2004 CHRYSLER TOWN AND COUNTRY window

²Do not inhale exhaust gases. They contain carbon
monoxide, a colorless and odorless gas which can kill.
Never run the engine in a closed area, such as a
garage, and never sit in a parked vehicle with the
engine running for an extended period. If the vehicle is
stopped in an open area with the engine running for
more than a short period, adjust the ventilation system
to force fresh, outside air into the vehicle.
²Guard against carbon monoxide with proper mainte-
nance. Have the exhaust system inspected every time
the vehicle is raised. Have any abnormal conditions
repaired promptly. Until repaired, drive with all side
windows fully open.
²Keep the liftgate closed when driving your vehicle to
prevent carbon monoxide and other poisonous ex-
haust gases from entering the vehicle.
ADDING FUEL
Fuel Filler Cap (Gas Cap)
The gas cap is behind the fuel filler door on the left side
of the vehicle. If the gas cap is lost or damaged, be sure
the replacement cap is for use with this vehicle.
STARTING AND OPERATING 279
5

NSteering Shaft Seal....................323
NSteering Linkage......................323
NDrive Shaft Universal Joints..............323
NBody Lubrication.....................324
NWindshield Wiper Blades................324
NWindshield And Rear Window Washers.....324
NExhaust System......................325
NCooling System.......................326
NHoses And Vacuum/Vapor Harnesses.......331
NBrakes.............................331
NMaster Cylinder Ð ABS Brakes Brake Fluid
Level Check.........................333
NFuel System Hoses....................334NAutomatic Transmission................335
NAll Wheel Drive (AWD).................337
NFront And Rear Wheel Bearings...........339
NAppearance Care And Protection
From Corrosion......................339
NCleaning The Instrument Panel And Underseat
Cup Holders........................343
mIntegrated Power Module (IPM)............344
mVehicle Storage........................345
mReplacement Light Bulbs.................346
mBulb Replacement......................347
NHeadlights..........................347
NFront Park/Turn Signal And
Sidemarker Lights.....................348
306 MAINTAINING YOUR VEHICLE

Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors, liftgate, sliding doors and hood hinges,
should be lubricated periodically to assure quiet, easy
operation and to protect against rust and wear. Prior to
the application of any lubricant, the parts concerned
should be wiped clean to remove dust and grit; after
lubricating excess oil and grease should be removed.
Particular attention should also be given to hood latching
components to insure proper function. When performing
other underhood services, the hood latch, release mecha-
nism and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
The rubber edges of the wiper blades and the windshield
should be cleaned periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove accu-
mulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield.
Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
Windshield and Rear Window Washers
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the engine
compartment and should be checked for fluid level at
regular intervals. Fill the reservoir with windshield
324 MAINTAINING YOUR VEHICLE

and Mopar Total Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with any commercial household-type glass cleaner.
Never use an abrasive type cleaner. Use caution when
cleaning inside rear windows equipped with electricdefrosters or windshields equipped with a windshield
wiper de-icer. Do not use scrapers or other sharp instru-
ments which may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
342 MAINTAINING YOUR VEHICLE

CAUTION!
²When installing the Integrated Power Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
²When replacing a blown fuse, it is important to
use only a fuse having the correct amperage
rating. The use of a fuse with a rating other than
indicated may result in a dangerous electrical
system overload. If a properly rated fuse contin-
ues to blow, it indicates a problem in the circuit
that must be corrected.
The Heated Mirrors, Lower Instrument Panel Power
Outlet and Removable Floor Console, when in the frontposition are fused with self resetting fuses that are only
serviceable by an authorized dealer. The power seats are
fused by a 30 Amp circuit breaker located under the
driver's seat. The Power Windows are fused by a 25 Amp
circuit breaker located under the instrument panel near
the steering column. If you experience temporary or
permanent loss of these systems see your authorized
dealer for service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may:
²Remove the 20 Amp mini fuse in the Integrated Power
Module labeled Ignition-Off Draw (IOD).
²Or, disconnect the negative cable from the battery.
²Anytime you store your vehicle, or keep it out of
service (i.e. vacation) for two weeks or more, run the
MAINTAINING YOUR VEHICLE 345
7

