2003 MERCEDES-BENZ S CLASS spare wheel

324 Practical hintsWhere will I find ...?
Removing the spare wheel
Take out the vehicle tool kit tray2.

Loosen the luggage bowl3. To do so,
turn the luggage bowl counterclock-
wise

Remove the spare wheel4.
Storing the spare wheel

Place spare wheel4 in wheel well.

Secure the spare wheel. To do so, turn
the luggage bowl3 clockwise to its
stop.

Place vehicle tool kit tray2 in luggage
bowl.Spare wheel S 430, S 500 and S 600
(except Sport Package*)
The spare wheel rim is mounted with a full
sized tire of the same type as on the vehi-
cle, and it is fully functional.
However, that spare wheel rim is weight
optimized and has a limited service life of
12 000 miles (20 000 km) use before a
standard wheel rim must replace it.
In case of flat tire, you may temporarily use
the spare wheel.
Do not operate vehicle with more than one
spare wheel mounted.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure that the jack
arm is fully seated in the jack take-up brack-
et. Always lower the vehicle onto sufficient
capacity jackstands before working under
the vehicle.

325 Practical hints
Where will I find ...?
More information can be found in the
“Technical data” section (
page 357).Spare wheel S 55 AMG and Sport
Package*
In case of a flat tire, you may temporarily
use the spare wheel when observing the
following restrictions:


Do not exceed a vehicle speed of
50 mph (80 km/h).


Drive to the nearest tire repair facility
to have the flat tire repaired or re-
placed as appropriate.


Do not operate vehicle with more than
one spare wheel mounted.
More information can be found in the
“Technical data” section (
page 357).
Warning!
G
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel rim is for temporary use
only. Use for over a total of 12 000 miles
(20 000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.
Warning!
G
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire pressure and do not exceed
vehicle speed of 50 mph (80 km).
The spare wheel rim is for temporary use
only. Use for over a total of 12 000 miles
(20 000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.

339 Practical hints
Flat tire
Flat tire
Preparing the vehicle
Park the vehicle as far as possible from
moving traffic on a hard surface.

Turn on the hazard warning flashers.

Engage the steering wheel lock in the
straight-ahead position and set the
parking brake.

Move the selector lever toP.

Have any passenger exit the vehicle at
a safe distance from the roadway.
Mounting the spare wheel Preparing the vehicle

Take vehicle tool kit tray and vehicle
jack out of trunk .

Take the spare wheel out of wheel well
(page 322).
Lifting the vehicle

Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
(not included) or other sizable objects.
When changing wheel on a level surface:

Place one chock in front of and one be-
hind the wheel that is diagonally oppo-
site to the wheel being changed.
When changing wheel on a hill:

Place chocks behind the downhill sides
of both wheels of the axle not being
worked on.
Warning!
G
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel rim is for temporary use
only. Use for over a total of 12000 miles
(20000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.
S 55 AMG and Sport Package* only:
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire pressure and do not exceed
vehicle speed of 50 mph (80 km/h).
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.


342 Practical hintsFlat tireMounting the new wheel
Clean contact surfaces of wheel and
wheel hub.

Guide the spare wheel onto the align-
ment bolt and push it on.

Insert wheel bolts and tighten them
slightly.

Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
Lowering the vehicle

Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.1-5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of
110 ft. lb. (150 Nm).
!To avoid paint damage, place wheel flat
against hub and hold it there while in-
stalling first wheel bolt.Warning!
G
Always replace wheel bolts that are dam-
aged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be re-
paired immediately. Do not continue to drive
under these circumstances! Contact an au-
thorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect mounting bolts or improperly
tightened mounting bolts can cause the
wheel to come off. This could cause an acci-
dent. Be sure to use the correct mounting
bolts.
Warning!
G
Use only genuine equipment
Mercedes-Benz wheel bolts. They are identi-
fied by the Mercedes star. Other wheel bolts
may come loose.
Do not tighten the wheel bolts when the ve-
hicle is raised. Otherwise the vehicle could
tip over.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
110 ft.lb. (150 Nm).


343 Practical hints
Flat tire

Before storing the jack in the trunk, it
should be fully collapsed, with handle
folded in.

Place the wheel bolt wrench, alignment
bolt and jack back in the vehicle tool kit
in the trunk and close the covering lid.
Replacing jack support tube cover

Slide tongue of cover under the upper
edge of the tube opening.

