2004 CHEVROLET OPTRA coolant level

3. Fill the coolant surge tank with the proper mixture
to the MAX (A) mark on the coolant surge tank.
Wait about five minutes, then check to see if
the level is below the MAX (A) mark. If the level is
below the MAX (A) mark, add additional coolant
to bring the level up to the MAX (A) mark. Repeat
this procedure until the level remains constant
at the MAX (A) mark for at least five minutes.4. With the coolant surge tank pressure cap off, start
the engine and let it run until you can feel the upper
radiator hose getting hot. Watch out for the
engine cooling fan.
By this time, the coolant level inside the coolant
surge tank may be lower. If the level is lower than
the MAX (A) mark, add more of the proper
mixture to the coolant surge tank until the level
reaches the MAX (A) mark.
5. Then replace the pressure cap. Be sure the
pressure cap is hand-tight and fully seated.
See your dealer, if necessary.
5-32

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specified to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-14for further
details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mixture if necessary. SeeEngine Coolant on
page 5-21for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the windshield
washer tank and add the proper fluid if necessary. See
Windshield Washer Fluid on page 5-34for further details.
At Least Once a Month
Tire Ination Check
Visually inspect your tires and make sure tires are inflated
to the correct pressures. Do not forget to check your
spare tire. SeeTires on page 5-51for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-40for further details.
6-18

Engine (cont.)
Engine Compartment Overview......................5-12
Exhaust.....................................................2-33
Oil .............................................................5-14
Overheating................................................5-24
Starting......................................................2-19
Engine Compartment Fuse Block......................5-86
Engine Coolant Level Check.............................6-18
Engine Oil Additives........................................5-17
Engine Oil Level Check...................................6-18
Event Data Recorders (EDR)............................7-10
Express-Down Window....................................2-15
Exterior Lamps...............................................3-12
F
Filter
Engine Air Cleaner......................................5-18
Finding a Station....................................3-40, 3-44
Finish Care....................................................5-77
Finish Damage...............................................5-78
Five-Speed....................................................2-27
Flash-to-Pass Feature....................................... 3-7
Flat Tire........................................................5-63
Flat Tire, Changing.........................................5-64Fluid
Automatic Transaxle.....................................5-20
Manual Transaxle........................................5-20
Power Steering...........................................5-33
Windshield Washer......................................5-34
FM ...............................................................3-51
Fog Lamp Light..............................................3-37
Fog Lamps..............................................3-7, 3-14
Folding the Seatback........................................ 1-8
Footnotes................................................6-7, 6-13
Front Armrest Storage Area..............................2-39
Front Storage Area.........................................2-38
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-39
Gasoline Octane........................................... 5-5
Gasoline Specifications.................................. 5-5
Low Warning Light.......................................3-39
System Inspection.......................................6-23
Fuses
Fuses and Circuit Breakers...........................5-83
Windshield Wiper.........................................5-82
5