2004 CHEVROLET TRACKER boot

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Maintenance Requirements..............................6-2
Your Vehicle and the Environment....................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Selecting the Right Schedule...........................6-4
Short Trip/City Scheduled Maintenance..............6-7
Long Trip/Highway Scheduled Maintenance......6-17
Part B: Owner Checks and Services................6-24
At Each Fuel Fill..........................................6-24
At Least Once a Month.................................6-24
At Least Twice a Year...................................6-25At Least Once a Year...................................6-25
Part C: Periodic Maintenance Inspections.........6-28
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection............................6-28
Exhaust System Inspection............................6-28
Fuel System Inspection..................................6-28
Engine Cooling System Inspection...................6-28
Throttle System Inspection.............................6-29
Rear Axle and Front Axle (Four-Wheel-Drive)
Service....................................................6-29
Brake System Inspection................................6-29
Part D: Recommended Fluids and
Lubricants................................................6-30
Part E: Maintenance Record...........................6-32
Section 6 Maintenance Schedule
6-1

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-11.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-29.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
®ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-28

Inspection
Brake System.............................................6-29
Engine Cooling System................................6-28
Exhaust System..........................................6-28
Fuel System...............................................6-28
Part C - Periodic Maintenance.......................6-28
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-28
Throttle System...........................................6-29
Instrument Panel
Cluster.......................................................3-27
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-16
Instrument Panel Fuse Block............................5-94
Interior Lamps................................................3-16
J
Jump Starting.................................................5-43
K
Key Lock Cylinders Service..............................6-25
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-13
Interior.......................................................3-16
Lap Belt........................................................1-25
Lap-Shoulder Belt...................................1-15, 1-26
LATCH System
Child Restraints...........................................1-42
Securing a Child Restraint Designed for the
LATCH System........................................1-44
Leaving Your Vehicle......................................... 2-9
Leaving Your Vehicle With the Engine
Running.....................................................2-26
Light
Air Bag Readiness.......................................3-29
Anti-Lock Brake System Warning...................3-31
Brake System Warning.................................3-30
Charging System.........................................3-30
Four-Wheel-Drive.........................................3-37
Malfunction Indicator....................................3-33
Oil Pressure...............................................3-36
Overdrive Off..............................................3-37
Power Indicator...........................................3-37
Safety Belt Reminder...................................3-28
Loading Your Vehicle.......................................4-51
Loading Your Vehicle for Off-Road Driving..........4-16
7

Locks
Door........................................................... 2-6
Leaving Your Vehicle..................................... 2-9
Power Door.................................................. 2-7
Rear Door Security Locks............................... 2-8
Long Trip/Highway De®nition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-17
Loss of Control...............................................4-15
Luggage Carrier..............................................2-34
Lumbar
Manual Controls............................................ 1-3
M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule
At Each Fuel Fill.........................................6-24
At Least Once a Month................................6-24
At Least Once a Year..................................6-25
At Least Twice a Year..................................6-25
Brake System Inspection..............................6-29
Engine Cooling System Inspection.................6-28
Exhaust System Inspection...........................6-28
Fuel System Inspection................................6-28
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-17
Maintenance Requirements............................. 6-2Maintenance Schedule (cont.)
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-24
Part C - Periodic Maintenance Inspections......6-28
Part D - Recommended Fluids and
Lubricants...............................................6-30
Part E - Maintenance Record........................6-32
Rear Axle and Front Axle (Four-Wheel-Drive)
Service...................................................6-29
Selecting the Right Schedule.......................... 6-4
Short Trip/City Scheduled Maintenance............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-28
Throttle System Inspection............................6-29
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-64
Making Turns.................................................4-62
Malfunction Indicator Light................................3-33
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Manual Transmission.......................................2-14
Fluid..........................................................5-23
Operation...................................................2-20
Manual Windows............................................2-11
Matching Transmitter(s) to Your Vehicle............... 2-5
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-4
8

Shifting Out of Park (P)...................................2-27
Short Trip/City De®nition.................................... 6-5
Short Trip/City Intervals..................................... 6-5
Short Trip/City Scheduled Maintenance................ 6-7
Shoulder Belt Height Adjuster...........................1-17
Skidding........................................................4-15
Some Other Rainy Weather Tips.......................4-34
Special Fabric Cleaning Problems.....................5-87
Speci®cations, Capacities.................................5-98
Speedometer..................................................3-28
Stalling on an Incline.......................................4-27
Starter Switch Check.......................................6-26
Starting Your Engine.......................................2-14
Steering........................................................4-10
Steering in Emergencies..................................4-12
Steering, Suspension and Front Drive Axle Boot
and Seal Inspection.....................................6-28
Steering Tips..................................................4-10
Storage Areas
Coinholder(s)..............................................2-33
Convenience Net.........................................2-36
Cupholder(s)...............................................2-33
Glove Box..................................................2-33
Luggage Carrier..........................................2-34
Storing a Flat or Spare Tire and Tools...............5-84
Stuck in Sand, Mud, Ice or Snow......................4-44
Sun Visors.....................................................2-11
Supplemental Restraint System (SRS)...............1-52
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-59Supplemental Restraint System (SRS) (cont.)
How Does an Air Bag Restrain?....................1-56
Servicing Your Air Bag-Equipped Vehicle.........1-58
What Makes an Air Bag In¯ate?....................1-55
What Will You See After an Air Bag
In¯ates?..................................................1-56
When Should an Air Bag In¯ate?...................1-55
Where Are the Air Bags?..............................1-54
T
Tachometer....................................................3-28
Tailgate........................................................... 2-9
Tailgate Lock Release....................................... 2-9
Throttle System Inspection...............................6-29
Tilt Wheel........................................................ 3-5
Tire In¯ation Check.........................................6-24
Tire Sidewall Labeling......................................5-56
Tire Size.......................................................5-59
Tire Terminology and De®nitions........................5-60
Tires.............................................................5-55
Buying New Tires........................................5-67
Chains.......................................................5-71
Changing a Flat Tire....................................5-72
If a Tire Goes Flat.......................................5-72
In¯ation - Tire Pressure................................5-63
Inspection and Rotation................................5-64
Uniform Tire Quality Grading.........................5-68
Wheel Alignment and Tire Balance.................5-69
12