2003 NISSAN 350Z engine

Due to legal requirements in some states/
areas, your vehicle may be required to be in what
is called the ªready conditionº for an
Inspection/Maintenance (I/M) test of the emis-
sion control system.
The vehicle is set to the ªready conditionº when
it is driven through certain driving patterns.
Usually, the ªready conditionº can be obtained
by ordinary usage of the vehicle.
If a powertrain system component is repaired or
the battery is disconnected, the vehicle may be
reset to a not ªready conditionº. Before taking
the I/M test, drive the vehicle through the follow-
ing pattern to set the vehicle to the ready
condition. If you cannot or do not want to
perform the driving pattern, a NISSAN dealer
can conduct it for you.
WARNING
Always drive the vehicle in a safe and
prudent manner according to traffic
conditions, and obey all traffic laws.
1. Start the engine. Allow the engine to idle until
the engine coolant temperature gauge needle
points between the C and H (normal operat-
ing temperature).2. Accelerate the vehicle to 55 MPH (88 km/h),
then quickly release the accelerator pedal
completely and keep it released for at least 6
seconds.
3. Quickly depress the accelerator pedal for a
moment, then drive the vehicle at a speed of
53 to 60 MPH (86 to 96 km/h) for at least 5
minutes.
4. Stop the vehicle. Leave the engine running.
5. Accelerate the vehicle to 35 MPH (55 km/h)
and maintain the speed for 20 seconds.
6. Repeat steps 4 and 5 at least 3 times.
7. Accelerate the vehicle to 55 MPH (88 km/h)
and maintain the speed for at least 3 minutes.
8. Stop the vehicle. Place the automatic trans-
mission gear selector lever in the P (Park) or
N (Neutral) position or the manual transmis-
sion shift lever in the N position.
9. Turn the engine off.
10.Repeat steps 1 through 8 at least one more
time.
If step 1 through 7 is interrupted, repeat the
preceding step. Any safe driving mode is ac-
ceptable between steps. Do not stop the engine
until step 7 is completed.READINESS FOR INSPECTION/
MAINTENANCE (I/M) TEST (US
only)
Technical and consumer information
9-21
Z
02.9.13/Z33-D/V5.0
X

10 Index
A
ABS (Anti-lock brake system)................................ 5-20
Air bag ON/OFF switch .......................................... 1-21
Air bag system
Front (See supplemental front air bag
system) .................................................................. 1-11
Side and curtain (See supplemental side air bag
and curtain side-impact air bag system) ...... 1-13
Air bag warning labels ............................................. 1-16
Air bag warning light .................................... 1-16, 2-14
Air cleaner housing filter.......................................... 8-18
Air conditioner
Air conditioner operation ..................................... 4-3
Air conditioner service ................................ 4-3, 4-6
Air conditioner specification label .................. 9-12
Air conditioning system refrigerant and lubricant
recommendations ......................................... 4-6, 9-6
Heater and air conditioner (automatic)............ 4-3
Alcohol, drugs and driving......................................... 5-5
Anchor point location, Top tether strap ............. 1-27
Anti-lock Brake System (ABS) .............................. 5-20
Anti-lock brake warning light.................................. 2-11
Appearance care
Exterior appearance care .................................... 7-2
Interior appearance care ..................................... 7-4
Ashtrays (See cigarette lighter and ashtray)...... 2-28
Audible reminders ..................................................... 2-16
Audio operation precautions ..................................... 4-7Audio system ................................................................ 4-6
Autochanger
Compact Disc (CD) ........................................... 4-17
Automatic
Anti-glare inside mirror ...................................... 3-13
Automatic transmission fluid (ATF) ................ 8-12
Driving with automatic transmission........ 5-5, 5-9
Transmission selector lever lock release ...... 5-12
Avoiding collision and rollover .................................. 5-4
B
Battery .......................................................................... 8-15
Battery saver system ......................................... 2-22
Battery replacement, (See remote keyless entry
system) ........................................................................... 3-7
Before starting the engine ......................................... 5-8
Belts (See drive belts) ............................................. 8-17
Brake
Anti-lock brake system (ABS) ......................... 5-20
Brake and clutch fluid ....................................... 8-13
Brake booster ...................................................... 8-22
Brake fluid............................................................. 8-13
Brake pedal .......................................................... 8-21
Brake pedal check ............................................. 8-21
Brake system ....................................................... 5-20
Parking brake check............................... 5-14, 8-21
Parking brake operation .................................... 5-14
Warning light ....................................................... 2-12Break-in schedule ..................................................... 5-17
Bulb check/instrument panel.................................. 2-11
Bulb replacement ...................................................... 8-25
C
Capacities and recommended fuel/lubricants...... 9-2
Car phone or CB radio............................................ 4-19
Cassette player (See audio system) .................... 4-16
Catalytic converter, Three way catalyst ................. 5-3
CD care and cleaning .............................................. 4-19
Child restraints ........................................................... 1-25
Top tether strap anchor point location ......... 1-27
Installation on front passenger seat............... 1-28
Precautions on child restraints........................ 1-25
With top tether strap ......................................... 1-27
