2003 OLDSMOBILE AURORA power steering

Power Steering Fluid
The power steering fluid
reservoir is near the center
of the engine compartment
on the passenger’s side
of the vehicle. See
Engine
Compartment Overview
on page 5-14 for more
information
on location. I
When to Check Power Steering Fluid
It is not necessary to regularly check power steering fluid
unless you suspect there is a leak in the system or
you hear an unusual noise. A fluid
loss in this system
and repaired. See
Engine Compartment Overview
on page 5-74 for reservoir location.
~n~rlrl inrlie-tn Q nrnhlnm Uq~,n thn rrrrrtnm innnn-+mA ““UlU II IU#”UL” LA y3VuI-I I I. I IUVU LI 1- eyer-I I I I1 IqJbULbU
How to Check Power Steering Fluid
Turn the key off, let the engine compartment cool down,
wipe the cap and the top of the reservoir clean, then
unscrew the cap and wipe the dipstick with a clean rag.
Replace the cap and completely tighten it. Then
remove the cap again and look at the fluid !eve!
on the
dipstick.
The level should be at the
FULL COLD mark. If
necessary, add only enough fluid to bring the level up to
the mark.
What to Use
To determine what kind of fluid to use, see Part D:
Recommended Fluids and Lubricants on page 6-15.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
5-37
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See
Service Publications
Ordering Information on page
7-9.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
iirles artJ i~uses iur pruper i1uui.i-up, bit Idit 16, it=ai.is,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals
if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts
as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page
2-33.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
6-1 3
ProCarManuals.com

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identified below by name, part
number or specification may be obtained from your
dealer.
Usage
I Fluid/Lubricant
Engine Oil Engine oil with the
American
Petroleum Institute Certified for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engme Oil on
page 5- 15.
50/50 mixture of clean, drinkable
water and use only DEX-COOL
Coolant. See
Enqlne Coolant on Engine Coolant
Windshield GM Optikleen Washer Solvent or
Washer Solvent
I eauivalent.
Parking Brake Cable Guides Chassis Lubricant
(GM Part
No.
US. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGl #2,
Category LB or GC-LB.
GM Power Steering Fluid (GM Part
No. US. i052884, in Canada power
System 993294, or equivalent).
I Usaae I FluidLubricant
I 8,"gFEi; I Fluid. DEXRON-Ill Automatic Transmission
Y
Multi-Purpose Lubricant, Superlube
GM Part No.
U.S. 12346241, in Ke Lock
inders Lanada 10953474, or
equivalent).
Floor Shift Linkage Lubri late
Lubricant Aerosol (GM
Part
L 0. U.S. 12346293, in Canada
992723, or equivalent)
or lubricant
meeting re uirements of NLGl #2,
Cateqow
L a or GC-LB.
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Sprin Anchor and
w elease
Pawl Lubri
late Lubricant Aerosol (GM
Part
R 0. US. 12346293, in Canada
992723, or equivalent) or lubricant
meeting re uirements of NLGl #2,
Category
L a or GC-LB.
Multi-Purpose Lubricant, Superlube
Hoo~,a,ngde~oor FM anada Part 10953474, No. US. 12346241, or equivalent). in
Fuel Door,
Glove
Box
Door, Console
Door and Rear
Compartment Lid Hinges Multi-Purpose
Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
6-1 5
ProCarManuals.com

Accessory Power Outlets ................................. 3-21
Adding Washer Fluid
....................................... 5-38
Additional Program Information
........................... 7-8
Additives, Fuel
................................................. 5-6
Add-on Electrical Equipment
............................ 5-91
Adjusting the Speakers (Balance/Fade)
.............. 3-62
Air Bag
Readiness Light
.......................................... 3-34
Air Bag Systems
............................................. 1-47
How Does an Air Bag Restrain? .................... 1-52
Servicing Your Air Bag-Equipped Vehicle
......... 1-54
What Makes an Air Bag Inflate?
.................... 1-52
What Will You See After an Air Bag Inflates? ...... 1-52
When Should an Air Bag Inflate?
................... 1-51
Where Are the Air Bags?
.............................. 1-49
Air CleanedFilter, Engine
................................. 5-21
All Overseas Locations
...................................... 7-4
Aluminum or Chrome-Plated Wheels
.................. 5-86
Antenna, Diversity
........................................... 3-76
Anti-Lock Brake, System Warning Light
.............. 3-36
Appearance Care
............................................ 5-82
Care
of Safety Belts .................................... 5-84
AM
............................................................... 3-74
r-11 It1-Iucln u1anG \JYQLGI II
uw) f-r A,-.+: I ,.-I, D.-~.I,A C?.,-+A- /A DC A7 ...........................
Appearance Care (cont.)
Chemical Paint Spotting
............................... 5-87
Cleaning the inside of Your Vehicle
................ 5-82
Cleaning the Outside of Your Vehicle
.............. 5-85
Finish Damage
............................................ 5-87
GM Vehicle Care/Appearance Materials
.......... 5-88
Sheet Metal Damage
................................ 5-87
Underbody Maintenance
........ ........ 5-87
Weatherstrips
........................... .... 5-84
Ashtrays
..................................... ........ 3-22
Assist Handles
............................................... 2-45
Audio System(s)
............................................. 3-59
Audio Systems
Audio Steering Wheel Controls
...................... 3-74
Care of Your Cassette Tape Player
................ 3-74
Care of Your CD Player
............................... 3-76
Care of Your CDs
........................................ 3-75
Chime Level Adjustment
............................... 3-76
Diversity Antenna System
............................. 3-76
NavigatiodRadio System
.............................. 3-69
Personal Choice Radio Controls
.................... 3-73
Radio with Cassette and CD
......................... 3-60
~eLlilly LIIt: I It lit3 3-a3
Theft-Deterrent Feature ................................ 3-73
Trunk-Mounted CD Changer
.......................... 3-70
Understanding Radio Reception
..................... 3-74
0 -LA:.- - . &I- - -r:.-- n rn ..........................................
1
ProCarManuals.com

