2003 NISSAN PATHFINDER engine overheat

The engine cooling system is filled at the factory
with a high-quality, year-round, anti-freeze cool-
ant solution. The anti-freeze solution contains
rust and corrosion inhibitors, therefore additional
cooling system additives are not necessary.
CAUTION
When adding or replacing the coolant,
be sure to use only a genuine NISSAN
anti-freeze coolant or equivalent with
the proper mixture ratio of 50% anti-
freeze and 50% demineralized water/
distilled water. The use of other types of
coolant solutions may damage your en-
gine cooling system.Outside tempera-
ture down to
Anti-
freezeDeminer-
alized
water or
distilled
water °C °F
−35 −30 50% 50%
WARNING

Never remove the radiator cap when
the engine is hot. Serious burns
could be caused by high pressure
fluid escaping from the radiator. Wait
until the engine and radiator cool
down. See “If your vehicle overheats”
in the “6. In case of emergency” sec-
tion.

The radiator is equipped with a pres-
sure cap. To prevent engine damage,
use only a genuine NISSAN radiator
cap.
CHECKING ENGINE COOLANT
LEVELCheck the coolant level in the reservoir tank
when the engine is cold. If the coolant level is
below the MIN level, add coolant to the MAX
level. If the reservoir tank is empty, check the
coolant level in the radiatorwhen the engine is
cold.If there is insufficient coolant in the radia-
tor, fill the radiator with coolant up to the filler
opening and also add it to the reservoir tank up
to the MAX level.
If the engine cooling system frequently
requires coolant, have it checked by your
NISSAN dealer.
SDI0378
ENGINE COOLING SYSTEM
Maintenance and do-it-yourself
8-9


03.1.28/R50-D/V5


CHANGING ENGINE COOLANT
Major cooling system repairs should be per-
formed by your NISSAN dealer. The service
procedures can be found in the appropriate
NISSAN Service Manual.

Improper servicing can result in reduced
heater performance and engine overheating.
WARNING

To avoid the danger of being scalded,
never change the coolant when the
engine is hot.

Never remove the radiator cap when
the engine is hot. Serious burns
could be caused by high pressure
fluid escaping from the radiator.

Avoid direct skin contact with used
coolant. If skin contact is made, washthoroughly with soap or hand cleaner
as soon as possible.

Keep coolant out of reach of children
and pets.
SDI0485
SDI0486A
8-10
Maintenance and do-it-yourself


03.1.28/R50-D/V5


3. Open the air release plug(s) to drain the
coolant.
4. Flush the cooling system by running fresh
water through the radiator.

Waste coolant must be disposed of
properly.

Check your local regulations.
5. Close the radiator drain plugs and engine
block drain plugs securely.
6. See the “9. Technical and consumer informa-
tion” section for cooling system capacity.
Fill the radiator slowly with the proper mixtureof coolant and water. Fill the reservoir tank
slowly up to the MAX level. Then install the
radiator cap and close the air release plug(s).
7. Start the engine and warm it up until it
reaches normal operating temperature. Then
race the engine 2 or 3 times under no load.
Watch the coolant temperature gauge for
signs of overheating.
8. Stop the engine. After it completely cools
down, refill the radiator up to the filler open-
ing. Fill the reservoir tank up the MAX level.
9. Check the radiator drain plug and engine
block drain plugs for any sign of leakage.
SDI1110SDI1189
SDI0419
8-12
Maintenance and do-it-yourself


03.1.28/R50-D/V5


which are sold commercially. Many of these
additives intended for gum, varnish or deposit
removal may contain active solvents or similar
ingredients that can be harmful to the fuel sys-
tem and engine.Octane rating tipsIn most parts of North America, you should use
unleaded gasoline with an octane rating of at
least 91 AKI (Anti-Knock Index) number
(VQ35DE engine) or 87 AKI (Anti-knock Index)
number (VG33E engine). However, you may use
unleaded gasoline with an octane rating as low
as 85 AKI (Anti-Knock Index) number in these
high altitude areas [over 4,000 ft (1,219 m)]
such as: Colorado, Montana, New Mexico, Utah,
Wyoming, northeastern Nevada, southern Idaho,
western South Dakota, western Nebraska, and
that part of Texas which is directly south of New
Mexico.
Using unleaded gasoline with an octane
rating lower than stated above can cause
persistent, heavy spark knock. (Spark
knock is a metallic rapping noise.) If se-
vere, this can lead to engine damage. If you
detect a persistent heavy spark knock even
when using gasoline of the stated octane
rating, or if you hear steady spark knock
while holding a steady speed on level
roads, have your dealer correct the condi-tion. Failure to correct the condition is
misuse of the vehicle, for which NISSAN is
not responsible.
Incorrect ignition timing will result in knocking,
after-run or overheating. This in turn may cause
excessive fuel consumption or damage to the
engine. If any of the above symptoms are en-
countered, have your vehicle checked at a
NISSAN dealer or other competent service fa-
cility.
However, now and then you may notice
light spark knock for a short time while
accelerating or driving up hills. This is no
cause for concern, because you get the
greatest fuel benefit when there is light
spark knock for a short time.
Technical and consumer information
9-5


03.1.28/R50-D/V5


After the hitch is removed, seal the
bolt holes to prevent exhaust fumes,
water or dust from entering the pas-
senger compartment.

