3
75
3
Starting – Riding – Parking
Optional extra
General
warning
lighte ABS warning
light
l/
brake failure Malfunctions
OFF ON Only RESIDUAL BRAKING FUNCTION available in both circuits (
b 71)
OFF Flashes at 1 Hz ABS not available Pull-away test not completed (
b 72)
OFF Flashes at 4 Hz Only RESIDUAL BRAKING FUNCTION available in both circuits (
b 71)
Self-diagnosis not completed (b 72)
ON OFF Tail light/brake light defective (Maintenance Instructions,
b Chapter 2)
ON Flashes at 1 Hz At least one brake circuit without ABS (
b 70)
ON Flashes at 4 Hz At least one brake circuit in RESIDUAL BRAKING FUNCTION mode (
b 71)
Alternate
flashing at
1Hz Alternate flash-
ing at 1 Hz
Fluid level in BMW Integral ABS too low.
Check the motorcycle as follows:
– Ignition OFF: is brake pressure OK at
the brake levers?
– Are the brakes acting on both wheels?
– Is the brake system leaktight, no signs of brake fluid escaping?
The brake system is defective if the test
outcome is negative.
Alternate
flashing at 4
Hz Alternate flas-
hing at 4 Hz
Fluid level in the BMW Integral ABS is too
low, perform the checks listed above.
Only RESIDUAL BRAKING FUNCTION
available in at least one circuit (
b 71)
d Warning:
Do not ride the motorcycle if you
have any doubts about the
dependability of the brake system.
BMW Integral ABSOE - Fault table
10r28bkg3.book Seite 75 Dienstag, 25. Mai 2004 5:26 17
i
84
Index
AActive brake with ABSchanging brake fluid, 33
checking brake fluid level, 33
Anti-lock braking system notes, 68, 70-75
BBrake fluid
changing, 30
Brake fluid level
checking, 30
checking front, 31, 35
checking rear, 32, 36
Brake pads, checking, 29
Brake system checking, 28
general, 28, 29
with BMW Integral ABS, 33-36
without BMW Integral ABS, 30,
31, 32
Braking, precautions, 66
C
Capacity, 25
Catalytic converter, 51 safety instructions, 51
Centre stand, 54, 55
Checking brake fluid level, 30
Choke
cold start, 12, 61
Choke lever operation, 61
position, 12 Clock (in cockpit), 10
Closing the System case, 18
Clutch
fluid level, 37
lever, 26
Cockpit layout, 6
DDipswitch, 12
EEngine oil, 22 filler, 4, 23
level sight glass, 4
pressure warning light, 62
FFront brake
brake fluid level, 31, 35
brake fluid reservoir, 5
lever, 27
Fuel, 24 filler cap, 5
octane number, 25
refuelling, 24
Fuse box, 5
GGear shifts, 64, 65
General view
left side, 4
right side, 5
A - G
10r28bkg3.book Seite 84 Dienstag, 25. Mai 2004 5:26 17
i
85
Index
HHandlebar fittingleft, 12
right, 13
Handlebar levers, 26 clutch, 26
handbrake, 27
Hazard warning flashers, 11
Headlight beam throw adjustment, 38
Heated handlebar grips, 11, 13
Helmet holder, 14
High/low (dipped) headlight
switch, 12
Horn, 12
Hydraulic fluid clutch, 37
IIgnition switch and steering lock, 6
function, 8, 9
Ignition, switching on, 58, 59
Installing System case, 19
Instruments, 6
KKill switch, 13
LLight
general instructions, 38
headlight beam throw, 38
switch, 13
MMotorcycle equipment, 81
NNeutral, 59
OOctane number (fuel), 25
Odometer, 6
Oil filler, engine, 4, 22
Oil levelchecking, 22
engine oil pressure, 7, 62
sight glass, 4
Opening the System case, 17
Overheating, 60
PPower socket, 12 V, 4
RRear brake brake fluid reservoir, 5
Removing System case, 18
Residual braking, 34
Rev. counter, 6
Rider’s equipment, 80
Riding, 64
Running in, 57
H - R
10r28bkg3.book Seite 85 Dienstag, 25. Mai 2004 5:26 17