F
FabricKarpet ................................................. 5-82
Filter Engine Air Cleaner
...................................... 5-21
Finding a PTY Station
..................................... 3-63
Finding a Station
............................................ 3-60
Finish Care
.................................................... 5-85
Finish Damage
............................................... 5-87
Flash-to-Pass
................................................... 3-8
Flat Tire
........................................................ 5-70
Flat Tire, Changing
......................................... 5-71
Floor Mats
..................................................... 2-46
Fluid Automatic Transaxle
..................................... 5-22
Power Steering
........................................... 5-37
Windshield Washer
...................................... 5-38
Fog Lamps
.................................................... 3-16
Following Distance
.......................................... 4-40
Footnotes
........................................................ 6-5
Front Reading Lamps
...................................... 3-20
Front Storage Area
......................................... 2-45
Fuel
....................................................... 3-46, 5-5
Additives
...................................................... 5-6
California Fuel
.............................................. 5-6
Filling a Portable Fuel Container
.................... 5-1 1
Filling Your Tank ........................................... 5-7
FM
............................................................... 3-74 Fuel
(cont.)
Fuels in Foreign Countries
.............................. 5-7
Gage
......................................................... 3-44
Gasoline Octane
........................................... 5-5
Gasoline Specifications .................................. 5-5
System Inspection
....................................... 6-13
Fuel Economy
................................................ 3-47
Fuses Fuses and Circuit Breakers
........................... 5-92
Windshield Wiper
......................................... 5-91
G
Gage ........................................................ 3-49
Engine Coolant Temperature
......................... 3-38
Fuel
.......................................................... 3-44
Speedometer
.............................................. 3-32
Tachometer
................................................. 3-33
Garage
Door Opener ....................................... 2-41
Gasoline Octane
........................................................ 5-5
Gate Operator and Canadian Programming ........ 2-43
Glass Surfaces
............................................... 5-84
Glove Box
..................................................... 2-45
GM Mobility Program for Persons with
Disabilities
.................................................... 7-5
Specifications
............................................... 5-5
6
ProCarManuals.com

H
Hazard Warning Flashers ................................... 3-4
Head Restraints
....................................... . 1-7
Headlamp
Aiming
....................................................... 5-50
Headlamp High/Low-Beam Changer .................... 3-7
Headlamp Horizontal Aiming
............................. 5-51
Headlamp Vertical Aiming
................................. 5-52
Headlamp Wiring ............................................ 5-91
Headlamps
.................................................... 5-55
Bulb Replacement
....................................... 5-54
Front Turn Signal and Parking Lamps
............. 5-57
Halogen Bulbs
............................................ 5-54
Headlamps on Reminder
.................................. 3-15
Heated Seats
............................................... 1-5
Highway Hypnosis ................................. ... 4-24
Hill and Mountain Roads
................ ... 4-24
Hitches
.......................................................... 4-39
HomeLink Transmitter, Programming
.................. 2-42
HomeLink@ Transmitter
.................................... 2-41
Hood
UI ICLRII ly I I Ill 1y3 VI IUGl 5- I L
Release ..................................................... 5-1 3
Horn
............................................................... 3-5
How to Add Coolant to the Coolant Surge Tank
.. 5-33
How to Add Fluid
............................................ 5-24
How to Check ........................................ 5-22, 5-61
OL--I..-- TI^: --.- I I--1- .. Am ................................
How to Check Power Steering Fluid ....... .... 5-37
How to Use This Manual
................................... ii
How to Wear Safety Belts Properly ............... 1-13
Hydroplaning
.............................................. 4-19
If
No Steam Is Coming From Your Engine .......... 5-30
If Steam Is Coming From Your Engine ............... 5-29
If the Light Is Flashing ..................................... 3-40
If the Light Is on Steady .................................. 3-41
If You Are Stuck in Sand, Mud, Ice or Snow ....... 4-32
If You Do Decide To Pull A Trailer
..................... 4-37
If You’re Caught in a Blizzard ........................... 4-29
Ignition Positions
............................................. 2-23
Ignition Transaxle Lock Check
.......................... 6-12
Inadvertent Power Battery Saver
....................... 3-20
Infants and Young Children, Restraints
............... 1-30
Inflation
-- Tire Pressure .................................. 5-60
Inspection
Brake System
.......................... ........ 6-14
Exhaust System
.......................................... 6-13
Fuel System
............................................... 6-13
Part C
- Periodic Maintenance ....................... 6-13
Steering, Suspension and Front Drive Axle
Boot and Seal
......................................... 6-13
Throttle System
........................................... 6-14
Engine
Cooling System
................. .... 6-14
7
ProCarManuals.com