Regularly check all hitch mounting
bolts are securely mounted.

To reduce the possibility of addi-
tional damage if your vehicle is
struck from the rear, where practical,
remove the hitch and/or receiver
when not in use.

Never connect a trailer brake system
directly to the vehicle brake system.Tire pressures
When towing a trailer, inflate the vehicle tires
to the recommended cold tire pressure indi-
cated on the tire placard (affixed to the glove
box lid).

Trailer tire condition, size, load rating and
proper inflation pressure should be in accor-
dance with the trailer and tire manufacturers’
specifications.Safety chains
Always use a suitable chain between your ve-
hicle and the trailer. The chain should be
crossed and should be attached to the hitch, not
to the vehicle bumper or axle. Be sure to leave
enough slack in the chain to permit turning
corners.Trailer lightsTrailer lights should comply with Federal and/or
local regulations.
When wiring vehicle for towing connection,
connect stop and tail light pickup into the
vehicle electrical circuit at point between
the sensor and stop light switch or light
switch.Trailer brakesIf your trailer is equipped with a braking system,
make sure it conforms to Federal and/or local
regulations and that it is properly installed.
WARNING
Never connect a trailer brake system
directly to the vehicle brake system.Trailer towing tipsIn order to gain skill and an understanding of thevehicle’s behavior, you should practice turning,
stopping and backing up in an area which is free
from traffic. Steering stability and braking perfor-
mance will be somewhat different than under
normal driving conditions.

Always secure items in the trailer to prevent
load shift while driving.

Avoid abrupt starts, acceleration or stops.

Avoid sharp turns or lane changes.

Always drive your vehicle at a moderate
speed.

Always block the wheels on both vehicle and
trailer when parking. Parking on a slope is not
recommended; however, if you must do so,
and if your vehicle is equipped with automatic
transmission, first block the wheels and apply
the parking brake, and then move the trans-
mission selector lever into the P position. If
you move the selector lever to the P position
before blocking the wheels and applying the
parking brake, transmission damage could
occur.

When going down a hill, shift into a lower
gear and use the engine braking effect.
When ascending a long grade, downshift the
transmission to a lower gear and reduce
speed to reduce chances of engine overload-
ing and/or overheating.
9-20
Technical and consumer information


03.1.28/R50-D/V5


Cigarette lighter and ashtray .................................. 2-29
Circuit breaker, Fusible link .................................... 8-27
Cleaning exterior and interior .......................... 7-2, 7-3
Clock ............................................................................ 2-27
Clutch
Fluid........................................................................ 8-19
Cold weather driving ................................................ 5-37
Compact Disc (CD) changer operation .............. 4-26
Compact Disc (CD) player (See audio
system) ......................................................................... 4-19
Compact spare tire ................................................... 8-39
Compass display ......................................................... 2-7
Console box................................................................ 2-33
Controls
Heater and air conditioner controls.................. 4-2
Steering wheel audio controls ........................ 4-28
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant ................................. 8-10
Checking engine coolant level........................... 8-9
Corrosion protection ................................................... 7-4
Cover, Tonneau cover .............................................. 2-36
Cruise control............................................................. 5-18
Cup holders ................................................................ 2-31
D
Daytime running light system ................................. 2-23
Defogger switch, Glass hatch and outside mirror
defogger switch ......................................................... 2-20
Determining vehicle payload capacity.................. 9-15
Dimensions and weights ......................................... 9-11
Door open warning light .......................................... 2-11Drive belts ................................................................... 8-22
Drive positioner, Automatic..................................... 3-17
Driving
Cold weather driving ......................................... 5-37
Driving with automatic transmission ..... 5-7, 5-11
Driving with manual transmission .......... 5-8, 5-15
On-pavement and offroad driving ..................... 5-4
Precautions when starting and driving ............ 5-2
Safety precautions ................................................ 5-5
E
Economy, Fuel............................................................ 5-20
Electric sunroof .......................................................... 2-40
Emission control information label ........................ 9-14
Emission control system warranty......................... 9-22
Engine
Before starting the engine................................ 5-10
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant ................................. 8-10
Changing engine oil ........................................... 8-14
Changing engine oil filter ................................. 8-15
Checking engine coolant level........................... 8-9
Checking engine oil level ................................. 8-13
Coolant temperature gauge ............................... 2-4
Engine block heater ........................................... 5-39
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-9
Engine oil .............................................................. 8-13
Engine oil and oil filter recommendation......... 9-6
Engine oil viscosity ............................................... 9-6
Engine serial number ......................................... 9-13
Engine specifications ........................................... 9-9If your vehicle overheats ................................... 6-11
Starting the engine............................................. 5-10
Exhaust gas (Carbon monoxide).............................. 5-2
F
4WD shift switch operations ................................. 5-28
F.M.V.S.S. certification label................................... 9-13
Filter, Air cleaner housing filter .............................. 8-23
Flashers (See hazard warning flasher switch) ... 2-25
Flat tire............................................................................ 6-2
Floor mat cleaning ....................................................... 7-4
Fluid
Automatic transmission fluid (ATF) ................ 8-16
Brake and clutch fluid ....................................... 8-19
Brake fluid............................................................. 8-19
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-9
Engine oil .............................................................. 8-13
Power steering fluid ........................................... 8-18
Window washer fluid ......................................... 8-20
FM-AM radio with cassette player and Compact
Disc (CD) player........................................................ 4-16
FM-AM-SATELLITE radio with cassette player and
Compact Disc (CD) player/CD changer............. 4-23
Fog light switch ......................................................... 2-24
Four wheel drive (4WD) .............................. 5-21, 5-25
Front air bag system (See supplemental restraint
system) ......................................................................... 1-16
Front fog light switch ............................................... 2-24
Front manual seat adjustment .................................. 1-2
Front power seat adjustment .................................... 1-4


