2004 DODGE RAM 2500 DIESEL engine oil capacity

27. Low Fuel Warning Light
Glows when the pointer is between ªEº and 1/8
indication mark (approximately 15% of tank vol-
ume) on the fuel gauge. When the fuel gauge
pointer is on ªEº (equivalent to Distance To Empty [DTE]
= 0 on the overhead console if so equipped) there is
reserve fuel capacity, which corresponds to approxi-
mately 8% of tank volume. This reserve capacity was put
in place to prevent the likelihood of customers running
out of fuel when operating at maximum load conditions
in areas where there aren't many gas stations.
Ram fuel tank volumes are as follows:
²34 gallons - 2500/3500 short box models
²35 gallons - 2500/3500 long box models28. Transmission Oil Temperature Warning Light
(Automatic Transmissions Only)
This light indicates that there is excessive trans-
mission fluid temperature that might occur
with severe usage such as trailer towing. If this
light comes on, stop the vehicle and run the
engine at idle or faster, with the transmission in NEU-
TRAL until the light goes off.
29. Check Gages
This light illuminates when the Voltmeter, Engine
Oil Pressure or Engine Coolant Temperature
gages indicate a reading either too high or too low.
Examine the gages carefully, and follow the instructions
above for each indicated problem.
150 UNDERSTANDING YOUR INSTRUMENT PANEL

Checking the vehicle while it's on level ground will also
improve the accuracy of the oil level readings. Add oil
only when the level on the dipstick is below the ªADDº
mark. The total capacity from the low mark to the high
mark is 2 quarts (1.9 liters).
Never operate the engine with oil level below the ªADDº
mark or above the upper ªSAFEº mark.Change Engine Oil
CAUTION!
Overfilling or underfilling the crankcase will cause
oil aeration or loss of oil pressure. This could dam-
age your engine.
Road conditions as well as your kind of driving affect the
interval at which your oil should be changed. Check the
following to determine if any apply to you:
²Frequent short trips where the engine does not achieve
full operating temperature (operating temperature de-
fined as 190É F (66É C ) coolant temperature).
²Extensive engine idling (over 10 minutes per hour of
operation) at ambient temperatures less than 32É F (0É
C).
326 MAINTAINING YOUR VEHICLE

Apply a light film of lubricating oil to the sealing surface
of the filter gasket before installing the filter.
CAUTION!
Overtightening may distort the threads or damage
the filter element seal.
Install the filter as specified by the filter manufacturer.
Turn the filter 3/4 to one full turn after making contact
with the gasket.
Check the condition of the threads and sealing surface on
the oil pan and drain plug.
Install the drain plug and sealing washer and tighten to
37 ft-lbs. (50 N´m).Use only high-quality multi-grade lubricating oil in your
Cummins Diesel Engine. Choose the correct oil for your
operating conditions as outlined in the Selection of
Engine Oil.
Cummins Turbo Diesel
Fill the engine with the correct grade of new oil. The
engine capacity is 11 quarts (10.4 liters) in the crankcase
and 1 quart (.95 liter) in the lubricating oil filter.
Start the engine and operate it at idle for several minutes.
Check for leaks at the lubricating oil filter and oil pan
drain plug.
Stop the engine. Wait approximately 15 minutes to let the
oil in the upper parts of the engine drain back to the pan.
Check the oil level again.
Add oil as necessary to bring the level to the ªSAFEº
mark on the dipstick.
330 MAINTAINING YOUR VEHICLE

Child Seat............................56,62
Cigar Lighter........................... 127
Climate Control......................... 185
Clock................................ 151
Clutch Linkage Maintenance................ 350
Compact Disc Maintenance................. 184
Compact Disc Player..................158,164
Compact Spare Tire...................... 255
Compass.............................. 117
Compass Calibration..................... 117
Compass Variance....................... 118
Computer, Trip/Travel.................... 113
Console, Overhead....................... 112
Contract, Service........................ 404
Cooling System......................... 343
Coolant Capacity...................... 379
Coolant Level......................... 344
Disposal of Used Coolant................ 346
Drain, Flush, and Refill.................. 344Inspection........................... 343
Radiator Cap......................343,346
Selection of Coolant..................345,380
Temperature Gauge..................... 146
Cruise Control.......................... 109
Cup Holder............................ 128
Customer Assistance..................... 402
Daytime Running Lights................... 102
Dealer Service.......................... 322
Defroster, Rear Window..............78,191,195
Defroster, Windshield..................186,189
Delay Wipers........................... 105
Differential, Limited-Slip.................. 237
Dipsticks.............................. 325
Power Steering........................ 339
Disc Brakes............................ 348
Disposal.............................. 331
Engine Oil........................... 331
414 INDEX

Exterior Lighting........................ 101
Fan .................................. 347
Filters
Engine Oil.....................325,328,380
Flashers
Turn Signal.......................... 103
Flat Tire Stowage.....................299,309
Fluid, Brake........................... 381
Fluid Capacities......................... 379
Fluid Level Checks
Brake............................... 348
Manual Transmission................... 352
Power Steering........................ 339
Transfer Case......................... 352
Fog Lights..........................102,378
Fold Flat Load Floor..................... 130
Four Wheel Drive....................... 226
Four-Way Hazard Flasher.................. 296Freeing A Stuck Vehicle................... 313
Front Axle..........................340,351
Fuel..............................264,297
Diesel.........................264,297,380
Gauge.............................. 149
Requirements......................... 264
Specifications......................... 267
Tank Capacity........................ 379
Fuses................................ 366
Garage Door Opener..................... 120
Gauges............................... 150
Coolant Temperature.................... 146
Fuel................................ 149
Oil Pressure.......................... 145
Speedometer......................... 145
Tachometer.......................... 144
Voltmeter............................ 144
Gear Ranges........................... 218
416 INDEX

Trailer Towing......................79,279
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................322,407
Multi-Function Control Lever............... 103
New Vehicle Break-In Period................ 67
Noise Control
Maintenance.......................... 357
Tampering Prohibited................... 358
Noise Emission Warranty...............357,359
Occupant Restraints....................... 33
Odometer..........................148,149
Trip .............................148,149
Off-Pavement Driving.................... 292
Off-Road Driving........................ 292
Oil, Engine............................ 380
Capacity............................ 379
Change Interval....................... 326Dipstick............................. 325
Disposal............................ 331
Filter.........................325,328,380
Pressure Gauge....................... 145
Recommendation...................... 327
Viscosity............................ 327
Oil Filter, Change........................ 328
Onboard Diagnostic System................ 321
Opener, Garage Door..................... 120
Operating Precautions.................... 321
Outside Rearview Mirrors.................. 76
Overdrive............................. 220
Overdrive OFF Switch.................... 220
Overhead Console.................... 112,113
Overhead Travel Information Center.......... 113
Owner's Manual........................ 408
Parking Brake.......................... 238
Passenger Airbag On/Off Switch............. 50
420 INDEX