2003 MERCEDES-BENZ ML350 automatic transmission fluid

206 OperationEngine compartmentTransmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Light
Truck Center check the automatic trans-
mission.Coolant
The engine coolant is a mixture of water
and anticorrosion/antifreeze. To check
the coolant level, the vehicle must be
parked on level ground and the engine
must be cool. 1Cap
2COLD LEVEL mark
The coolant level should reach the COLD
LEVEL mark2 in the reservoir.

Using a rag, turn the cap slowly approx-
imately one half turn to the left to re-
lease any excess pressure.
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if engine temperature is above
194°F (90°C). Allow engine to cool
down before removing cap. The coolant
reservoir contains hot fluid and is under
pressure.


Using a rag, slowly open the cap approx-
imately ½ turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.
iIf the engine is already at its regular op-
erating temperature, the coolant may
be approximately 0.6 in (1.5 cm) above
the COLD LEVEL mark.


284 Technical dataFuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.Capacities
Vehicle components and their respective
lubricants must match.Therefore use only brand tested and rec-
ommended by us.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Light Truck Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
ML 320, ML 350,
ML 500
8.5 US qt (8.0 l)
Recommended engine oils
ML 55 AMG
8.0 US qt (7.5 l)
Recommended engine oils
Automatic transmis-
sion
9.0 US qt (8.5 l)
MB Automatic Transmission Oil
1
1MB part no. 001 989 21 03 10Transfer case
1.6 US qt (1.5 l)
(Dexron 3 or Dexron 2E)
Rear axle
1.3 US qt (1.25 l)
(Hypoid gear oil SAE 90, 85 W 90)
Front axle
1.2 US qt (1.1 l)
(Hypoid gear oil SAE 90)
Power steering
approx. 0.65 US qt (0.6 l)
MB Power Steering Fluid
Front wheel hubs
approx. 1.5 oz (43 g) each
High temperature roller bearing grease
Brake system
0.75 US qt (0.7 l)
MB Brake Fluid (DOT 4+)

300 Index
Passenger 59
Safety guidelines 57
Side impact 59
Window curtain 59
Alarm
Audible 70, 79
Canceling 79
Visual 78
Alarm system
Anti-theft 78
Anticorrosion/antifreeze 288
Antiglare
Automatic 119
Antilock brake system (ABS) 293
Anti-theft alarm system
Arming 78
Canceling alarm 79
Disarming 79
Anti-theft systems
Anti-theft alarm system 78
Immobilizer 78
Tow-away alarm, glass breakage
sensor 79
Aquaplaning see Hydroplaning 183Armrest
Storage compartment in front of 153
Storage spaces 153
Armrest in rear seat bench 155
Ashtray
Front center console 156
Rear center console 157
At the gas station 200
ATF (automatic transmission fluid) 206
Attaching a trailer 194
Automatic antiglare for rear
view mirror 119
Automatic central locking
Activating 89
Deactivating 89
Automatic climate control 124
Adjusting air distribution 127
Adjusting air volume 127
Air conditioning 129
Air outlets 132
Air recirculation mode 128
Basic setting 127
Changing basic setting 127
Defrosting 128Economy mode 125
Rear passenger compartment 131
Rear window defroster 131
Residual heat utilization 130
Residual ventilation 130
Switching off 127
Switching on 126
Automatic headlamp mode 103
Automatic interior lighting control
Activating 107
Deactivating 107
Automatic locking when driving 89
Automatic transmission 113
Accelerator position 117
Emergency operation (Limp Home
Mode) 117
Gear ranges 114
Gear selector lever position 115
Gear shifting malfunctions 117
Kickdown 117
Manual shifting 113
One-touch gearshifting 113
Selector lever position 113
Towing a trailer 117
Transmission fluid 206

