2004 Acura TSX radiator

CONT INUED
Pour Honda All Season
Antif reeze/Coolant Type 2 into
the radiator up to the base of the
f iller neck. This coolant is a
mixture of 50 percent antif reeze
and 50 percent water. Pre-mixing
is not required.Fill the reserve tank to the MAX
mark. Install the reserve tank cap.
Install the radiator cap, and
tighten it to the first stop.
The cooling system capacity is:
Start the engine, let it run f or
about 30 seconds, then turn it of f .
Fill the radiator with coolant up to
the base of the f iller neck.
Start the engine, let it run until the
radiator cooling f an comes on at
leasttwice,thenturnitoff.
7.
10.
11.
12.
8.
9.
With automatic transmission:
With manual transmission:
Maint enance
Cooling Syst em
253
Fill up to here
RESERVE TANK
FILLER NECK
1.43 US gal (5.4)
1.40 US gal (5.3
)

Remove the radiator cap. Pour
coolant into the radiator up to the
base of the f iller neck and into the
reserve tank up to the MAX mark.
Start the engine and hold it at
1,500 rpm until the cooling f an
comes on. Turn of f the engine.
Check the coolant level in the
radiator and add coolant if needed.
Install the radiator cap, and
tighten it fully.
If necessary, f ill the reserve tank
to the MAX mark. Install the
reserve tank cap.
16. 15.
14.
13.
Cooling Syst em
Maint enance254

Run the air conditioning at least once
a week during the cold weather
months. Run it f or at least ten
minutes while you are driving at a
steady speed with the engine at
normal operating temperature. This
circulates the lubricating oil con-
tained in the ref rigerant.If the air conditioning does not get as
cold as before, have your dealer
check the system. Recharge the
system with Ref rigerant HFC-134a
(R-134a). (See Specif ications on page
.)
Your car’s air conditioning is a sealed
system. Any major maintenance,
such as recharging, should be done
by a qualif ied mechanic. You can do
a couple of things to make sure the
air conditioning works ef f iciently.
Periodically check the engine’s
radiator and air conditioning
condenser f or leaves, insects, and
dirt stuck to the f ront surf ace. These
block the air f low and reduce cooling
ef f iciency. Use a light spray f rom a
hose or a sof t brush to remove them. 334
A ir Condit ioning Syst em
Maint enance269
AIR CONDITIONING CONDENSER
Whenever you have the air conditioning
system serviced, make sure the service
f acility uses a ref rigerant recycling
system. This system captures the
ref rigerant f or reuse. Releasing
ref rigerant into the atmosphere can
damage the environment.
The condenser and radiator f ins bend
easily. Only use a low-pressure spray
or sof t-bristle brush to clean them.

If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open the
hood.
If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointerreaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.
Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page
). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks. Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see on page ). Start the engine and set the
temperature control to its upper
limit, . Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
4.
5.
6.
7.
8. 9.10.
328
189 11.
12.
328
T aking Care of t he Unexpect ed
If Your Engine Overheats
Emergency
Towing
Emergency
Towing
316
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

ÎÎ
...................
Radiator Overheating . 315
.....
Radio/CD Sound System . 129,148
..
Rear Lights, Bulb Replacement . 286
..........................
Rear Seat Armrest .95
..........................
Rear Seat, Folding .94
..........................
Rear View Mirror .102
.................
Rear Window Def ogger . 75
.........
Reclining the Seat Backs . 91,92
.......
Recommended Shif t Speeds . 202
.............................
Reminder Lights .59
.......................
Remote Transmitter .83
Replacement Inf ormation .................
Air Cleaner Element . 261
.......................................
Coolant .251
................
Engine Oil and Filter . 246
..........................................
Fuses .324 ................................
Light Bulbs .282
....................................
Schedule .232
................................
Spark Plugs .262
...........................................
Tires .276
.............................
Wiper Blades .267
Replacing Seat Belts Af ter a ............................................
Crash .45
.................
Reserve Tank, Coolant . 189
...............................
Restraint, Child .21
..................
Reverse Gear Position . 206
................................
Rotation, Tire .276
........................................
Saf ety Belts .8
.........
Safety Defects, Reporting . 350
.................................
Saf ety Features .7
...........................................
Airbags .9
..................................
Door Locks .11
..........................
Head Restraints .11
.......................................
Seat Belts .8
..................
Seats and Seat-Backs . 10
.............
Saf ety Labels, Location of . 54
...............................
Saf ety Messages .ii
...........................................
Seat Belts .8
...............
Additional Information . 43Automatic Seat Belt
...............................
Tensioners .44
.....................................
Cleaning .299
......................
Lap/Shoulder Belt .43
................................
Maintenance .45
Reminder Light and ................................
Beeper .43, 60
...................
System Components . 43
...............
Use During Pregnancy . 19
........................
Seats, Adjusting the .90
............................
Security System .173
.........................
Select/Reset Knob .68
...............................
Serial Number .332
...........................
Service Intervals .234
...........................
Service Manual .351
.........
Service Station Procedures . 184
..................
Setting the Clock . 135,153
.....
Shif t Lever Position Indicator . 204
........................
Shif t Lock Release .210
....................................
Side Airbags .48
...
How Your Side Airbags Work . 48
How The SIDE Airbag Cutof f ...........
Indicator Light Works . 50
......................
Side Curtain Airbags .49
How Your Side Curtain ..........................
Airbags Work .49
........................
Protecting Children .21
.......................
Protecting Inf ants .30
.......
Protecting Larger Children . 36
.........
Protecting Small Children . 33
Using Child Seats with .....................................
Tethers .39
.............................
Using LATCH .41
Index
R
S
VI