2004 CHRYSLER PT CRUISER oil level

MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability . The limited warranties in the warranty booklet DO NOT COVER repairs
required due to improper maintenance. W e strongly suggest you keep track of scheduled maintenance and
keep receipts or other documents. Use only recommended Mopar lubricants and genuine Mopar parts.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICA TED, FOLLOW THE INTERVAL
THA T OCCURS FIRST .
AT EACH STOP FOR FUEL
¥ Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground willimprove the accuracy of the oil level reading.
Add oil only when the level is at or below the
ADD or MIN mark.
¥ Check the windshield washer solvent and add if required.
ONCE A MONTH
¥ Check the tire pressure and look for unusualwear or damage.
¥ Inspect the battery and clean and tighten theterminals as required.
¥ Check the fluid levels of coolant reservoir , brake
master cylinder , power steering and transmission
and add as needed.
¥ Check all the lights and all other electrical itemsfor correct operation.
¥ Check rubber seals on each side of the radiatorfor proper fit (all except Pacifica ).
¥ Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORA TION AND PHYSICAL DAMAGE.
There are two maintenance schedules contained in your OwnerÕ s Manual. Schedule
ÒBÓ best describes operating conditions inCanada and is the recommended serviceschedule. For your convenience, the scheduledmaintenance intervals outlined in this bookletfollow the Severe Service Schedule as describedin your OwnerÕ s Manual. Schedule ÒBÓ is for
vehicles that are operated under one or more ofthe following conditions: day or night tempera -
tures are below 0 ¡C; stop and go driving;
extensive engine idling; driving in dustyconditions; short trips of less than 16.2 km; more than 50% of your driving is at sustainedhigh speeds during hot weather
, above 32¡C;
trailer towing; taxi, police, or delivery service(commercial service); off-road or desert driving;if equipped for and operating with E-85(ethanol) fuel. Schedule ÒAÓ is for vehicles thatare not operated under any of the conditionslisted under Schedule ÒB.Ó
The performance of all scheduled servicework is required to maintain your vehicle ingood operating condition. DaimlerChryslerCanada Inc. reserves the right to denywarranty coverage if the vehicle has not beenproperly maintained. While we do not insistthat such work be performed by factory-authorized dealers, we strongly recommendthat an authorized Chrysler , Jeep
¨or Dodge
dealer perform this work.
INTRODUCTION
2004 Car_Minivan Maint Cover 7/11/03 2:03 PM Page 4

5,000 km
Maint enance Service
Sc hedule ÒBÓ
Odometer Reading
Date
Dealer copy.
Remove and attach to Repair Order 26-92-01-01 3N.
Maint enance Service Sc hedule ÒBÓ
5,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
lInspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde, Intrepid, 300M, Pacifica and Minivan only).
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 31

Maintenance Service Sc hedule ÒBÓ
5,0 00 km
Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible, Concorde,Intrepid, 300M, Pacifica and Minivan only).
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 32

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
10,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-02-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary
(Sebring, Sebring Convertible,
Concorde, Intrepid, 300M, Pacifica and Minivan only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 33

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary
(Sebring, Sebring Convertible, Concorde,
Intrepid, 300M, Pacifica and Minivan only).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
Maint enance Service Sc hedule ÒBÓ
1 0,0 00 km
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 34

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
14,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-03-01 3N.
Maint enance Service Sc hedule ÒBÓ
14,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary
(Sebring, Sebring Convertible,
Concorde, Intrepid, 300M, Pacifica and Minivan only).
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M and SX 2.0 only.)
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 35

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary
(Sebring, Sebring Convertible, Concorde, Intrepid,
300M, Pacifica and Minivan only).
INSPECT THE FOLLOWING:
l Inspect the front and rear brake linings and components (Pacifica, Minivan, Concorde, Intrepid, 300M and SX 2.0 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
Maint enance Service Sc hedule ÒBÓ
14,0 00 km
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 36

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
19,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-04-01 3N.
Maint enance Service Sc hedule ÒBÓ
1 9,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate, as required, all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary
(Sebring, Sebring Convertible,
Concorde, Intrepid, 300M, Pacifica and Minivan only).
l Replace the air conditioning filter (Pacifica and Minivan, if equipped).
l Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
l Inspect the front and rear brake linings and components (Sebring, Sebring Convertible, PT Cruiser and SRT-4 only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition (if equipped).
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
2004 Car_Minivan Maint Book 7/24/03 12:42 PM Page 37