2004 BMW 7 SERIES LONG maintenance

Vehicle Check
Maintenance work (continued)
• Brake system connections and lines: check
for leaks, damage and correct positioning
• Underbody, incl. all visible parts (i.e. trans-
mission, rear axle, fuel lines, exhaust
system), check for damage, leaks and
corrosion
• Steering components: check for clearance,
leaks, damage and wear
• Final Inspection: Road test with check of
– Brakes
– Steering
– Shock absorbers
– Gearbox
Brake fluid
Maintenance work
• Replace brake fluid
Spark plugs
Maintenance work
• Replace spark plugs at intervals of 100,000
miles
Automatic Transmission
Maintenance work
• Replace ATF at intervals of 100,000
7

Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State
Inspection(s)
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State
Inspection(s)
Spark plugs
yes no
Distance reading
Date, stamp and signature
Engine Oil
yes no
Vehicle check
Front BrakeBrake fluid
Rear Brake
Microfilter
State
Inspection(s)
Spark plugs
yes no
Distance reading
Date, stamp and signature
8
Evidence of maintenance work

Emission Control
Maintenance Schedule
The maintenance schedule as shown is
required for the proper functioning of the
emission control systems for optimum vehicle
performance and fuel economy.
Basic Engine
Engine oilAs specified by CBS
Engine oil filter As specified by CBS
Fuel System
Air filterAs specified by CBS
Ignition System
Spark plugs As specified by CBS
Emission Control Components
Oxygen sensorReplace at intervals
of 100,000 miles
Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced to maximize
vehicle fuel economy and minimize exhaust
pollution.
Battery Care
If your car is driven only for short distances of
less than 10 miles over a prolonged period of
time, without an occasional drive at highway
speeds, the engine’s charging system will not
maintain the battery. Insufficient use of the
vehicle could result in short term starting
problems and in the long term could damage
the battery.
In case the car is not operated for several
weeks it is advisable to:
a) slide battery switch to “Off”position. Refer
to “Battery Switch”in vehicle owner’s
manual.
b) consider using a proper trickle charger,
following the charger manufacturer’s
instructions, to maintain the battery’s state
of charge; or
c) consult your BMW center regarding battery
removal. Once removed, the battery must
be charged and stored in a cool, dry place
where it can be protected from freezing. If
the battery will be stored for over 3
months, it must be recharged every 3
months, or else it will become damaged
and useless.
Please consult with your BMW center for
further guidance and information.
16

Corrosion Protection
Extensive corrosion protection measures
implemented by BMW now make it possible
to offer a six-year limited anti-corrosion
warranty against rust perforation on your
vehicle provided that the vehicle is maintained
in accordance with the provisions of the New
Vehicle Limited Warranty as outlined in the
Warranty Section of this Statement (page 30).
The major degree of corrosion protection is
due to the electrophoretic dip painting
process which cathodically deposits paint
particles on all body parts, attracting paint
particles into the minutest cavities or seams.
Body parts are designed to provide optimum
corrosion protection.
During manufacture, exterior body parts
receive an additional corrosion protection
coat. Hood, trunk, doors and other body
parts are coated with PVC and sealed from
the outside.
All floor panels receive a resilient coating of
PVC for maximum protection against damage
due to stones, etc.
Corrosion protection materials tested over
many years are applied to the surfaces of
cavities and to the entire underside of the
vehicle during and after assembly.
Requirements for maintaining the six-year
limited anti-corrosion warranty are outlined in
the Warranty Section of this Statement (page
32).
Restoring corrosion protection
Please take care that anti-corrosion material
is replaced when your car is repaired after
body or chassis damage.
BMW will not accept any liability for any
parts and accessories not approved by
BMW.
Underbody maintenance
The underbody has to be cleaned at least
once a year, in spring, with plain water in
order to remove mud, chemical sediments
and other deposits. If those materials are not
removed, corrosion (rust) will occur on metal
components.
Your BMW center will do this anti-corrosion
service for you.
WARNING
Do not apply additional undercoating or rust-
proofing on or near the exhaust manifold,
exhaust pipes, catalytic converter or heat
shields. During driving, the substance used
for undercoating could overheat and cause a
fire.
17