Child safety ................................................................. 1-20
Chimes, Audible reminders..................................... 2-16
Cigarette lighter and ashtray .................................. 2-28
Circuit breaker, Fusible link .................................... 8-23
Cleaning exterior and interior .......................... 7-2, 7-4
Clock ............................................................................ 2-27
Clutch fluid.................................................................. 8-14
Cold weather driving ................................................ 5-24
Compact Disc (CD) changer operation .............. 4-17
Compact Disc (CD) player (See audio
system) ......................................................................... 4-11
Compact spare tire ................................................... 8-33
Console box................................................................ 2-31
Z
02.9.13/Z33-D/V5.0
X

Controls, Heater and air conditioner controls
(automatic) ..................................................................... 4-3
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Checking engine coolant level........................... 8-8
Corrosion protection ................................................... 7-5
Cruise control............................................................. 5-15
Cup holders ................................................................ 2-30
Curtain side-impact air bag system (See
supplemental side air bag and curtain side-impact
air bag system) .......................................................... 1-13
D
Daytime running light system ................................. 2-23
Defroster switch, Rear window and outside mirror
defroster switch ......................................................... 2-21
Dimensions and weights ............................................ 9-9
Door open warning light .......................................... 2-12
Drive belts ................................................................... 8-17
Driving
Cold weather driving ......................................... 5-24
Driving with automatic transmission........ 5-5, 5-9
Driving with manual transmission .......... 5-6, 5-12
Precautions when starting and driving ............ 5-2
E
Economy, Fuel............................................................ 5-17
Emission control information label ........................ 9-11
Emission control system warranty......................... 9-20Engine
Before starting the engine .................................. 5-8
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Changing engine oil and filter ......................... 8-10
Checking engine coolant level........................... 8-8
Checking engine oil level ................................. 8-10
Coolant temperature gauge ............................... 2-5
Engine block heater ........................................... 5-25
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-8
Engine oil .............................................................. 8-10
Engine oil and oil filter recommendation......... 9-5
Engine oil viscosity ............................................... 9-5
Engine serial number ......................................... 9-11
Engine specifications ........................................... 9-8
If your vehicle overheats ...................................... 6-9
Starting the engine ............................................... 5-8
Exhaust gas (Carbon monoxide).............................. 5-2
F
F.M.V.S.S. certification label................................... 9-11
Filter, Air cleaner housing filter .............................. 8-18
Flashers (See hazard warning flasher switch) ... 2-24
Flat tire............................................................................ 6-2
Low tire pressure warning system .................... 5-3
Floor mat cleaning ....................................................... 7-4
Fluid
Automatic transmission fluid (ATF) ................ 8-12
Brake and clutch fluid ....................................... 8-13
Brake fluid............................................................. 8-13Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-8
Engine oil .............................................................. 8-10
Power steering fluid ........................................... 8-13
Window washer fluid ......................................... 8-14
FM-AM radio with cassette player and Compact
Disc (CD) changer.................................................... 4-13
Front air bag system (See supplemental restraint
system) ......................................................................... 1-11
Front manual seat adjustment .................................. 1-3
Front power seat adjustment .................................... 1-4
Fuel
Capacities and recommended fuel/
lubricants ................................................................. 9-2
filler cap................................................................. 3-10
filler lid ................................................................... 3-10
Fuel economy ...................................................... 5-17
Fuel octane rating ................................................. 9-3
Fuel recommendation ........................................... 9-3
Gauge ...................................................................... 2-6
Fuses ............................................................................ 8-22
Fusible links ................................................................ 8-23
G
Garage door opener, HomeLink
Universal
Transceiver .................................................................. 2-36
Gas cap ....................................................................... 3-10
Gauge ............................................................................. 2-3
Engine coolant temperature gauge .................. 2-5
Fuel gauge .............................................................. 2-6
Odometer ................................................................ 2-4
Speedometer .......................................................... 2-4
Z
02.9.13/Z33-D/V5.0
X
10-2

