2004 CHEVROLET COLORADO automatic transmission

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
The key should come out only in LOCK.
With a manual transmission, the key should come
out only in LOCK.
Contact your GM Goodwrench dealer if service
is required.
Parking Brake and Automatic
Transmission Park (P) Mechanism Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release the parking brake followed by the
regular brake.
Contact your GM Goodwrench dealer if service
is required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-11

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM Standard
GM6094M and displays the
American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
oil meets all the requirements for your
vehicle. To determine the proper
viscosity for your vehicle’s engine,
seeEngine Oil on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-25.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Usage Fluid/Lubricant
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242) or lubricant meeting
requirements of NLGI #2, Category
LB or GC-LB.
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 89021184, in Canada
89021186).
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Manual
TransmissionManual Transmission Fluid (GM Part
No. U.S. 89021806, in Canada
89021807).
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517) or equivalent DOT-3
brake uid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242) or lubricant meeting
requirements of NLGI #2, Category
LB or GC-LB.
6-12

Normal Maintenance Replacement Parts
Replacement parts identied below by name, part number, or specication can be obtained from your dealer.
Part GM Part Number ACDelco®Part Number
Transmission Filter Kit
Automatic 24225323 —
Engine Air Cleaner/Filter 15202408 —
Engine Oil Filter
2.8 L Engine
3.5 L Engine88984215
89017342PF46
PF61
Fuel Filter 25121800 GF624
Spark Plugs 25337472 41-981
Windshield Wiper Blades GM Part Number
Driver’s Side15169017
Passenger’s Side15169018
Wiper Blade Length – Driver’s 22 inches (55 cm)
Wiper Blade Length – Passenger’s 19 inches (48 cm)
6-14

Audio System(s) (cont.)
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
Theft-Deterrent Feature................................3-58
Understanding Radio Reception.....................3-59
Automatic Door Locks.....................................3-31
Automatic Headlamp System.............................. 3-7
Automatic Transmission...................................2-19
Fluid..........................................................5-19
Operation...................................................2-22
B
Backing Up....................................................4-67
BATTERY......................................................3-33
Battery..........................................................5-42
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-10
Battery Warning Light......................................3-21
Bed Rails......................................................2-45
Before Leaving on a Long Trip.........................4-34
Before You Go Off-Roading..............................4-15
Brake
Parking......................................................2-31
System Warning Light..................................3-22
Brake Adjustment............................................5-41
Brake Fluid....................................................5-39
Brake Pedal Travel.........................................5-41Brake Wear...................................................5-41
BRAKES.......................................................3-33
Brakes..........................................................5-39
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-17
Bulb Replacement...........................................5-50
Center High-Mounted Stoplamp (CHMSL)........5-53
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-52
Halogen Bulbs............................................5-50
Headlamps.................................................5-50
Replacement Bulbs......................................5-54
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps........................................5-53
Buying New Tires...........................................5-67
C
California Fuel.................................................. 5-6
Canada – Customer Assistance.......................... 7-5
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-8
Capacities and Specications..........................5-107
Carbon Monoxide...................2-10, 2-36, 4-38, 4-57
Care of
Safety Belts................................................5-97
Your CD Player...........................................3-59
Your CDs ...................................................3-59
2

F
Fan Knob......................................................3-12
Filter
Engine Air Cleaner......................................5-18
Finding a Program Type (PTY) Station.......3-42, 3-51
Finding a Station............................3-37, 3-40, 3-48
Finish Care....................................................5-98
Finish Damage.............................................5-100
Five-Speed....................................................2-25
Fixed Mast Antenna........................................3-59
Flat Tire........................................................5-73
Flat Tire, Changing.........................................5-74
FLUID...........................................................3-34
Fluid
Automatic Transmission................................5-19
Manual Transmission....................................5-22
Power Steering...........................................5-36
Windshield Washer......................................5-37
FM ...............................................................3-59
Fog Lamps...................................................... 3-9
Following Distance..........................................4-66
Four-Wheel Drive....................................2-27, 5-48
Front Armrest Storage Area..............................2-44
Front Axle......................................................5-49
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6Fuel (cont.)
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-29
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
FUEL CAP.....................................................3-34
Fuses
Fuses and Circuit Breakers.........................5-104
Windshield Wiper.......................................5-103
G
Gage
Engine Coolant Temperature.........................3-24
Fuel..........................................................3-29
Speedometer..............................................3-17
Tachometer.................................................3-18
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Getting Familiar with Off-Road Driving................4-16
Glove Box.....................................................2-44
GM Mobility Program for Persons with
Disabilities.................................................... 7-6
GM Oil Life System™......................................3-30
6

M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-16
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-14
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-69
Making Turns.................................................4-67
Malfunction Indicator Light................................3-24
Manual Lumbar Controls.................................... 1-5
Manual Seats................................................... 1-3
Manual Transmission.......................................2-19
Fluid..........................................................5-22
Operation...................................................2-25
Manual Windows............................................2-12Map Lamps....................................................2-39
Matching Transmitter(s) to Your Vehicle............... 2-5
Message
DIC Warnings and Messages........................3-32
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) – Customer Assistance....... 7-5
Mirror Operation.............................................2-38
Mirrors
Automatic Dimming Rearview with Compass
and Temperature Display...........................2-38
Manual Rearview Mirror................................2-37
Manual Rearview Mirror with OnStar
®.............2-38
Outside Convex Mirror.................................2-42
Outside Manual Mirrors................................2-41
Outside Power Mirrors..................................2-41
Mode Buttons.................................................3-13
Mode Knob....................................................3-12
MyGMLink.com................................................ 7-4
N
New Vehicle Break-In......................................2-17
Normal Maintenance Replacement Parts............6-14
9

Theft-Deterrent Systems...................................2-14
Content Theft-Deterrent................................2-15
Passlock
®...................................................2-16
Tilt Wheel........................................................ 3-5
Tire Sidewall Labeling......................................5-57
Tire Size.......................................................5-61
Tire Terminology and Denitions........................5-62
Tires.............................................................5-57
Buying New Tires........................................5-67
Chains.......................................................5-72
Changing a Flat Tire....................................5-74
If a Tire Goes Flat.......................................5-73
Ination - Tire Pressure................................5-64
Inspection and Rotation................................5-65
Spare Tire..................................................5-93
Uniform Tire Quality Grading.........................5-69
Wheel Alignment and Tire Balance.................5-70
Wheel Replacement.....................................5-70
When It Is Time for New Tires......................5-67
To Use the Engine Coolant Heater....................2-21
Top Strap......................................................1-42
Top Strap Anchor Location...............................1-44
Torque Lock...................................................2-34
Total Weight on Your Vehicle’s Tires..................4-65
Towing
Recreational Vehicle.....................................4-44
Towing a Trailer..........................................4-57
Your Vehicle...............................................4-44Traction
Control System (TCS).................................... 4-8
TRACTION FAULT..........................................3-35
Trailer
Recommendations.......................................4-56
Trailer Brakes.................................................4-65
Transfer Case................................................5-48
Transmission
Fluid, Automatic...........................................5-19
Fluid, Manual..............................................5-22
Up-Shift Light..............................................3-22
Transmission Operation, Automatic....................2-22
Transmission Operation, Manual........................2-25
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-12
Transportation Options...................................... 7-9
Traveling to Remote Areas...............................4-16
Trip Information..............................................3-30
Trip Odometer................................................3-17
Truck-Camper Loading Information....................4-56
TURN SIGNAL...............................................3-35
Turn Signal/Multifunction Lever........................... 3-6
Turn Signals When Towing a Trailer..................4-67
Two-Tiered Loading.........................................4-55
14