Applying even pressure, press cover
until it snaps into place. Be careful not
to damage the locking tabs or clamp
the plastic retaining strap.!You can also screw the faulty wheel
down into the spare wheel well in the
trunk.
Do not activate the tire inflation pres-
sure monitor until the depressurized
tire is no longer in the vehicle.


367 Technical data
Rims and tires
Spare wheel
S 430, S 430 4MATIC
S 500, S 500 4MATIC
(except Sport Package*)
S 430, S 430 4MATIC, S 500, S 500 4MATIC
(Sport Package*)
S 600, S 55 AMG
Rims (light alloy)
7½ J x 17 H2
8 J x 18 H2
Wheel offset
2.0 in. (51 mm)
1.73 in. (44 mm)
Summer tires (radial-ply tires)
-
245 / 45 R18 96Y
All-season tires (radial-ply tires)
225 / 55 R17 97H M+S AS
-

394 IndexEmergency call system* 237
Emergency calls
Initiating an emergency call 240
With Tele Aid* 238
Emergency engine shut-down 355
Emergency operation (Limp Home Mode)
165
Emergency operations
Closing sliding/pop-up roof 330
Locking the vehicle 327
Opening sliding/pop-up roof 330
Remote door unlock 244
Unlocking the trunk lid 327
Unlocking the vehicle 326
Emergency tensioning device see ETD 65,
382
Emission control 259
Ending
A call (telephone) 140
Engine 362
Compartment 263
Message in display 294
Starting 43
Starting with KEYLESS-GO* 43
Starting with the Smartkey 43
Turning off with the Smartkey 52Engine cleaning 284
Engine compartment 263
Fuse box in 354
Hood 263
Engine malfunction indicator lamp 294
Engine number 382
Engine oil 264
Adding 266, 267
Additives 373
Checking level 264
Consumption 264
Display messages 308
Filler neck 267
Messages in display 265, 309
Viscosity 382
Engine oil level see Oil level 262
Engine shut down in an emergency 355
Entry position
Messages in display 321
ESP 78, 382
Four wheel electronic traction system
with ESP 81
Switching off 80
Switching on 80
Warning lamp 290ETD 382
Safety guidelines 60
ETD (Emergency tensioning device) 65
Exterior lamp switch 120
Exterior rear view mirrors
Adjusting 39
Folding electrically 170
Parking position for 158
F
Fahrenheit
Setting temperature units 149
Fastening the seat belts 40
Fine adjustment
Cruise control 198
Distronic* 205
First aid kit 322
Flat tire 339
Lowering the vehicle 342
Mounting the spare wheel 339
Preparing the vehicle 339
Flexible Service System (FSS) 280, 383
Fog lamp, rear 123, 332
Fog lamps
Replacing bulbs 331

395 Index
Fog lamps, front
Messages in display 314
Replacing bulbs 332
Switching on 122
Folding electrically
Exterior rear view mirrors
170
Four wheel electronic traction system
(4MATIC)
with ESP 81
4MATIC 81
Front airbags 61
Front lamps
Messages in display 313–315
Replacing bulbs 331, 333
Switching on 120
Front seat head restraints
Installing 106
Power seat 105
Removing 105
FSS (Flexible Service System) 280, 383
Fuel 261
Fuel reserve warning lamp 294
Premium unleaded gasoline 261
Fuel consumption statistics
After start 143Since last reset 144
Fuel filler flap 261
Locking 261
Opening 329
Unlocking 261
Fuel reserve tank
Message in display 311
Fuel tank
Filler flap 261
Fuels, coolants, lubricants etc. 371
Functions (control system) 131, 134
Resetting 147
Fuse box 353, 354
Fuse chart 323
Fuses 353
Auxiliary fuse box in trunk 353
Fuse box in engine compartment 354
Fuse box in passenger compartment
353
Fuse boxes in the engine compartment
355
Fuse chart 323
Fuse extractor 323
Spare fuses 323G
Garage door opener 245
Erasing in remote control 247
Integrated remote control 246
Rolling code programming 246
Gasoline see Fuel 261
Gear range 383
Automatic transmission 162
Limiting 162
Shifting into optimal 161
Gear range limit
Canceling 161
Gear selector lever
Cleaning 287
Position 163
Global
Locking 87
Unlocking 87
Global Positioning System (GPS) 383
Glove box 224
Closing 224
Opening 224
Good visibility 168
GPS 383
GPS see COMAND* 243