Adding Fuel........................... 279
Adding Washer Fluid..................232,324
Additives, Fuel......................... 277
Adjustable Pedals........................ 116
Air Conditioner Maintenance............... 321
Air Conditioning.....................209,214
Air Conditioning Controls................. 209
Air Conditioning Filter.................230,322
Air Conditioning, Operating Tips............ 229
Air Conditioning, Rear Zone.............216,224
Air Conditioning Refrigerant............... 321
Air Conditioning System..........209,214,219,321
Air Conditioning System, Zone Control........ 210
Air Pressure, Tires....................... 261
Airbag................................ 50
Airbag Deployment....................... 57
Airbag Light.....................54,59,74,162
Airbag Maintenance....................... 58
Airbag, Side............................ 56Alarm Light........................... 164
Alarm System........................... 27
Alignment and Balance................... 267
All Wheel Drive...................244,268,337
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 329
Antifreeze (Engine Coolant)..............327,328
Anti-Lock Brake System................... 247
Anti-Lock Warning Light.................. 163
Anti-Theft Security Alarm.................. 27
Appearance Care........................ 339
Ashtray............................... 140
Auto Down Power Windows................ 39
Automatic Dimming Mirror................. 82
Automatic Door Locks..................... 19
Automatic Headlights.................... 108
Automatic Temperature Control............. 219
Automatic Transaxle...................241,335
Adding Fluid......................... 353
386 INDEX

Radiator Cap......................... 329
Selection of Coolant..................327,352
Cruise Control.......................... 117
Cruise Light........................... 167
Cup Holder.........................140,343
Customer Assistance..................... 376
Daytime Running Lights................... 109
Dealer Service.......................... 311
Defroster, Rear Window................... 233
Defroster, Windshield................74,213,223
Digital Video Disc Player.................. 197
Dimmer Control........................ 107
Dipsticks
Automatic Transaxle.................... 336
Disposal
Antifreeze........................... 329
Domelight............................. 108
Door Ajar Light......................... 161Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 129
Drive Belts............................ 316
Drive Shaft Universal Joints................ 323
Driving
On Slippery Surfaces.................... 299
DVD Player............................ 197
Electric Remote Mirrors.................... 84
Electrical Power Outlets................... 138
Electronic Speed Control................... 117
Electronic Vehicle Information Center......... 125
Emergency, In Case of
Jacking............................. 292
Overheating.......................... 291
Emission Control System Maintenance......310,356
Engine............................... 308
Air Cleaner.......................... 317
INDEX 389
10

Overheating, Engine...................164,291
Owner's Manual.......................4,380
Panic Alarm............................ 22
Parking Brake.......................... 245
Parking On Hill......................... 245
Passing Light........................... 111
Pedals, Adjustable....................... 116
Pets.................................. 68
Placard, Tire and Loading Information......... 256
Power
Brakes.............................. 246
Distribution Center..................... 344
Door Locks........................... 18
Lift Gate............................. 35
Mirrors.............................. 84
Outlet.............................. 138
Seats................................ 86
Sliding Door.......................... 30Steering............................. 249
Steering, Checking..................... 322
Sunroof............................. 135
Windows............................. 38
Pregnant Women and Seat Belts.............. 49
Pretensioners
Seat Belts............................. 48
Programmable Electronic Features......126,130,134
Programming Transmitters............23,130,134
Radial Ply Tires......................... 264
Radiator Cap........................327,329
Radio..........................171,181,188
Radio Broadcast Signals................... 169
Radio Operation........................ 209
Radio Remote Controls.................200,206
Rear Air Conditioning.................216,224
Rear Cup Holder........................ 141
Rear Heater............................ 216
396 INDEX