Sun Roof Operation . . . . . . . . . . . . . . . . . 75
Mirror Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Mirrors
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Mopar® Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Multi-Function Indicator . . . . . . . . . . . . . . . . . . . . . . . 87
Multifunction Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . 66
OOccupant Restraints . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Opening/Closing doors . . . . . . . . . . . . . . . . . . . . . . . . 23
Operation, Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Ornamental Moldings . . . . . . . . . . . . . . . . . . . . . . . . . 222
Outlet, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Outside Temperature Display . . . . . . . . . . . . . . . . . . . 91
Freightliner-all.book Pag e 268 Monday, December 1, 2003 2:54 PM