2004 CHRYSLER PT CRUISER service schedule

EMISSION CONTROL SYSTEM MAINTENANCE
The ªScheduledº maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
There are three maintenance schedules that showre-
quiredservice for your vehicle.
First is ScheduleªBºÐALL ENGINES. It is for vehicles
that are operated under the conditions that are listed
below and at the beginning of the schedule.
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
²Taxi, police, or delivery service (commercial ser-
vice).²L
294 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE ªBºÐALL ENGINES
Follow schedule ªBºÐAll Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (96 000 km) if the vehicle is usually operated
under one or more of the conditions marked with anL.
Change the manual transaxle fluid every 48,000 miles (77
000 km) if the vehicle is usually operated under one or
more of the conditions marked with an ².
²Day and night temperatures are below32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16.2 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C ).
²Trailer towing.²L
²Taxi, police, or delivery service (commercial ser-
vice).²L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBÐAll En-
ginesº of the9Maintenance Schedules9section of this
manual.
MAINTENANCE SCHEDULES 297
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 111,000 114,000 117,000 120,000
(Kilometers) (173 000) (178 000) (183 000) (188 000) (193 000)
Change engine oil and engine oil filter.XXXXX
Inspect the brake linings. X
Inspect theengine air cleaner filterand replace as
necessary.*X
Inspect the tie rod ends and boot seals. X
Inspect thePCV make-up air filter.Replace as nec-
essary.XX
Adjust the generator drive belt tension. X
Change automatic transaxle fluid and filter.LX
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
² This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.LThis maintenance is required only for police, taxi,
limousine type operation, or trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
304 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles108,000 114,000 120,000
(Kilometers) (173 000) (182 000) (192 000)
[Months] [108] [114] [120]
Change engine oil and engine oil filter. X X X
Inspect thePCV valveand replace if necessary. * X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
308 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 110,000 115,000 120,000
(Kilometers) (177 000) (185 000) (193 000)
[Month] [90] [96] [102]
Change engine oil and engine oil filter. X X X
Inspect thePCV Valveand replace if necessary. * X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
MAINTENANCE SCHEDULES 313
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Locks
Central.............................. 20
Child Protection........................ 21
Door................................ 18
Power Door........................... 19
Steering Wheel......................... 17
Lubrication, Body....................... 262
Luggage Rack.......................... 119
Maintenance Free Battery.................. 259
Maintenance, General..................... 251
Maintenance Procedures................... 251
Maintenance Schedule
Schedule9A9.......................305,309
Schedule9B9.......................... 297
Maintenance Schedules.................... 294
Malfunction Indicator Light..............134,249
Manual, Service......................... 322
Manual Transaxle..................180,189,276Downshifting......................... 191
Fluid Level Check...................... 276
Frequency of Fluid Change............... 276
Lubricant Selection..................... 276
Master Cylinder......................... 271
Mirrors................................ 67
Electric Remote........................ 68
Outside.............................. 67
Rearview............................. 67
Vanity............................... 69
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................250,321
Multi-Function Control Lever................ 95
Navigation System....................... 161
New Vehicle Break-In Period................ 59
Occupant Restraints....................... 32
Octane Rating, Gasoline................... 216
334 INDEX

Safety Checks Inside Vehicle................. 60
Safety Checks Outside Vehicle............... 61
Safety Defects, Reporting.................. 321
Safety Information, Tire................... 197
Safety Tips............................. 59
Satellite Radio.......................... 161
Satellite Radio Antenna................... 164
Schedule, Maintenance.................... 294
Seat Belts.............................. 32
Adjustable Shoulder Belt.................. 38
Adjustable Upper Shoulder Anchorage........ 38
And Pregnant Women................... 41
Child Restraint......................... 50
Cleaning............................ 282
Front Seat............................ 33
Pretensioners.......................... 41
Rear Seat............................. 33
Reminder............................ 131
Untwisting Procedure.................... 39Seats................................. 82
Adjustment........................... 82
Head Restraints........................ 85
Heated.............................. 85
Height Adjustment...................... 83
Rear Folding........................86,88
Reclining............................. 84
Removal............................. 90
Security Alarm.......................... 26
Sentry Key...........................14,27
Sentry Key Programming................... 16
Service and Maintenance.................. 294
Service Assistance....................... 316
Service Contract......................... 318
Service Manuals........................ 322
Setting the Clock........................ 136
Severe Service.......................... 297
Shift Speeds, Manual Transaxle.............. 190
Shoulder Belts........................... 33
INDEX 337
10