Tachometer ............................................................. 2-5
Trip computer ......................................................... 2-8
General maintenance .................................................. 8-2
H
Hatch, Rear hatch........................................................ 3-9
Hazard warning flasher switch............................... 2-24
Head restraints ............................................................. 1-5
Headlights
Bulb replacement ............................................... 8-26
Headlight switch ................................................. 2-22
Xenon headlights ................................................ 2-21
Heated seats .............................................................. 2-25
Heater
Engine coolant heater ....................................... 5-25
Heater and air conditioner (automatic)............ 4-3
HomeLink
Universal Transceiver ......................... 2-36
Hood, release ............................................................... 3-8
Horn .............................................................................. 2-24
How to stop alarm, Vehicle security .................... 2-17
I
Ignition switch ............................................................... 5-5
Automatic transmission models................ 5-5, 5-9
Key positions .......................................................... 5-7
Manual transmission models .................. 5-6, 5-12
Immobilizer system .................................................... 2-18
Indicator lights............................................................ 2-14
Inside
Automatic anti-glare mirror............................... 3-13
Mirror...................................................................... 3-13Inspection/maintenance (I/M) test ........................ 9-21
Instrument panel........................................................... 2-2
Instrument pocket...................................................... 2-29
Interior light ................................................................. 2-35
Interior light replacement......................................... 8-27
J
Jump starting................................................................. 6-6
K
Keyless entry (See remote keyless entry
system) ........................................................................... 3-4
Keys................................................................................. 3-2
L
Label, Air conditioner specification label ............ 9-12
Label, Emission control information label............ 9-11
Label, F.M.V.S.S. certification label ...................... 9-11
Labels
Air bag warning labels ...................................... 1-16
Engine serial number ......................................... 9-11
Vehicle identification number (VIN)................ 9-10
License plate, Installing front license plate......... 9-13
Light
Air bag warning light ......................................... 1-16
Bulb replacement ............................................... 8-25
Headlight switch ................................................. 2-22
Headlights, Bulb replacement ......................... 8-26
Interior light .......................................................... 2-35
Luggage compartment light ............................. 2-36Replacement ........................................................ 8-25
Vanity mirror light ................................................ 2-36
Warning/indicator lights and audible
reminders .................................................. 2-11, 2-14
Xenon headlights ................................................ 2-21
Lights, Exterior and interior light replacement ... 8-27
Loading information (See vehicle loading
information) ................................................................. 9-14
Lock
Door locks ............................................................... 3-2
Power door lock .................................................... 3-2
Rear hatch lock...................................................... 3-9
Low tire pressure warning light ............................. 2-13
Low tire pressure warning system .......................... 5-3
Luggage compartment light.................................... 2-36
M
Maintenance
Battery ................................................................... 8-15
General maintenance ........................................... 8-2
Inside the vehicle................................................... 8-3
Maintenance precautions .................................... 8-5
Outside the vehicle............................................... 8-2
Seat belt maintenance ...................................... 1-24
Under the hood and the vehicle........................ 8-4
Manual front seat adjustment ................................... 1-3
Meters and gauges ..................................................... 2-3
Mirror
Automatic anti-glare inside mirror .................. 3-13
Inside mirror ......................................................... 3-13
Outside mirror control ....................................... 3-14
Outside mirrors ................................................... 3-14
Z
02.9.13/Z33-D/V5.0
X
10-3

N
New vehicle break-in ................................................ 5-17
Nissan vehicle Immobilizer System....................... 2-16
Nissan Vehicle Immobilizer System, Engine
start.................................................................................. 5-7
O
Obtaining an air bag ON/OFF switch ................. 1-21
Odometer ....................................................................... 2-4
Oil
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine oil and filter ......................... 8-10
Checking engine oil level ................................. 8-10
Engine oil .............................................................. 8-10
Engine oil viscosity ............................................... 9-5
Outside mirror control .............................................. 3-14
Outside mirrors .......................................................... 3-14
Overheat, If your vehicle overheats ......................... 6-9
P
Parking
Brake check ......................................................... 8-21
