2004 CHEVROLET TAHOE spare wheel

A. Jack
B. Wheel Blocks
C. Wing Nut Holding
Tire Blocks
D. Mounting Bracket
E. Removable TrayF. Retaining Hook
G. Retaining Bracket
and Wing Nut
H. Tool Kit with
Jack Tools
Secondary Latch System
Your vehicle has an underbody mounted tire hoist
assembly equipped with a secondary latch system.
It’s designed to stop the spare tire from suddenly falling
off your vehicle. For the secondary latch to work, the
spare must be installed with the valve stem pointing
down. See “Storing a Flat or Spare Tire, Jack and Tools”
earlier in this section.
{CAUTION:
Before beginning this procedure read all the
instructions. Failure to read and follow the
instructions could damage the hoist assembly
and you and others could get hurt. Read and
follow the instructions listed below.
To release the spare tire from the secondary latch do
the following: Suburban
5-96

1. Check under the vehicle to see if the cable end is
visible.
2. If the cable is not visible proceed to Step 6.
If it is visible, rst try to tighten the cable by turning
the wheel wrench clockwise until you hear two
clicks or feel it skip twice. You cannot overtighten
the cable.
3. Loosen the cable by turning the wrench
counterclockwise three or four turns.4. Repeat this procedure at least two times. If the
spare tire lowers to the ground, continue with
Step 5 of “Removing the Spare Tire and Tools”
earlier in this section.
5. Turn the wrench counterclockwise until
approximately six inches (15 cm) of cable is
exposed.
6. Stand the wheel blocks
on their shortest ends,
with the backs
facing each other.
5-97

7. Place the bottom edge of the jack on the wheel
blocks, separating them so that the jack is
balanced securely.
8. Attach the jack handle, extension, and wheel
wrench to the jack and place it (with the wheel
blocks) under the vehicle towards the front of the
rear bumper. Position the center lift point of the jack
under the center of the spare tire.
9. Turn the wrench clockwise to raise the jack until it
lifts the end tting.
10. Continue raising the jack until the spare tire stops
moving upward and is held rmly in place. The
secondary latch has released and the spare tire is
balancing on the jack.
5-98

11. Lower the jack by turning the wheel wrench
counterclockwise. Keep lowering the jack until the
spare tire slides off the jack or is hanging by
the cable.
{CAUTION:
Someone standing too close during the
procedure could be injured by the jack. If the
spare tire does not slide off the jack completely,
make sure no one is behind you or on either
side of you as you pull the jack out from
the spare.
12. Disconnect the jack handle from the jack and
carefully remove the jack. Use one hand to push
against the spare while rmly pulling the jack out
from under the spare tire with the other hand.
If the spare tire is hanging from the cable, insert
the hoist handle, extension and wheel wrench into
the hoist shaft hole in the bumper and turn the
wheel wrench counterclockwise to lower the spare
the rest of the way.13. Tilt the retainer (D) at
the end of the cable
and pull it through
the wheel opening. Pull
the tire out from
under the vehicle.
14. If the cable is hanging under the vehicle, turn the
wheel wrench in the hoist shaft hole in the bumper
clockwise to raise the cable back up.
Have the hoist assembly inspected as soon as you can.
You will not be able to store a spare or at tire using
the hoist assembly until it has been replaced.
To continue changing the at tire, see “Removing
the Flat Tire and Installing the Spare Tire” earlier in
this section.
5-99

Spare Tire
Your vehicle, when new, had a fully inated spare tire.
A spare tire may lose air over time, so check its
ination pressure regularly. SeeInation - Tire Pressure
on page 5-69andLoading Your Vehicle on page 4-58
for information regarding proper tire ination and loading
your vehicle. For instruction on how to remove, install
or store a spare tire, seeChanging a Flat Tire on
page 5-80.
After installing the spare tire on your vehicle, you should
stop as soon as possible and make sure the spare is
correctly inated. Have the damaged or at road
tire repaired or replaced as soon as you can and
installed back onto your vehicle. This way, a spare tire
will be available in case you need it again.
Your vehicle may have a different size spare tire than
the road tires, those originally installed on your vehicle.
This spare tire was developed for use on your vehicle,
so it is all right to drive on it. If your vehicle has
four-wheel-drive and the smaller spare is installed, keep
the vehicle in two-wheel-drive mode as much as
possible.
Appearance Care
Cleaning products can be hazardous. Some are toxic.
Other cleaning products can burst into ames if a match
is struck near them or if they or get on a hot part of
the vehicle. Some are dangerous if their fumes
are inhales in a closed space. When anything from a
container is used to clean the vehicle, be sure to follow
the manufacturer’s warnings and instructions. And
always open the doors or windows of the vehicle when
cleaning the inside.
Never use these to clean the vehicle:
Gasoline
Benzene
Naphtha
Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
Lacquer Thinner
Nail Polish Remover
They can all be hazardous — some more than
others — and they can all damage the vehicle, too.
5-100