Magnetic-Speed Variable Assist Steering ............ 4-1 0
Maintenance. Normal Replacement Parts .......... 5-1 01
Maintenance Schedule
At Each Fuel Fill
....................................... 6-9
At Least Once a Month
....... ............... 6-9
At Least Once a Year
..... .............. 6-10
At Least Twice a Year
.................................. 6-10
Brake System Inspection
.............................. 6-14
Exhaust System Inspection
........................... 6-1 3
How This Section is Organized ....................... 6-3
Introduction
.................................................. 6-2
Maintenance Requirements
............................. 6-2
Part
A - Scheduled Maintenance Services ......... 6-4
Part B
- Owner Checks and Services ............... 6-9
Part C
- Periodic Maintenance Inspections ...... 6-13
Part D
- Recommended Fluids and Lubricants . 6-15
Part E
- Maintenance Record ........................ 6-16
Scheduled Maintenance
................................. 6-5
Boot and Seal Inspection
.......................... 6-13
Throttle System Inspection
............................ 6-14
Engine
Cooling System Inspection
................. 6-14
Fuel System Inspection
................................ 6-13
cv---.- -. . .----- :-.- -.--I I- L n .. f. ._ A . . I - ateGI II IY, auq.~w IWWI I IU rl UI 11 UI IV~ nx~e
Using Your ................................................... 6-4 Maintenance Schedule
(cont.)
Your Vehicle and the Environment
............... 6-2
Maintenance When Trailer Towing
..................... 4-43
Making Turns
................................................. 4-41
Malfunction Indicator Light
................................ 3-39
Manual Lumbar Controls
.................................... 1-3
Manual Operation
........................................... 3-24
Manual Passenger Seat
.................................... 1-2
Matching Transmitter(s) to Your Vehicle
............... 2-8
Memory Mirrors
.............................................. 2-48
Memory Seat
................................................. 2-48
Memory Seats
................................................ 3-58
Message DIC Warnings and Messages
........................ 3-50
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and
US
. Virgin Islands) ....................... ..... 7-4
Mirror Operation
............................................. 2-35
Mirrors Automatic Dimming Rearview with Compass
.... 2-35
Memory
..................................................... 2-48
Outside Curb View Assist Mirror
.................... 2-37
Outside Heated Mirrors
................................ 2-38
Outside Power Mirrors
.............................. 2-37
A, ttcirla Pnnrrnv hl;rrnr WUL~IUU -ut IVUfi *Vfftt ut 1-30 n on .................................
9
ProCarManuals.com

Perimeter Lighting ............................... 3.19. 3-57
Personalization. Climate Controls ...................... 3-29
Personalization Features .................................... 2-7
Plan Ahead When Possible ................................ 7-7
Playing a Cassette Tape .................................. 3-65
Playing a Compact Disc .......................... 3-67, 3-71
Power
Playing the Radio
........................................... 3-60
Accessory Outlets ........................................ 3-21
Door Locks ................................................. 2-1 1
Electrical System ......................................... 5-91
Lumbar Controls ........................................... 1-4
Seat ............................................................ 1-2
Steering
Fluid ............................................. 5-37
Windows .................................................... 2-1 8
Power Steering ............................................... 4-10
Programmable Automatic Door Locks ................. 2-1 2
Programming the HomeLink@ Transmitter ........ 2-42
Radios ..........................................................
Care of Your Cassette Tape Player ................
Care of Your CD Player ...............................
Care of Your CDs ........................................
Navigation System .......................................
Personal Choice Radio Controls ....................
Radio with Cassette and CD .........................
Setting the Time ..........................................
Theft-Deterrent ............................................
Trunk-Mounted CD Changer ..........................
Understanding Reception ..............................
RainsenseTM II Wipers .....................................
RDS Messages ..............................................
Rear Reading Lamps ......................................
Rear Safety Belt Comfort Guides ......................
Rear Storage Area ..........................................
Rear Seat Passengers, Safety Belts ..................
3-59
3-74
3-76
3-75
3-69
3-73 3-60
3-59
3-73
3-70 3-74
.. 3-9
3-64
3-20
1-25
1-21
2-46
Rear Underseat Fuse Block .............................. 5-96
................................ n Rear Window Defogger 3-26 U Rearview Mirror, Automatic Dimming with
Questions and Answers About Safety Belts
......... 1-12 Compass .................................................... 2-35
11
ProCarManuals.com