New Vehicle Limited Warranty –
2004 Models (Valid Only in the
U.S.A. and Puerto Rico)
Warrantor
BMW NA warrants 2004 U.S. specification
vehicles distributed by BMW NA or sold
through the BMW NA European Delivery
Program against defects in materials or
workmanship to the first retail purchaser, and
each subsequent purchaser.
Warranty Period
The warranty period is 48 months or 50,000
miles, whichever occurs first.
Warranty Begins
This warranty begins on the date of first
retail sale, or the date the vehicle is first
placed in service as a demonstrator or
company vehicle, whichever is earlier.
Warranty Coverage
To obtain service under this warranty, the
vehicle must be brought, upon discovery of a
defect in material or workmanship, to the
workshop of any authorized BMW center,
during normal business hours. The BMW
center will, without charge for parts or labor,
either repair or replace the defective part(s)
using new or authorized remanufactured
parts. The decision to repair or replace said
part(s) is solely the prerogative of BMW NA.
Parts for which replacements are made
become the property of BMW NA.
In all cases, a reasonable time must be allowed
for warranty repairs to be completed after the
vehicle is received by the BMW center.
Safety Belt Warranty - Kansas
Safety belts are covered under the BMW New
Vehicle Limited Warranty for defects in
material or workmanship for a period of 10
years, unlimited mileage from the date of
purchase. In order to be eligible for this
coverage, the vehicle must be a new car
retailed in the State of Kansas and the repair
performed by an authorized BMW center in
Kansas.
Towing/Other Owner Benefits
A 24-hour Roadside Assistance Program is
available to every BMW owner during the new
vehicle warranty period.
Roadside assistance and other owner
benefits are available by calling:
1-800-332-4269
For additional details on towing and other
owner benefits please refer to the BMW
Roadside Assistance section of this
Statement (page 26).
Other Items
Wheel alignment, balancing and wiper blade
inserts are covered up to 2,000 miles.
Items which are subject to wear and tear
or deterioration due to driving habits or
conditions, such as brake pads/linings,
brake discs, clutch disc, pressure plate,
filters, upholstery, trim and chrome items,
paint finish, drive belts, glass, and similar
items, are specifically limited to defects in
material or workmanship.
This warranty does not apply to the follow-
ing:
Damage which results from negligence,
improper operation of the vehicle, improper
repair, lack of or improper maintenance,
environmental influences, flood, accident or
fire damage, road salt corrosion, or use of
improper or contaminated fuel.
Damage to the engine, transmission or any
related component caused by improper shift-
ing of the transmission.
Maintenance services and parts when
replaced during maintenance such as spark
plugs, lubricants, fluids, engine tuneup parts,
replacement of filters, coolant, and refriger-
ant.
Failure to maintain the vehicle properly in
accordance with the instructions in the
Owner’s Manual or the Service section of this
Statement, that results in the failure of any
part of the vehicle.
30

Modification of the vehicle or installation of
any performance accessories or components
attached to the vehicle which alters the origi-
nal engineering and/or operating specifica-
tions or which result in damage to the other
original components, electrical interference,
electrical short, radio static, water leaks and
wind noise.
Tires are warranted by their respective
manufacturer as detailed in the applicable tire
manufacturer’s warranty statements.
Instructions for proper tire care and mainte-
nance are contained in the Owner’s Manual.
Should you experience difficulty in obtaining
warranty service from a tire manufacturer,
your authorized BMW center will assist you in
resolving the difficulty.
Non-BMW Parts – While you may elect to use
non-genuine BMW parts for maintenance or
repair services, BMW NA is not obligated to
pay for repairs that include non-genuine BMW
parts or for any damage resulting from the
use of non-genuine parts.
BMW will not accept any liability for any
parts and accessories not approved by
BMW.
This warranty shall be null and void if the
vehicle identification number has been
altered or cannot be read, if the odometer
has been replaced or altered and the true
mileage cannot be determined, if the
vehicle has been declared a total loss or
sold for salvage purposes, or if the vehicle
has been used in any competitive event.
General
These warranties give you specific legal
rights, and you may also have other rights
which vary from state to state.
THE DURATION OF ANY IMPLIED
WARRANTIES, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY, IS
LIMITED TO THE DURATION OF THE
EXPRESS WARRANTIES HEREIN. BMW
NA HEREBY EXCLUDES INCIDENTAL AND
CONSEQUENTIAL DAMAGES, INCLUDING
LOSS OF TIME, INCONVENIENCE, OR
LOSS OF USE OF THE VEHICLE, FOR ANY
BREACH OF ANY EXPRESS OR IMPLIED
WARRANTY, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY,
APPLICABLE TO THIS PRODUCT.
Some states do not allow limitations on how
long an implied warranty lasts, or the exclu-
sion or limitation of incidental or consequen-
tial damages, so the above limitations and
exclusions may not apply to you.
31

