2003 TOYOTA TUNDRA manual transmission

’03 TUNDRA_U (L/O 0307)
253
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Twowheel drive models—
(a) Towing with wheel lift type truck
From front—
Manual transmission:
We recommend using a towing dolly under
the rear wheels. If you do not use a tow-
ing dolly, release the parking brake and
put the transmission in neutral.
Automatic transmission:
Use a towing dolly under the rear wheels.
NOTICE
Never tow a vehicle with an automatic
transmission from the front with the
rear wheels on the ground, as this
may cause serious damage to the
transmission.
From rear— Place the ignition key in the
“ACC” position.
NOTICE
 When lifting wheels, take care to
ensure adequate ground clearance
for towing at the opposite end of
the raised vehicle. Otherwise, the
bumper and/or underbody of the
towed vehicle will be damaged dur-
ing towing.
 Do not tow with the key removed or
in the “LOCK” position, as the
steering lock mechanism is not
strong enough to hold the front
wheels straight while towing.
(b) Using flat bed truck Fourwheel drive models—
(a) Towing with wheel lift type truck
From front—
Manual transmission:
We recommend using a towing dolly under
the rear wheels. If you do not use a tow-
ing dolly, release the parking brake, put
the transmission in neutral and set the
transfer in “H2” mode.
Automatic transmission:
Use a towing dolly under the rear wheels.
NOTICE
Never tow a vehicle with an automatic
transmission from the front with the
rear wheels on the ground, as this
may cause serious damage to the
transmission.

’03 TUNDRA_U (L/O 0307)
256
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
A driver must be in the vehicle to steer
it and operate the brakes.
Towing in this manner may be done only
on hard−surfaced roads for a short dis-
tance and at low speeds. Also, the
wheels, axles, drive train, steering and
brakes must all be in good condition.
CAUTION
Use extreme caution when towing the
vehicle. Avoid sudden starts or errat-
ic driving maneuvers which would
place excessive stress on the emer-
gency towing hook and towing cable
or chain. The hook and towing cable
or chain may break and cause serious
injury or damage.
NOTICE
Use only a cable or chain specifically
intended for use in towing vehicles.
Securely fasten the cable or chain to
the towing hook provided.
Before towing, release the parking brake,
put the transmission in neutral (manual) or
“N” (automatic) and set the transfer in
“H2” (lever type) or “2WD” (button type)
mode. The key must be in “ACC” (engine
off) or “ON” (engine running).
CAUTION
If the engine is not running, the pow-
er assist for the brakes and steering
will not work so steering and braking
will be much harder than usual.
Before emergency towing, check that
the hook is not broken or damaged and
that the installation bolts are not loose.
Fasten the towing cable or chain se-
curely to the hook.
Do not jerk the hook. Apply steady and
even force.
To avoid damaging the hook, do not
pull from the side or at a vertical
angle. Always pull straight ahead.
—Emergency towing hook
precautions

’03 TUNDRA_U (L/O 0307)
309
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
U.S.A. kg (lb.)
Cab type
EngineDriving systemTransmission typeGrade∗ 1Deck typePayload∗2
Standard cab5VZ −FETw o −wheel driveManual transmissionStandardStandard bed714 (1575)
Automatic transmissionStandardStandard bed701 (1545)
2UZ −FEFour −wheel driveAutomatic transmissionSR5Standard bed776 (1710)
Access cab
5VZ −FE
Tw o −wheel driveManual transmissionSR5Standard bed699 (1540)
Automatic transmissionSR5Standard bed678 (1495)
Four −wheel driveManual transmissionSR5Standard bed710 (1565)
Automatic transmissionSR5Standard bed689 (1520)
2UZ −FE
Tw o −wheel driveAutomatic transmission
SR5Standard bed794 (1750)
StepSide bed687 (1515)
LimitedStandard bed816 (1800)
StepSide bed726 (1600)
Four −wheel driveAutomatic transmission
SR5Standard bed669 (1475)
StepSide bed576 (1270)
LimitedStandard bed692 (1525)
StepSide bed601 (1325)
∗
1: See “Model code” on page vi in the beginning of this m anual if you are not sure of which model your vehicle is.∗
2:
Occupants + luggage (Payload is the maximum weight th e vehicle should carry with standard equipment. Depending
on the number of options equipped on your vehicle, the pa yload may differ from the figures on the tire and loading
information label on your vehicle.)
Payload