Parking brake check .......................................... 5-14
Parking brake operation .................................... 5-14
Parking on hills .................................................... 5-14
Parking/parking on hills ........................................... 5-18
Phone, Car phone or CB radio ............................. 4-19Power
Power door lock .................................................... 3-2
Power outlet ......................................................... 2-27
Power steering fluid ........................................... 8-13
Power steering system ...................................... 5-19
Power windows................................................... 2-33
Power front seat adjustment .............................. 1-4
Precautions
Audio operation precautions .............................. 4-7
Braking precautions ........................................... 5-20
Cruise control precautions ............................... 5-15
Maintenance precautions .................................... 8-5
On child restraints .............................................. 1-25
On seat belt usage ............................................ 1-18
Precautions on supplemental restraint
system ...................................................................... 1-6
Precautions when starting and driving ............ 5-2
Pre-tensioner seat belt system .............................. 1-15
Push starting ................................................................. 6-8
R
Radio, Car phone or CB radio .............................. 4-19
Readiness for inspection/maintenance (I/M) test (US
only) .............................................................................. 9-21
Rear floor box ............................................................. 2-32
Rear hatch .................................................................... 3-9
Rear hatch opener ....................................................... 3-9
Rear parcel box ......................................................... 2-32
Rear power point....................................................... 2-27
Rear window and outside mirror defroster
switch ........................................................................... 2-21
Rear window wiper and washer switch .............. 2-20
Registering your vehicle in another country ....... 9-10Remote keyless entry system ................................... 3-4
Reporting safety defects (US only) ...................... 9-20
Rollover........................................................................... 5-4
S
Safety
Child seat belts ................................................... 1-20
Reporting safety defects (US only)................ 9-20
Towing safety....................................................... 9-17
Seat
Belt warning light................................................ 1-18
Belt warning light and chime ........................... 2-14
Seat adjustment
Front manual seat adjustment............................ 1-3
Front power seat adjustment ............................. 1-4
Seat belt(s)
Child safety .......................................................... 1-20
Infants and small children ................................. 1-21
Injured persons.................................................... 1-22
Larger children .................................................... 1-21
Precautions on seat belt usage ...................... 1-18
Pregnant women ................................................. 1-21
Pre-tensioner seat belt system ....................... 1-15
Seat belt cleaning ................................................. 7-5
Seat belt extenders ............................................ 1-24
Seat belt maintenance ...................................... 1-24
Seat belts ............................................................. 1-18
Three-point type.................................................. 1-22
Seat(s)
Heated seats........................................................ 2-25
Seats ........................................................................ 1-2
Secondary rear hatch release ................................ 3-10
Security system, vehicle security system ............ 2-17
Z
02.9.13/Z33-D/V5.0
X
10-4

Security systems (Nissan Vehicle Immobilizer
System), Engine start ............................................... 2-18
Security systems (See vehicle security
system) ......................................................................... 2-16
Servicing air conditioner ................................... 4-3, 4-6
Shift lock release ....................................................... 5-12
Shifting
Automatic transmission .............................. 5-5, 5-9
Manual transmission ................................. 5-6, 5-12
Side air bag system (See supplemental side air bag
and curtain side-impact air bag system)............. 1-13
Spark plugs................................................................. 8-17
Speedometer ................................................................ 2-4
Starting
Before starting the engine .................................. 5-8
Jump starting .......................................................... 6-6
Precautions when starting and driving ............ 5-2
Push starting .......................................................... 6-8
Starting the engine ............................................... 5-8
Steering
Power steering fluid ........................................... 8-13
Power steering system ...................................... 5-19
Tilting steering wheel......................................... 3-12
Storage ........................................................................ 2-29
Sunglasses holder .................................................... 2-29
Supplemental air bag warning labels................... 1-16
Supplemental air bag warning light .......... 1-16, 2-14
Supplemental front air bag system....................... 1-11
Supplemental side and curtain side-impact air bag
system ......................................................................... 1-13
Supplemental restraint system ................................. 1-6
Precautions on supplemental restraint
