2004 BMW 3 SERIES instrument panel

3 Con-
Series vertible
Check battery state-of-charge indicator and charge if required.  
Check lighting system, i.e.: headlights, foglights, parking, back-up,  
license plate, interior (including map reading lights), glove box, flashlight,
illuminated makeup mirrors, luggage compartment/area lights.
Check instrument panel and dashboard illumination.  
Check all warning/indicator lights, check control.  
Check turn signals, hazard warning flashers, brake lights, horns, headlight  
dimmer and flasher switch.
Check wipers and washer system(s); wiper blades, washer jet positions.  
Check condition and function of safety belts.  
Visually examine all SRS airbag units for torn covers, obvious damage or  
attachment of decals, decorations or accessories.
Check central locking/double lock.  
Check operation of all latches.  
Check heater/air conditioner blower, rear window defogger.  
Check rear view mirrors.  
Activate automatic roll-over protection system via OBD plug. 
Note: First remove hardtop/lower top.
Lubricate convertible top sliding linkage covers. 
Final Inspection
Road test with check of brakes, suspension, steering, clutch/manual  
transmission or automatic transmission.
7
Inspection I
Body/Electrical

This warranty applies only to U.S. specifica-
tion vehicles distributed by BMW of North
America (BMW NA) or sold through the BMW
NA European Delivery Program.
In accordance with the defect warranty
provisions of section 207(b) of the Clean Air
Act, BMW NA warrants to the first retail
purchaser, and each subsequent purchaser,
that the car (a) was designed, built and
equipped so as to conform, at the time of
sale, with all regulations of the U.S. Environ-
mental Protection Agency applicable at the
time of manufacture and (b) is free from
defects in materials and workmanship which
would cause it to fail to conform with
applicable regulations for a period of 2 years
or 24,000 miles, whichever occurs first,
except for specific emission control compo-
nents (as listed on page 36), for which the
warranty period is 8 years or 80,000 miles,
whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company vehicle,
whichever is earlier.
Warranty claims must be made as soon as
reasonably possible after a defect is
discovered. To make a claim, the car must
be brought to any authorized BMW center
during normal business hours.
The BMW center will, without charge for parts
or labor (including diagnosis), either repair or
replace the defective part, if any. The decision
whether to repair or replace said parts is solely
the prerogative of BMW NA and must be
expected to correct the failure of the warranted
part. Parts for which replacements are made
become the property of BMW NA. In all cases,
a reasonable time must be allowed for
warranty repairs to be completed after the car
is received by the BMW center.For assistance in determining which specific
parts or components of your vehicle are
covered under this warranty, please contact
your BMW center.
It is the owner’s responsibility to have all
scheduled inspection and maintenance
services performed (at the owner’s ex-
pense), as prescribed in the maintenance
schedule for the BMW Emission Control
System. Service intervals are computed by
the onboard BMW service interval indicator
and displayed on the instrument panel. The
instructions for proper maintenance and use
can be found in the Owner’s Manual. It is
strongly recommended that any replacement
parts used for maintenance, repair or
replacement of emission control systems be
certified BMW Service Parts or BMW
Authorized Remanufactured Parts. Without
invalidating this warranty, the owner may
elect to have maintenance, repair or
replacement of the emission control systems
performed by any automotive repair estab-
lishment, or elect to use parts other than
certified BMW Service Parts. However, the
cost of such service or parts will not be
covered under this warranty, except in
emergency situations. In an emergency
situation, where an authorized BMW center
or a warranty replacement part is not
reasonably available (within 30 days),
repairs may be performed at any available
service establishment using any equivalent
part. BMW NA will reimburse the owner for
such emergency repairs (including labor,
parts and diagnosis not to exceed BMW NA
rates for labor, parts, and diagnosis in said
area) that are covered under this warranty.
Replaced parts and paid invoices must be
presented at a BMW center as a condition of
reimbursement for emergency repairs not
performed by a BMW center.
The use of replacement parts, which are not
of equivalent quality, may impair the effec-
tiveness of the emission control system. If
other than certified BMW Service Parts or
Authorized Remanufactured Parts are used
for maintenance, repair or replacement of
components affecting emission control, the
owner should obtain assurances that such
Federal Emissions System
Defect Warranty
(Valid only in the U.S.A. and
Puerto Rico)
30

35 This warranty applies to California certified
vehicles distributed by BMW of North America
(BMW NA) or sold through the BMW NA
European Delivery Program, registered and
operated primarily in California.
BMW NA warrants to the original purchaser and
each subsequent owner that the vehicle is:
(a) designed, built and equipped so as to
conform with the applicable California Air
Resources Board emission standards.
(b) free from defects in materials and workman-
ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 3 years or 50,000 miles, which-
ever occurs first.
(c) free from defects in materials and workman-
ship in emission related parts, which are
contained in the California Emission
Warranty Parts List on page 40, for a period
of 7 years or 70,000 miles, whichever
occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in
service as a demonstrator or company vehicle,
whichever is earlier.
To obtain service under this warranty, the
vehicle must be brought, upon failure of a
Smog Check test or upon discovery of the
defect, to the workshop of any authorized
BMW center, during normal business hours.
The BMW center will honor or deny your claim
within 30 days. If the claim is denied, the BMW
center will notify you in writing of the reason(s).
The BMW center is required by law to honor
the claim if notice is not given to the owner
within 30 days.
The BMW center will, without charge for parts
or labor (including diagnosis), either adjust,
repair or replace the defective part and other
parts affected by the failure of the warranted
part, if any. If your vehicle failed the California
California Emission Control
System Limited Warranty*Smog Check test or an EPA approved short
test, then BMW NA will repair your vehicle so
that it will pass this test. Items that require
scheduled replacement are warranted up to
the replacement interval specified in the
Service section of this Statement. BMW NA
may repair a part in lieu of replacing it when
performing warranty repairs. Parts for which
replacements are made become the property
of BMW NA. After 3 years or 50,000 miles, and
in accordance with paragraph (c) above, such
repairs are limited to the repair or replacement
of those parts identified in the California
Emissions Warranty List.
If your California registered vehicle is between
7 and 8 years old and has been driven less
than 80,000 miles, then your vehicle is eligible
for additional warranty coverage under the
Federal Emissions Warranty.
A repair performed as the result of a smog
check test failure due to a defect in a part,
which is warranted for 7 years/70,000 miles, is
covered.
In all cases, a reasonable time, not to exceed
30 days, must be allowed for a warranty repair
to be completed, after the car is received by
the BMW center.
It is the owner’s responsibility to have all
required maintenance services performed (at
the owner’s expense), as prescribed in the
maintenance schedule for the BMW Emission
Control System. Service intervals are com-
puted by the service interval indicator and
displayed on the instrument panel.
However, BMW NA will not deny your warranty
repair claims solely because you do not have
maintenance records or you did not perform
the required maintenance unless BMW NA
demonstrates that such lack of required
maintenance is a direct cause of the emission
control system failure. The instructions for
required maintenance and use can be found
in the Owner’s Manual and in the Service
section of this Statement.
*The California Emissions Control System
Limited Warranty applies to all 2004 U.S.