’03 TUNDRA_U (L/O 0307)
313
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt., Imp.
qt.):
5VZ− FE engine
With filter 5.2 (5.5, 4.6)
Without filter 4.9 (5.2, 4.3)
2UZ− FE engine
With filter 6.2 (6.5, 5.5)
Without filter 5.7 (6.0, 5.0)
“Toyota Genuine Motor Oil” is filled in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and
viscosity.
Oil grade: API grade SL “Energy −Conserving” or
ILSAC multigrade engine oil Recommended oil viscosity:
SAE 5W −30
Outside temperature
Please contact your Toyota dealer for fur-
ther details.
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
With manual transmission 10.0 (10.6, 8.8)
With automatic transmission 5VZ− FE engine 9.9 (10.5, 8.7)
2UZ− FE engine 11.6 (12.3, 10.2) Coolant type:
“Toyota Genuine Long Life Coolant” is
filled in your Toyota vehicle. In order to
avoid technical problems, we strongly
recommend using “Toyota Genuine Long
Life Coolant” or equivalent.
With ethylene− glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
Please contact your Toyota dealer for
further details.
BATTERY
Open voltage∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max.

’03 TUNDRA_U (L/O 0307)
314
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
CLUTCH
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSMISSION
Oil capacity, L (qt., Imp. qt.): Tw o −wheel drive models
2.6 (2.7, 2.3)
Four −wheel drive models
2.2 (2.3, 1.9)
Oil type: Gear oil API GL −4 or GL −5
Recommended oil viscosity: SAE 75W −90
AUTOMATIC TRANSMISSION
Fluid capacity (drain and refill), L (qt.,
Imp. qt.): Up to 2.0 (2.1, 1.8)
Fluid type: Toyota Genuine ATF Type T −IV
Change automatic transmission fluid only
as necessary. Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only “Toyota Genuine ATF Type T
−IV”
(ATF JWS3309 or NWS6500) to aid in
assuring optimum transmission perfor-
mance.
Notice: Using automatic transmission
fluid other than “Toyota Genuine ATF
Type TIV” may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle.
Please contact your Toyota dealer for fur-
ther details.
TRANSFER
Oil capacity, L (qt., Imp. qt.):
1.0 (1.1, 0.9)
Oil type: Gear oil API GL−4 or GL−5
Recommended oil viscosity: SAE 75W −90 DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.):
Front1.15 (1.2, 1.0)
Rear
Tw o −wheel drive models
Standard differential
3.80 (4.0, 3.3)
Limited− slip differential
3.15 (3.3, 2.8)
Four −wheel drive models
Standard differential 3.50 (3.7, 3.1)
Limited− slip differential
2.95 (3.1, 2.6)
Oil type: Standard differentialHypoid gear oil API GL −5
Limited− slip differential
Hypoid gear oil for limited −slip differ-
ential API GL −5

’03 TUNDRA_U (L/O 0307)
322
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
CAUTION
If a load is too far back, it can cause
dangerous handling. If it is too far
forward, the front axle may be over-
loaded.
Camper center of gravity
Recommended center of
gravity location zoneCARGO WEIGHT RATING
Standard cab models 453 kg (1000 lb.)
Access cab models
5 people, V6, 2WD, Manual transmission 295 kg (650 lb.)
6 people, V6, 2WD, Automatic transmission 226 kg (500 lb.)
5 people, V6, 4WD, Manual transmission
295 kg (650 lb.)
6 people, V6, 4WD, Automatic transmission 226 kg (500 lb.)
6 people, V8, 2WD, Standard bed 340 kg (750 lb.)
6 people, V8, 2WD, StepSide bed 226 kg (500 lb.)
6 people, V8, 4WD, Standard bed 181 kg (400 lb.)
6 people, V8, 4WD, StepSide bed 68 kg (150 lb.)
—Cargo weight rating and
proper matching