system ...................................................................... 1-6Switch
Hazard warning flasher switch ........................ 2-24
Headlight switch ................................................. 2-22
Ignition switch ........................................................ 5-5
Ignition switch automatic transmission
models ............................................................ 5-5, 5-9
Ignition switch manual transmission
models .......................................................... 5-6, 5-12
Obtaining an air bag ON/OFF switch........... 1-21
Power door lock switch....................................... 3-4
Rear window and outside mirror defroster
switch..................................................................... 2-21
Turn signal switch .............................................. 2-23
T
Tachometer.................................................................... 2-5
Temperature gauge, Engine coolant temperature
gauge .............................................................................. 2-5
Theft (Nissan Vehicle Immobilizer System), Engine
start ............................................................................... 2-18
Three way catalyst ....................................................... 5-3
Tilting and reclining passenger's seat .................. 1-5
Tilting steering wheel ............................................... 3-12
Tire
Flat tire ..................................................................... 6-2
Low tire pressure warning system .................... 5-3
Uniform tire quality grading .............................. 9-19
Tire pressure, Low tire pressure warning
light ............................................................................... 2-13
Tires
Spare tire .............................................................. 8-33
Tire chains ............................................................ 8-31
Tire placard .......................................................... 9-12Tire pressure ........................................................ 8-29
Tire rotation .......................................................... 8-31
Types of tires ....................................................... 8-30
Wheel/tire size ....................................................... 9-9
Wheels and tires ................................................ 8-29
Top tether strap child restraints ............................ 1-27
Towing
Tow truck towing ................................................ 6-10
Towing a trailer.................................................... 9-15
Towing load/specification chart ...................... 9-15
Towing safety....................................................... 9-17
Traction control system (TCS)............................... 5-22
Traction control system (TCS) off switch ........... 2-26
Trailer towing .............................................................. 9-15
Transceiver, HomeLink
Universal
Transceiver .................................................................. 2-36
Transmission
Automatic transmission fluid (ATF) ................ 8-12
Driving with automatic transmission........ 5-5, 5-9
Driving with manual transmission .......... 5-6, 5-12
Transmission selector lever lock release ...... 5-12
Transmitter (See remote keyless entry system) ... 3-4
Traveling or registering your vehicle in another
country ......................................................................... 9-10
Trip computer ............................................................... 2-8
Turn signal switch ..................................................... 2-23
U
Underbody cleaning .................................................... 7-3
Uniform tire quality grading .................................... 9-19
Z
02.9.13/Z33-D/V5.0
X
10-5

FUEL RECOMMENDATION:Use unleaded premium gasoline with an octane
rating of at least 91 AKI (Anti-Knock Index)
number (Research octane number 96).
If premium gasoline is not available, unleaded
regular gasoline with an octane rating of 87 AKI
number (Research octane number 91) may be
temporarily used, but only under the following
precautions:
IHave the fuel tank filled only partially with
unleaded regular gasoline, and fill up with
unleaded premium gasoline as soon as pos-
sible.
IAvoid full throttle driving and abrupt accelera-
tion.
However, for maximum vehicle perfor-
mance, the use of unleaded premium gaso-
line is recommended.
CAUTION
Using a fuel other than that specified
could adversely affect the emission con-
trol systems, and may also affect war-
ranty coverage.
Under no circumstances should aleaded gasoline be used, since this will
damage the three way catalyst.
For additional information, see ªCapacities and
recommended fuel/lubricantsº in the ª9. Techni-
cal and consumer informationº section.
ENGINE OIL RECOMMENDATION:IAPI Certification Mark
IAPI grade SG/SH, Energy ConservingI&II
or API grade SJ or SL, Energy Conserving
IILSAC grade GF-I, GF-II & GF-III
ISAE 5W-30 viscosity oil is preferred for all
ambient temperatures. SAE 10W-30 viscos-
ity oil may be used for ambient temperatures
above 0ÉF (þ18ÉC).
See ªCapacities and recommended fuel/
lubricantsº in the ª9. Technical and consumer
informationº section for engine oil and oil filter
recommendation.COLD TIRE PRESSURES:See tire placard affixed to the inside of the
console box lid.
NEW VEHICLE BREAK-IN
PROCEDURES
RECOMMENDATION:During the first 1,200 miles (2,000 km) of ve-
hicle use, follow the recommendations outlined
in the ªBreak-in scheduleº Information found in
the ª5. Starting and drivingº section of this
Owner's Manual. Follow these recommenda-
tions for the future reliability and economy of
your new vehicle.
GAS STATION INFORMATION
Z
02.9.13/Z33-D/V5.0
X

QUICK REFERENCE1. Engine oil (P.8-10)
2. Brake fluid (P.8-13)
3. Meters and gauges (P.2-3)
4. Fuel filler lid release (P.3-10)
5. Hood release (P.3-8)
6. Seat belt (P.1-18)
7. Door lock/key (P.3-2)
8. Rear hatch release (P.3-9)
9. Engine coolant (P.8-8)
10. Windshield washer fluid (P.8-14)
11. Power steering fluid (P.8-12)
12. Battery (P.8-15)
13. Audio system (P.4-6)/
Heater and air conditioner (P.4-3)
14. Fuel (P.3-10, P.9-2)
15. Spare tire (P.6-3, P.8-33)
STI0327Z
02.9.13/Z33-D/V5.0
X