Limited Warranty –
Rust Perforation 2004 Models
BMW NA warrants this original vehicle
against defects in materials or workmanship
which will result in rust perforation of the
vehicle body for a period of 6 years, without
mileage limitation, commencing on the date
of first retail sale, or the date the vehicle is
first placed in service as a demonstrator or
company vehicle, whichever is earlier.
To obtain service under this warranty, the
vehicle must be brought, upon discovery of
any rust perforation, to the workshop of any
authorized BMW center. This BMW center
will, without charge for parts or labor, either
repair or replace the defective part(s). The
decision to repair or replace said part(s) is
solely the prerogative of BMW of North
America. Parts for which replacements are
made become the property of BMW of North
America.
REQUIRED MAINTENANCE:
In order to keep this warranty in effect, the
vehicle must be inspected at least every two
years. Any areas requiring preventative
maintenance must be repaired. (THIS
INSPECTION/MAINTENANCE IS AT THE
OWNER’S EXPENSE).
The Inspection/Maintenance consists of:
a. Washing the chassis before inspection, if
necessary, due to dirt accumulation.
b. Repairing any damages to undercoating or
paint due to stone chips, gravel erosion,
scratches, or other external influences.
BMW of North America makes no other
express warranty on this product except the
new car warranty or the warranty as to the
emission control system. THE DURATION OF
ANY IMPLIED WARRANTIES, INCLUDING
THE IMPLIED WARRANTY OF
MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS
WARRANTIES HEREIN.
BMW OF NORTH AMERICA HEREBY
EXCLUDES INCIDENTAL AND CONSE-
QUENTIAL DAMAGES, INCLUDING LOSS
OF TIME, INCONVENIENCE, OR LOSS OFUSE OF THE VEHICLE, FOR ANY BREACH
OF ANY EXPRESS OR IMPLIED
WARRANTY, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY,
APPLICABLE TO THIS PRODUCT.
Some states do not allow limitations on how
long an implied warranty lasts, or the exclu-
sion or limitation of incidental or consequen-
tial damages, so the above limitations and
exclusions may not apply to you.
This warranty gives you specific legal rights,
and you may also have other rights which
vary from state to state. Any legal claim or
action arising from any express or implied
warranty contained herein must be brought
within 12 months of the date it arises.
This warranty does not apply to the
following:
a.Damage caused by negligence, improper
accident damage repairs, or improper use.
b. Damage attributable to failure to perform
required inspections/maintenance at the
specified intervals or in accordance with
the BMW rust inspection/maintenance
program instructions. Proof must be
provided by a paid invoice or filling in the
appropriate boxes in the Service Section
of this Statement.
BMW will not accept any liability for any
parts and accessories not approved by
BMW.
This warranty shall be null and void if the
vehicle identification number has been
altered or cannot be read, if the odometer
has been replaced or altered and the true
mileage cannot be determined, if the
vehicle has been declared a total loss or
sold for salvage purposes, or if the vehicle
has been used in any competitive event.
32

Federal Emissions System
Defect Warranty (Valid only in
the U.S.A. and Puerto Rico)
This warranty applies only to U.S. specifica-
tion vehicles distributed by BMW of North
America (BMW NA) or sold through the BMW
NA European Delivery Program.
In accordance with the defect warranty provi-
sions of section 207(b) of the Clean Air Act,
BMW NA warrants to the first retail purchaser,
and each subsequent purchaser, that the car
(a) was designed, built and equipped so as to
conform, at the time of sale, with all regula-
tions of the U.S. Environmental Protection
Agency applicable at the time of manufacture
and (b) is free from defects in materials and
workmanship which would cause it to fail to
conform with applicable regulations for a
period of 2 years or 24,000 miles, whichever
occurs first, except for specific emission
control components (as listed on page 36),
for which the warranty period is 8 years or
80,000 miles, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company
vehicle, whichever is earlier.
Warranty claims must be made as soon as
reasonably possible after a defect is discov-
ered. To make a claim, the car must be
brought to any authorized BMW center during
normal business hours.
The BMW center will, without charge for parts
or labor (including diagnosis), either repair or
replace the defective part, if any. The
decision whether to repair or replace said
parts is solely the prerogative of BMW NA
and must be expected to correct the failure of
the warranted part. Parts for which replace-
ments are made become the property of
BMW NA. In all cases, a reasonable time
must be allowed for warranty repairs to be
completed after the car is received by the
BMW center.
For assistance in determining which specific
parts or components of your vehicle are
covered under this warranty, please contact
your BMW center.It is the owner’s responsibility to have all
scheduled inspection and maintenance
services performed (at the owner’s expense),
as prescribed in the maintenance schedule
for the BMW Emission Control System.
Service intervals are computed by the
onboard BMW service interval indicator and
displayed on the instrument panel. The
instructions for proper maintenance and use
can be found in the Owner’s Manual. It is
strongly recommended that any replacement
parts used for maintenance, repair or replace-
ment of emission control systems be certified
BMW Service Parts or BMW Authorized
Remanufactured Parts. Without invalidating
this warranty, the owner may elect to have
maintenance, repair or replacement of the
emission control systems performed by any
automotive repair establishment, or elect to
use parts other than certified BMW Service
Parts. However, the cost of such service or
parts will not be covered under this warranty,
except in emergency situations. In an
emergency situation, where an authorized
BMW center or a warranty replacement part
is not reasonably available (within 30 days),
repairs may be performed at any available
service establishment using any equivalent
part. BMW NA will reimburse the owner for
such emergency repairs (including labor,
parts and diagnosis not to exceed BMW NA
rates for labor, parts, and diagnosis in said
area) that are covered under this warranty.
Replaced parts and paid invoices must be
presented at a BMW center as a condition of
reimbursement for emergency repairs not
performed by a BMW center.
The use of replacement parts, which are not
of equivalent quality, may impair the effective-
ness of the emission control system. If other
than certified BMW Service Parts or
Authorized Remanufactured Parts are used
for maintenance, repair or replacement of
components affecting emission control, the
owner should obtain assurances that such
parts are warranted by their manufacturer to
be equivalent to genuine BMW parts in
performance and durability. BMW NA
assumes no liability under this warranty with
respect to parts other than genuine BMW
parts.
33