Spare Tire....................................................5-100
Special Fabric Cleaning Problems....................5-102
Specications, Capacities...............................5-118
Speedometer..................................................3-41
Split Bench Seat (50/50)..................................1-13
Split Bench Seat (60/40)..................................1-11
Stabilitrak
®, All-Wheel Drive..............................2-35
Stabilitrak®System.........................................4-12
STABILITY SYS ACTIVE..................................3-74
STABILITY SYS DISABLED..............................3-74
Stalling on an Incline.......................................4-36
Starting Your Engine.......................................2-23
Steering........................................................4-15
Steering in Emergencies..................................4-16
Steering Tips..................................................4-15
Steering Wheel Controls, Audio.......................3-136
Steering Wheel, Tilt Wheel................................. 3-7
Step-Bumper Pad...........................................4-82
Stereo RCA Jacks.........................................3-124
Storage Areas
Center Console Storage Area........................2-63
Convenience Net.........................................2-65
Cupholder(s)...............................................2-63
Front Storage Area......................................2-63
Glove Box..................................................2-63
Luggage Carrier..........................................2-63
Rear Storage Area.......................................2-65
Storing a Flat or Spare Tire, Jack and Tools.......5-92
Stuck in Sand, Mud, Ice or Snow......................4-52Sun Visors.....................................................2-18
Sunroof.........................................................2-66
T
Tachometer....................................................3-41
Taillamps.......................................................5-59
Temperature and Compass Display....................2-46
Temperature Display........................................2-49
Testing the Alarm............................................2-20
Theft-Deterrent, Radio....................................3-135
Theft-Deterrent Systems...................................2-18
Content Theft-Deterrent................................2-18
Passlock
®...................................................2-20
Third Row......................................................1-67
Throttle, Adjustable..........................................2-24
TIGHTEN FUEL CAP......................................3-75
Tilt Wheel........................................................ 3-7
Tilting the 50/50 Split Bench Seat.....................1-14
Tilting the Bench Seat.....................................1-19
Tire
Pressure Light.............................................3-49
Tire Sidewall Labeling......................................5-62
Tire Size.......................................................5-65
Tire Terminology and Denitions........................5-66
Tires.............................................................5-61
Buying New Tires........................................5-74
Chains.......................................................5-79
15

Tires (cont.)
Changing a Flat Tire....................................5-80
If a Tire Goes Flat.......................................5-80
Ination - Tire Pressure................................5-69
Inspection and Rotation................................5-72
Pressure Monitor System..............................5-70
Spare Tire................................................5-100
Uniform Tire Quality Grading.........................5-76
Wheel Alignment and Tire Balance.................5-77
Wheel Replacement.....................................5-77
When It Is Time for New Tires......................5-74
To Use the Engine Coolant Heater....................2-25
Top Strap......................................................1-58
Top Strap Anchor Location...............................1-59
Torque Lock...................................................2-41
Total Weight on Your Vehicle’s Tires..................4-72
Tow/Haul Mode...............................................2-29
Tow/Haul Mode Light.......................................3-54
Towing
Recreational Vehicle.....................................4-55
Towing a Trailer..........................................4-65
Your Vehicle...............................................4-55
Traction
Assist System (TAS)...................................... 4-9
Off Light.....................................................3-46
Stabilitrak
®System......................................4-12
TRACTION ACTIVE........................................3-75
Traction Control Operation................................4-13
TRACTION SYS LIMITED................................3-75Trailer
Recommendations.......................................4-65
Trailer Brakes.................................................4-73
Trailer Wiring Harness.....................................4-78
Transfer Case........................................5-50, 5-52
Transmission
Fluid, Automatic...........................................5-24
Temperature Gage.......................................3-48
TRANSMISSION HOT.....................................3-75
Transmission Operation, Automatic....................2-26
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-11
Transportation Options...................................... 7-8
Traveling to Remote Areas...............................4-27
Trip Information Button....................................3-57
Trip Odometer................................................3-41
Turn and Lane Change Signals.......................... 3-8
TURN SIGNAL ON.........................................3-76
Turn Signal/Multifunction Lever........................... 3-7
Turn Signals When Towing a Trailer..................4-75
U
Underhood Fuse Block...................................5-113
Understanding Radio Reception.......................3-137
Uniform Tire Quality Grading............................5-76
United States – Customer Assistance.................. 7-4
Used Replacement Wheels..............................5-78
Using Cleaner on Fabric................................5-101
16