2003 YAMAHA BIG BEAR PRO 400 oil type

5-13
EBU00492*
Engine oil/Transfer gear oil
Make sure the engine oil/transfer gear oil is at the
specified level. Add oil as necessary. (See pages
8-13 ~ 8-25.)
Recommended oil:
Recommended engine oil classification:
API Service SE, SF, SG type or higher
-20˚ -10˚ 0˚
10˚20˚ 30˚40˚50˚C
10W/30
15W/4020W/4020W/50
10W/40
5W/30
EE.book Page 13 Monday, June 18, 2001 10:18 AM

5-14
FBU00492*
Huile de moteur/huile de boîte intermédiaire
S’assurer que l’huile de moteur et l’huile de boîte inter-
médiaire sont au niveau spécifié. Ajouter de l’huile si né-
cessaire. (Voir pages 8-14 à 8-26.)
Huile recommandée:
Classification d’huile de moteur recommandée:
Huiles de type API Service, de classe SE, SF,
SG min.
-20˚ -10˚ 0˚
10˚20˚ 30˚40˚50˚C
10W/30
15W/4020W/4020W/50
10W/40
5W/30
SBU00492*
Aceite del motor/Aceite de la caja transfer
Asegúrese de que el aceite del motor/caja transfer se
encuentra al nivel especificado. Añada aceite según
se requiera. (Ver página 8-14 ~ 8-26.)
Recommended oil:
Recommended engine oil classification:
API Service SE, SF, SG type or higher
-20˚-10˚0˚
10˚20˚30˚40˚50˚C
10W/30
15W/4020W/4020W/50
10W/40
5W/30
EE.book Page 14 Monday, June 18, 2001 10:18 AM

8-59
3. Refill with the same type of brake fluid. Mixing
fluids may result in a harmful chemical reac-
tion and lead to poor brake performance.
4. Be careful that water does not enter the mas-
ter cylinder when refilling. Water will signifi-
cantly lower the boiling point of the fluid and
may result in vapor lock.
5. Brake fluid may deteriorate painted surfaces
or plastic parts. Always clean up spilled fluid
immediately.
6. Have a Yamaha dealer check the cause if the
brake fluid level goes down. Recommended brake fluid:DOT 4
EE.book Page 59 Monday, June 18, 2001 10:18 AM

10-1
EBU00428
1-SPECIFICATIONS
Model YFM400FP/YFM400FW
Dimensions:
Overall length 1,956 mm
Overall width 1,155 mm
Overall height 1,144 mm
Seat height 845 mm
Wheelbase 1,210 mm
Minimum ground clearance 215 mm
Minimum turning radius 3,500 mm
Basic weight:
With oil and full fuel tank 286 kg
Engine:
Engine type Air-cooled 4-stroke, SOHC
Cylinder arrangement Forward-inclined single cylinder
Displacement 386 cm
3
Bore
× stroke 83.0 ×
71.5 mm
Compression ratio 8.6:1
Starting system Electric and recoil starter
Lubrication system Wet sump
EE.book Page 1 Monday, June 18, 2001 10:18 AM

10-2
10
Noise and vibration level:
Noise level (77/311/EEC) 87.1 dB (A)
Vibration on seat (EN1032, ISO5008) Not exceed 0.5 m/s
2
Vibration on handlebar (EN1032, ISO5008) Not exceed 2.5 m/s
2
Engine oil/Transfer gear oil:
Type
Recommended engine oil classification: API Service SE, SF, SG type or higherModel YFM400FP/YFM400FW
-20˚-10˚0˚
10˚20˚30˚40˚50˚C
10W/30
15W/4020W/4020W/50
10W/40
5W/30
CAUTION:
Be sure to use motor oils that do not contain anti-
friction modifiers. Passenger car motor oils (often
labeled “Energy Conserving II”) contain anti-fric-
tion additives which will cause clutch and/or
starter clutch slippage, resulting in reduced com-
ponent life and poor engine performance.
EE.book Page 2 Monday, June 18, 2001 10:18 AM

10-3
Quantity:
Periodic oil change (engine oil): 2.4 L
Periodic oil change
(engine oil with oil filter replacement): 2.5 L
Periodic oil change
(engine oil and transfer gear oil with
oil filter replacement):3.1 L
Transfer gear case oil 0.3 L
Total amount 3.4 L
Final gear oil:
Type SAE 80 API “GL-4” Hypoid gear oil
Quantity
Periodic oil change 0.19 L
Total amount 0.25 L
Air filter: Wet type element
Differential gear oil:
Type SAE80 API “GL-4” Hypoid gear oil
Quantity:
Periodic oil change 0.47 L
Total amount 0.5 LModel YFM400FP/YFM400FW
EE.book Page 3 Monday, June 18, 2001 10:18 AM

10-6
Suspension:
Front suspension Double wishbone
Rear suspension Swingarm (monocross)
Shock absorber:
Front shock absorber Coil spring / Oil damper
Rear shock absorber Coil spring / Oil damper
Wheel travel:
Front wheel travel 100 mm
Rear wheel travel 110 mm
Electrical:
Ignition system D.C. C.D.I.
Generator system A.C. magneto
Battery type YTX 20L-BS
Battery voltage, capacity 12 V, 18 AH
Headlight type: Bulb type
Bulb voltage, wattage
× quantity:
Headlight 12 V, 30 W / 30 W
× 2
Tail / brake light 12 V, 5 W / 21 W × 1
Meter light 12 V, 3 W
× 1
Indicator light:
Neutral 12 V, 1.7 W
× 1
Reverse 12 V, 1.7 W × 1
Oil temperature 12 V, 1.7 W
× 1 Model YFM400FP/YFM400FW
EE.book Page 6 Monday, June 18, 2001 10:18 AM