2004 Acura TL Manual transmission

If you have a f lat tire while driving,
stop in a saf e place to change it.
Drive slowly along the shoulder until
you get to an exit or an area to stop
that is far away from the traffic lanes.Park the vehicle on f irm, level, and
non-slippery ground. Put the
transmission in Park (automatic)
or Reverse (manual). Apply the
parking brake.
Turn on the hazard warning lights,
and turn the ignition switch to
LOCK (0). Have all the
passengers get out of the vehicle
while you change the tire.Open the trunk. Raise the trunk
f loor by lif ting up on the back edge.
Take the tool case out of the spare
tire.
Unscrew the wing bolt and take
the spare tire out of its well.
5. 4.
3.
2. 1.
CONT INUED
Changing a Flat T ire
T aking Care of t he Unexpect ed231
TOOL CASE
JACK
TRUNK FLOOR
SPARE TIRE
The vehicle can easily roll off
the jack, seriously injuring
anyone underneath.
Follow the directions for
changing a tire exactly, and
never get under the vehicle
when it is supported only by the
jack.

Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run. When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See on page . Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
the f uses are OK, there is
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ).
Check these things:
If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page).
Check the transmission interlock.
If you have a manual transmission,
the clutch pedal must be pushed
all the way to the f loor or the
starter will not operate. With an
automatic transmission, the shif t
lever must be in Park or Neutral.
238 226
238 249
If theEngineWon’tStart
T aking Care of t he Unexpect ed
Nothing Happens or the Starter
Motor Operates Very Slowly
Jump Starting Emergency T owing
236

µ
µ µ
There are three popular types of
prof essional towing equipment.
Shif t the transmission to Neutral.
ShifttoD,thentoN.
Turn of f the engine.
The tow
truck uses metal cables with hooks
on the ends. These hooks go around
parts of the f rame or suspension and
the cables lif t that end of the vehicle
of f the ground. Your vehicle’s sus-
pension and body can be seriously
damaged.
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
behind another vehicle with just a
rope or chain. It is very dangerous.
The operator
loads your vehicle on the back of a
truck.
The tow
truck uses two pivoting arms that go
under the tires (f ront or rear) and lif t
them of f the ground. The other two
tires remain on the ground. If your Acura cannot be transported
by f lat-bed, it should be towed by
wheel-lif t equipment with the f ront
wheels of f the ground. If , due to
damage, your vehicle must be towed
with the f ront wheels on the ground,
do the f ollowing: Release the parking brake.
Start the engine. Release the parking brake.
Automatic Transmission:
6-speed Manual Transmission:
Sling-t ype Equipment
Flat -bed Equipment Wheel-lif t Equipment
T his method of towing
is unacceptable.
T his is the best way to
transport your A cura.
T his is
an acceptable way to tow your
Acura.
Emergency T owing
T aking Care of t he Unexpect ed249
NOTICE: Improper towing preparation
will damage the transmission. Follow
the above procedure exactly. If you
cannot shif t the transmission or start
the engine (automatic transmission),
your vehicle must be transported with
the f ront wheels of f the ground.

µµÎ
Î
Î
Î
Specif ications
T echnical Inf ormation256
Dimensions
Weights
Air Conditioning
Capacities Capacities
186.2 in (4,730 mm)
72.2 in (1,835 mm)
56.7 in (1,441 mm)
107.9 in (2,740 mm)
62.1 in (1,577 mm)
62.0 in (1,576 mm)
HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) ND-OIL8
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb.
Refrigerant type
Charge quantity
Lubricant type
Fuel tank Engine
coolant
Engine oil
Automatic
transmission
fluid
Manual
transmission
fluid
Windshield
washer
reservoir
2.6 US qt (2.5
)
7.6 US qt (7.2
)
3.1 US qt (2.9)
5.3 US qt (5.0)
4.2 US qt (4.0
)
4.5 US qt (4.3
)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity: 0.16 US gal (0.6
)
Excluding the oil remaining in the engine. 2.3 US qt (2.2
)
2.6 US qt (2.5)
4.8 US qt (4.5
)
2.14 US gal (8.1
)
2.09 US gal (7.9)
1.66 US gal (6.3
)
1.69 US gal (6.4)
Approx.
Front
Rear
1:
2:Change
Manual
Automatic
Total Manual
Automatic
Change Including
filter
Without
filter
Total
Change
Total
Change
Total
U.S. Vehicle
Canada Vehicle
17.09 US gal (64.7)
1
2

µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Î
Î
Î
Î
ÎÎ
Specif ications
T echnical Inf ormation257
Lights
Battery
Fuses Engine
Alignment
Tires
3.50 x 3.39 in (89.0 x 86.0 mm)
12 V 21/5 W
195.8 cu-in (3,210 cm
)
Water cooled 4-stroke
SOHC VTEC 6-cylinder (V6), gasoline engine
12 V 21 W 12 V 51 W (HB4)
DRL (Canadian models)
Front turn signal/Side marker/
Parking lights
Fog Lights
Rear turn signal lights
Back-up lights
License plate light
Ceiling light
Trunk light
Door courtesy lights
Vanity mirror lights
Spotlights 12 V
12 V
12 V
12 V
12 V
12 V
12 V21 CP
3CP
5W
5W
2CP
5W
4CP
Capacity 65 AH/20 HR
Interior
Under-hood 12 V51 W (HB3)
12 V
11 : 1
See page 248or the fuse label
attached to the inside of the fuse
box door on each side of the
dashboard.
See page 247or the fuse box
cover. Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Toe-in
Camber
Caster
0.00 in (0.0 mm)
0.08 in (2.0 mm)
0°30’
1°00’
3°17’
P235/45R17 93W 235/45R17 93W IZFR6K-11
SKJ20DR-M11
35 psi (240 kPa , 2.4 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
32 psi (220 kPa , 2.2 kgf/cm)
60 psi (420 kPa , 4.2 kgf/cm)
Size
Pressure
T145/70R17 96M T135/80R16 101M
Front
Rear
Front
Rear
Front
NGK:
DENSO:
Front/Rear
Spare
Front
Rear
Spare A/T Vehicles:
M/T Vehicles:
All season tire
Summer tire
Vehicles with manual transmission
Vehicles with automatic transmission
1:
2:
3:
4:
1
2
34