03.1.28/R50-D/V5

10-2

Vanity mirror light ................................................ 2-43
Warning/indicator lights and audible
reminders ..................................................... 2-9, 2-14
Loading information (See vehicle loading
information) ................................................................. 9-15
Lock
Door locks ............................................................... 3-2
Glass hatch lock ................................................. 3-11
Glove box lock..................................................... 2-32
Power door lock .................................................... 3-2
Low fuel warning light ............................................ 2-12
Low tire pressure warning light (if so
equipped) .................................................................... 2-12
Low tire pressure warning system (if so
equipped).............................................................. 5-3, 6-2
Luggage hooks .......................................................... 2-34
Luggage rack ............................................................. 2-37
M
Maintenance
Battery ................................................................... 8-21
General maintenance ........................................... 8-2
Inside the vehicle................................................... 8-3
Maintenance precautions .................................... 8-5
Outside the vehicle............................................... 8-2
Seat belt maintenance ...................................... 1-32
Under the hood and vehicle ............................... 8-4
Manual front seat adjustment ................................... 1-2
Meters and gauges ..................................................... 2-3
Mirror
Inside mirror ......................................................... 3-16
Outside mirror control ....................................... 3-16
Outside mirrors ................................................... 3-16N
Net, Cargo net ........................................................... 2-36
New vehicle break-in ................................................ 5-20
Nissan vehicle Immobilizer System....................... 2-16
Nissan Vehicle Immobilizer System, Engine
start.................................................................................. 5-9
O
Odometer ....................................................................... 2-3
Oil
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine oil ........................................... 8-14
Changing engine oil filter ................................. 8-15
Checking engine oil level ................................. 8-13
Engine oil .............................................................. 8-13
Engine oil viscosity ............................................... 9-6
Outside mirror control .............................................. 3-16
Outside mirrors .......................................................... 3-16
Outside temperature display..................................... 2-6
Overdrive switch........................................................ 5-14
Overheat, If your vehicle overheats ...................... 6-11
P
Parking
Brake check ......................................................... 8-25
Parking brake check .......................................... 5-17
Parking brake operation .................................... 5-17
Parking on hills .................................................... 5-17
Parking/parking on hills ........................................... 5-32Payload weight capacity.......................................... 9-17
Personal lights............................................................ 2-43
Phone, Car phone or CB radio ............................. 4-31
Power
Front seat adjustment .......................................... 1-4
Power door lock .................................................... 3-2
Power outlet ......................................................... 2-28
Power steering fluid ........................................... 8-18
Power steering system ...................................... 5-33
Power windows................................................... 2-38
Pre-tensioner seat belt system .............................. 1-20
Precautions
Audio operation precautions............................ 4-14
Braking precautions ........................................... 5-34
Cruise control operations ................................. 5-19
Cruise control precautions ............................... 5-18
Driving safety .......................................................... 5-5
Maintenance precautions .................................... 8-5
On child restraints .............................................. 1-32
On seat belt usage ............................................ 1-24
On-pavement and offroad driving
precautions ............................................................. 5-4
Precautions on supplemental restraint
system.................................................................... 1-10
Precautions when starting and driving ............ 5-2
Push starting .............................................................. 6-11
R
Rack, Luggage rack.................................................. 2-37
Radio
Car phone or CB radio ..................................... 4-31
Steering wheel audio controls ........................ 4-28


03.1.28/R50-D/V5

10-4