’03 TUNDRA_U (L/O 0307)
2
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Cranking hold function 214
. . . . . . . . . . . . . . . .
Cruise control 123
. . . . . . . . . . . . . . . . . . . . . . .
Cup holders 179
. . . . . . . . . . . . . . . . . . . . . . . . .
D
Differential, Limited slip 197
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 92
. . . . . . . . . . . . . .
Dinghy towing 219
. . . . . . . . . . . . . . . . . . . . . . .
Directional signals 92
. . . . . . . . . . . . . . . . . . . .
Discharge warning light 104
. . . . . . . . . . . . . . .
Do −it−yourself maintenance
Parts and tools 276
. . . . . . . . . . . . . . . . . . . . .
Service precautions 274
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 269 . . . . .
Doors
Access door 14
. . . . . . . . . . . . . . . . . . . . . . . .
Front door 12
. . . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 104 . . . . . .
Driver ’s seat belt reminder light 104 . . . . . . . .
Driving
Automatic transmission 113
. . . . . . . . . . . . .
Driving tips 214
. . . . . . . . . . . . . . . . . . . . . . . .
Manual transmission 117
. . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 215 . . . . .
Driving with a manual transmission 117
. . . . . . . . . . . . . . . . . . . . .
Driving with an automatic transmission 113
. . . . . . . . . . . . . . . . . . . . .
Economical driving 230
. . . . . . . . . . . . . . . . .
Good driving practice 113,117
. . . . . . . . . . .
Winter driving tips 218
. . . . . . . . . . . . . . . . . .
During
Break −in 187
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 230 . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical system
Battery 296,297 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 274 . . . . . . . . . . . . . . . . . . . . .
Fuses 298 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 93 . . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 298 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 93 . . . . . . . . . . . .
Flat tire 239 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 238 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you lose your keys 257 . . . . . . . . . . . . . . . .
If you lose your remote keyless entry transmitter 258 . . . . . . . . . . . . . . . . . . . . . .
If your engine stalls while driving 237 . . . . . . . . . . . . . . . . . . . . . . . . . .
If your vehicle becomes stuck 251 . . . . . . .
If your vehicle needs to be towed 252 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 234 . . . . . . . . . .
Jump starting 235 . . . . . . . . . . . . . . . . . . . . . .
Overheating 238 . . . . . . . . . . . . . . . . . . . . . . .
Towing 252 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 270 . . . . . . . . .
Engine
Before starting the engine 214 . . . . . . . . . . .
Checking the coolant level 282 . . . . . . . . . .
Emission control device 190 . . . . . . . . . . . . .
Engine compartment 272 . . . . . . . . . . . . . . . Exhaust gas caution 191
. . . . . . . . . . . . . . . .
Hood release 23 . . . . . . . . . . . . . . . . . . . . . . .
Identification number 198 . . . . . . . . . . . . . . .
Oil consumption 192 . . . . . . . . . . . . . . . . . . . .
Oil level 280 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil pressure gauge 101 . . . . . . . . . . . . . . . . .
Overheating 238 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 214 . . . . . . . . . . . . . . . . .
Three −way catalytic converters 190 . . . . . .
Engine coolant
Temperature gauge 100 . . . . . . . . . . . . . . . . .
Winter driving tips 218 . . . . . . . . . . . . . . . . . .
Engine coolant temperature
gauge 100 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine oil
Winter driving tips 218 . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 101 . . . . . . . . . . . . .
Exhaust gas caution 191 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 192 . . . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 92 . . . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 250 . . . . . . . . . . . . . .
Changing tire 247 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 239 . . . . . . . . . . . . . . . .
Jack point 245 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 239 . . . . . . . . . . . . . . . .
Jacking up 246 . . . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 245 . . . . . . . . . . . . . . .
Lowering vehicle 248 . . . . . . . . . . . . . . . . . . .
Reinstalling wheel ornament 249 . . . . . . . . .