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the ambient
temperature is between 20° and
95°F.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions. If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more. Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
CONT INUED
St at e Emissions T est ing
T esting of Readiness Codes
T echnical Inf ormation263

ÎCONT INUED
...............
Gas Mileage, Improving . 168
.........................................
Gasoline .164
...............
Fuel Reserve Indicator . 56
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Tank, Filling the .165
................
Gas Station Procedures . 165
...................................
Fan, Interior .122
Features, Comfort and ..............................
Convenience .109
....................
Filling the Fuel Tank . 165
........................................
Filter, Oil .205
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 231
.....................................
Floor Mats .218
Fluids ..........
Automatic Transmission . 209
..........................................
Brake .211
.........................................
Clutch .211
..............
Manual Transmission . 210
..........................
Power Steering .212
................
Windshield Washers . 208
FM Stereo Radio ...................................
Reception .122
.....................................
Fog Lights .75 ..........................
Four-way Flashers .76
..............................
Front Airbags .9 ,22
......................................
Front Seats .90
......................................
Adjusting .90
.........................................
Heaters .96
.....................................
Airbags .9, 22
.................................................
Fuel .164
......................
Fill Door and Cap .165
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Reserve Indicator .56
........................
Tank, Filling the .165
.....................
Fuses, Checking the .245
..................
Checking the Fuses . 245
.........
Hazard Warning Flashers . 76
......
If Your Vehicle Gets Stuck . 249
............................
Jump Starting .238
.....
Low Oil Pressure Indicator . 242
...
Malf unction Indicator Lamp . 243
..................
Overheated Engine . 240
.......................................
Towing .249
.........................
Emergency Brake .103
......................
Emergency Flashers .76
......................
Emergency Towing .249
............
Emergency Trunk Opener . 84
.......................
Emissions Controls .260
.............
Emissions Testing, State . 263
Engine ....
Coolant Temperature Gauge . 57
Malf unction Indicator ................................
Lamp .52, 243
.........................................
Oil Lif e .64
........
Oil Pressure Indicator . 52,242
..............
Oil, What Kind to Use . 204
...............................
Overheating .240
............................
Specif ications .257
....................
Speed Limiter . 179,185
.......................................
Starting .177
...................
Engine, .236 ......................
Ethanol in Gasoline .164
.
Evaporative Emissions Controls . 260
...............................
Exhaust Fumes .46
Expectant Mothers, Use of Seat ........................................
Belts by .17
if it won’t start
Index
F
G
III

ÎÎÎ
ÎÎ.................
Jacking up the Vehicle . 232
.......................................
Jack, Tire .231
................................
Jump Starting .238
Gauges
...
Engine Coolant Temperature . 57
...............................................
Fuel .57
...............................
Speedometer .57
.................................
Tachometer .57
Gearshif t Lever Positions ..........
Automatic Transmission . 181
6-speed Manual .........................
Transmission .178
......................................
Glove Box .107 ...
Identif ication Number, Vehicle . 254
Ignition ..............................................
Keys .79
...........................................
Switch .80
............
Timing Control System . 261
........................
Immobilizer System .81
.........
Important Safety Precautions . 6
.........................................
Indicators .52
......
ABS (Anti-Lock Brake) . 53,189
Brake (Parking and Brake ............................
System) .52, 244
................
Charging System . 52,242
.............................
Cruise Control .54
DRL (Daytime Running ..................................
Lights) .55
...................................
Fog Light .56
...................................
High Beam .55
........
Key (Immobilizer System) . 56
......................................
Low Fuel .56 ................
Low Oil Pressure . 54,242
...........................
Side Airbag Of f .53
.........................................
SRS .26, 53
Turn Signal and Hazard ...................................
Warning .55
............................
VSA Activation .54
.................................
VSA System .54
...............................
Inf ant Restraint .34
......................................
Inf ant Seats .34
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 221
...................................
Inside Mirror .91
.............................
Inspection, Tire .222
............................
Instrument Panel .51
..........
Instrument Panel Indicators . 52
........
Instrument Panel Brightness . 75
...............................
Interior Lights .104
........................................
Introduction .i
.......................
Halogen Fog Bulbs .213
..........
HandsFree Link (HFL) . 70,149
..............
Hazard Warning Flashers . 76
........................................
Headlights .74
........................................
Aiming .213
Automatic Lighting Off .....................................
Feature .76
.......
Daytime Running Lights . 74
..................
High Beam Indicator . 55
.........................
Reminder Chime .74
...................................
Turning on .74
..............................
Head Restraints .89
.................
High-Low Beam Switch . 74HomeLink Universal
................................
Transceiver .145
....................................
Hood Latch .212
.......................
Hood, Opening the .166
Index
H I
J
IV