2004 CHRYSLER 300 M timing belt

CAUTION!
Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and the
vehicle.
WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transaxle is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
Engine Timing Belt
Replace the engine timing belt at the intervals described
in the appropriate maintenance schedule.
Crankcase Emission Control System
Proper operation of this system depends on freedom
from sticking or plugging due to deposits. As vehicle
mileage builds up, the PCV valve and passages may
accumulate deposits. If a valve is not working properly,
MAINTAINING YOUR VEHICLE 207
7

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XXX X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.X
Flush and replace the engine coolant. X
Replace theengine timing belt(Federal Emis-
sions).X
Replace theengine timing belt(California
Emissions).X
Replace thespark plugs.X
Adjust the drive belt tension.X
Change the differential fluid. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 249
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.*X
Adjust the drive belt tension. X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt(Federal Emissions
equipped vehicles only).X
Replace theengine timing belt(California Emis-
sions equipped vehicles only).X
Flush and replace the engine coolant at 60 months
or 100,000 miles.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
252 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Disabled Vehicle Towing................. 193
Disposal
Antifreeze........................... 215
Engine Oil.......................... 205
Door Ajar............................. 114
Door Ajar Light........................ 114
Door Locks..........................14,15
Door Locks, Automatic................... 16
Door Locks, Central...................... 15
Door Opener, Garage...................75,80
Drive Belts............................ 205
Drive Shaft Universal Joints............... 211
Driver’s Seat Glide Feature................ 58
Driving
On Slippery Surfaces.................. 191
With an Automatic Transaxle............ 157
With an Automatic Transmission.......... 157
Electric Remote Mirrors................... 55
Electronic Speed Control.................. 71
Electronic Vehicle Information Center......... 88
Emergency Flashers..................... 182
Emission Control System Maintenance . 199,207,240Engine
Air Cleaner Filter..................... 206
Block Heater......................... 157
Break-In Recommendations............... 47
Checking Oil Level.................... 201
Compartment........................ 197
Cooling.......................... 114,214
Fails to Start......................... 156
Oil ............................. 113,201
Oil Change Interval................... 202
Oil Selection......................... 203
Oil Synthetic......................... 204
Overheating...................... 114,182
Timing Belt.......................... 207
Entry System, Illuminated................. 14
Exhaust Gas Caution..................47,214
Exhaust System........................ 213
Exterior Lights.......................66,230
Filler Location Fuel..................... 113
Filters
Air Cleaner.......................... 206
Automatic Transaxle................... 223
INDEX 269
10

Synthetic Engine Oil..................... 204
System, Navigation..................... 136
Tachometer........................... 113
Tape Player........................... 143
Temperature Gauge, Engine Coolant...... 114,183
Theft Alarm............................ 23
Theft System........................... 23
Tilt Steering Column..................... 70
Time Delay, Headlight.................... 67
Timing Belt........................... 207
Tires ...........................48,164,263
Air Pressure......................164,165
Alignment.......................... 174
Balancing........................... 174
Chains............................. 170
Changing........................183,184
Flat Changing........................ 183
High Speed......................... 168
Jacking............................. 184
Pressure Label....................... 165
Pressure Monitor System.............89,166
Quality Grading...................... 263Radial............................. 168
Replacement......................... 172
Rotation.........................167,173
Snow Tires.......................... 170
Spare Tire........................... 169
Spinning............................ 170
Tread Wear Indicators.................. 171
To Open Hood.......................... 63
Towing.............................. 179
Disabled Vehicle...................... 193
Trailering........................... 179
Traction Control...................70,113,163
Trailer Towing......................... 179
Transaxle
Additives........................... 223
Automatic........................157,221
Autostick........................... 159
Filter.............................. 223
Operation........................... 158
Selection of Lubricant.................. 221
Transmission
Range Indicator.................... 116,158
Transmitter Battery Service................ 23
276 INDEX