305 Index
Engine
Compartment 202
Starting 44
Technical data 278
Turning off 51
Engine cleaning 219
Engine compartment
Fuse box in 271
Hood 202
Engine malfunction indicator lamp 25, 232
Engine number 293
Engine oil 203, 286
Adding 204, 205
Additives 286
Checking level 203
Consumption 203
Filler neck 205
Viscosity 294
Engine oil level indicator 204
Engine oil level see Oil level 201
Enlarged cargo area 93
Error
Display messages 235
ESP 25, 75, 294
LOW RANGE mode 76
Malfunction indicator lamp 225, 226Switching off 76
Switching on 77
Warning lamp 224, 225, 226
ETD 294
Safety guidelines 57
ETD (Emergency Tensioning Device) 54
ETD (Emergency tensioning device) 62
Exterior mirrors
Folding 120
Exterior rear view mirrors 38
Adjusting 38
F
Fastening the seat belts 40
Fine adjustment
Cruise control 148
First aid kit 236
Flat tire 255
Inflating the spare tire 259
Lowering the vehicle 258
Mounting the spare wheel 255
Preparing the vehicle 255
Spare wheel 239
Flexible Service System (FSS) 215, 294
Flexible service system (FSS) 25
Fluid level
Automatic transmission 206Fog lamp, rear 248
Fog lamps 105
Replacing bulbs 247
Fog lamps, front
Replacing bulbs 248
Switching on 105
Folding
Exterior mirrors 120
4-ETS 25, 73
Indicator lamp 226
LOW RANGE mode 74
Malfunction indicator lamp 226
Warning lamp 224
Front airbags 59
Front fog lamps
Indicator lamp 229
Switching off 106
Front lamps
Replacing bulbs 247, 249
Switching on 102
Front towing eyes 269
FSS 25
FSS (Flexible Service System) 215, 294
Fuel 200
Additives 287
Fuel reserve warning lamp 233

309 Index
Light alloy wheels
Cleaning 221
Lighter
Rear center console 157
Lighter see cigarette lighter 156
Lighting 102
Automatic headlamp mode 103
Cargo compartment 109
Combination switch 102
Daytime running lamp mode 103
Door entry lamps 107
Front fog lamps 105
High beam flasher 102
High beams 102
Instrument cluster illumination 110
Interior 107
Locator lighting 105
Low beam 102
Night security illumination 104
Parking lamps 102
Limiting the gear range 114
Limp Home Mode 117
Line of fall 294
Loading 139
Cargo area cover blind* 143
Cargo floor plates 144Cargo tie-down rings 140
Hooks 140
Instructions 139, 140
Partition net* 141
Roof rack 145
Split rear bench seat 93
Trailer 193
Locator lighting 105
Lock button 294
Locking 84
Automatic while driving 89
Centrally from inside 90
Fuel filler flap 200
Global 85
Vehicle in an emergency 243
Locking knobs 32
Loss of keys 86
Loss of Service and Warranty Information
Booklet 275
Low beam headlamps
Replacing bulbs 247, 249
Switching on 46
Low engine oil level
Indicator lamp 229
LOW RANGE - 4-ETS 74
LOW RANGE - ABS 72LOW RANGE - ESP 76
LOW RANGE mode 118
Low washer system fluid level
Indicator lamp 234
Lowering
Vehicle 258
M
Main dimensions 282
Maintenance 12
Display messages 235
Manual operations
Fuel filler flap 244
Interior lighting control 108
Locking the vehicle 243
Sliding/pop-up roof 246
Unlocking the driver’s door 242
Unlocking transmission selector
lever 245
Manual seat
Adjusting 35
Adjusting backrest tilt 36
Adjusting head restraint height 36
Adjusting head restraint tilt 36
Seat fore and aft adjustment 35
Seat height 35

316 IndexSwitching off
Automatic climate control 127
ESP 76
Front fog lamps 106
Hazard warning flasher 106
Headlamps 51
Rapid seat heating 91
Rear fog lamp 106
Transmission control – LOW RANGE
mode 118
Switching on
Automatic climate control 126
ESP 77
Front fog lamps 105
Front fog lamps, rear fog lamp 105
Hazard warning flasher 106
Headlamps 46
High beams 102
Rapid seat heating 91
Seat heating 91
Transmission control – LOW RANGE
mode 118
Trip computer 172
Windshield wipers 47Synchronizing
Power windows 136
Remote control 244
Sliding/pop-up roof 138
T
Tachometer 26, 112
Displaying gear range 114
Tail lamps 251
Cleaning 220
Replacing bulbs 248
Tar stains 218
Technical data 286
Brake fluid 286
Coolants 287
Electrical system 281
Engine 278
Engine oil 286
Engine oil additives 286
Fuel requirements 287
Gasoline additives 287
Main dimensions 282
Premium unleaded gasoline 286
Rims and tires 279
Weights 283
Windshield and headlamp washer sys-
tem 290Tele Aid
Information 165
Initiating an emergency call manually
163
Roadside assistance 163
Tele Aid System 160
Tele Aid System* 296
Tele Aid* 159
Emergency calls 161
Remote door unlock 167
Stolen vehicle tracking services 168
System self-check 160
Upgrade signals 166
Telematics* 296
Telephone* 158
Temperature
Grades of tires 292
Tires 211
Third row seats* 96
Folding down single seat 96
Installing single seat 98
Removing single seat 98
Storing single seat 97
Tie-down rings (Cargo compartment) 140
Tightening torque 296
Tightening torque (Wheel bolts) 258