’03 TUNDRA_U (L/O 0307)
4
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Stop/tail/rear side marker
lights 303,304 . . . . . . . . . . . . . . . . . . . . . . .
Light bulbs, Replacing 299 . . . . . . . . . . . . . . . .
Light, Interior
Ignition switch light 95 . . . . . . . . . . . . . . . . . .
Interior light 94 . . . . . . . . . . . . . . . . . . . . . . . .
Personal light 95 . . . . . . . . . . . . . . . . . . . . . . .
Step light 95 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limited slip differential 197 . . . . . . . . . . . . . . . .
Load capacity 208 . . . . . . . . . . . . . . . . . . . . . . . .
Lock
Front doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 112 . . . . . . . . . . . . . . . . . . .
Tailgate 22 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low engine oil pressure warning
light 104 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 104 . . . . . . . . . . . .
Low windshield washer fluid level warning light 104 . . . . . . . . . . . . . . . . . . . . . . .
M
Maintenance
Do −it−yourself maintenance 274 . . . . . . . . .
Does your vehicle need repairing? 269 . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 267 . . . . . . . . . . . . . . .
Maintenance requirements 266 . . . . . . . . . .
Parts and tools 276 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 266 . . . . . . . . . . . . .
Malfunction indicator lamp 270 . . . . . . . . . . . .
Malfunction indicator lamp
Emissions Inspection and Maintenance (I/M) programs 104 . . . . . . .
Service reminder indicator 104 . . . . . . . . . . Manual transmission
Driving with a manual transmission 117 . . . . . . . . . . . . . . . . . . . . .
Shift pattern 117 . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 117 . . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed
Automatic transmission 113 . . . . . . . . . . . . .
Manual transmission 117 . . . . . . . . . . . . . . .
Mirror
Anti −glare inside rear view 88
. . . . . . . . . . .
Mirrors
Folding rear view 88
. . . . . . . . . . . . . . . . . . . .
Outside rear view 87
. . . . . . . . . . . . . . . . . . .
Power rear view 87
. . . . . . . . . . . . . . . . . . . . .
Vanity 90
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle break −in 187 . . . . . . . . . . . . . . . . .
Note pad holder 182 . . . . . . . . . . . . . . . . . . . . . .
O
Odometer 103
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Off −road driving precautions 217
. . . . . . . . . .
Off −road vehicle precautions 186
. . . . . . . . . .
Oil
Consumption 192
. . . . . . . . . . . . . . . . . . . . . .
Power steering 285
. . . . . . . . . . . . . . . . . . . . .
Pressure gauge 101
. . . . . . . . . . . . . . . . . . . .
Viscosity and grade 280
. . . . . . . . . . . . . . . .
Oil consumption 192
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 104
. . . . . . . . . . . . . . .
Operation in foreign countries 189
. . . . . . . . . Outside rear view mirror heaters 98
. . . . . . . .
Overdrive switch 113
. . . . . . . . . . . . . . . . . . . . .
Overheating, Engine 238
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 100
. . . . . . . . . .
Overview
Engine compartment 272
. . . . . . . . . . . . . . .
P
Parking brake
Operation 123 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 123 . . . . . . . . . . . . . . . . . . . . .
Passenger airbag manual on −off
switch 56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 261 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power outlet 167 . . . . . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 87 . . . . . . . . . .
Power rear window 21 . . . . . . . . . . . . . . . . . . . .
Power steering
Fluid level 285 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 18 . . . . . . . . . . . . . . . .
Preloaders
(seat belt pretensioners) 45 . . . . . . . . . . . . .
Pretensioners
(seat belt pretensioners) 45
. . . . . . . . . . . . .
Protecting your Toyota from
corrosion 260
. . . . . . . . . . . . . . . . . . . . . . . . . .
R
Radiator
Checking the radiator 284 . . . . . . . . . . . . . . .
Coolant, Engine 282 . . . . . . . . . . . . . . . . . . . .
Radio 128 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .