2003 MERCEDES-BENZ G55AMG fuel cap

316 Technical dataFuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.Capacities
Vehicle components and their respective
lubricants must match.Therefore use only brands tested and rec-
ommended by Mercedes-Benz.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Light Truck Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
G500
G55AMG
8.5 US qt (8.0 l)
8.0 US qt (7.5 l)
Recommended engine oils
Automatic transmission
9.0 US qt (8.5 l)
MB Automatic Transmission Fluid
1
1MB part no. 001 989 21 03 10Transfer case
2.96 US qt (2.8 l)
MB part no. A 001 989 28 03 10
Differential lock mechanism
0.47 - 0.63 US qt
(0.45 - 0.6 l)
Brake fluid DOT 3+4, SAE J1703
Front axle
1.5 US qt (1.4 l)
Hypoid gear oil SAE 90, 85 W 90
Rear axle
1.9 US qt (1.8 l)
Hypoid gear oil SAE 90, 85 W 90
Power steering
approx. 1.06 US qt (1.0 l)
MB Power Steering Fluid, or
approved Dextron III ATF
Front wheel hubs
approx. 1.5 oz (43 g) each
High temperature roller bearing grease
Brake system
approx. 0.53 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Fuel tank
including a reserve of
25.4 US gal (96.0 l)
5.3 US gal (20.0 l)
Premium unleaded gasoline:
Posted Octane 91
(average of 96 RON / 86 MON)

317 Technical data
Fuels, coolants, lubricants etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on recom-
mended brands is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Light
Truck Center.
Please follow FSS and Service Booklet rec-
ommendations for scheduled oil changes.
F ai lu re to d o s o could res ul t in engi ne da m -
age not covered by the Mercedes-Benz
Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.
Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air condition-
ing system.
Never use R-12 (CFC) or mineral-based lu-
bricating oil, otherwise damage to the
system will occur.
Model
Capacity
Fuels, coolants, lubricants etc.
Cooling system
approx. 12.7 US qt (12.0 l)
MB Anticorrosion/Antifreeze
Air conditioning system
R-134a refrigerant and
special PAG lubricant oil (never R-12)
Windshield/rear window washer system
and headlamp cleaning system
approx. 7.9 US qt (7.5 l)
MB Windshield Washer Concentrate
and water
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available pre-
mixed windshield washer solvent / antifreeze for temperatures below freezing. Follow suggested mixing ratios (
page 321).

319 Technical data
Fuels, coolants, lubricants etc.
Gasoline additives
A major concern among engine manufac-
turers is carbon build-up caused by gaso-
line. Mercedes-Benz recommends only the
use of quality gasoline containing additives
that prevent the build up of carbon depos-
its.
After an extended period of using fuels
without such additives, carbon deposits
can build up especially on the intake valves
and in the combustion area, leading to en-
gine performance problems such as:

Warm-up hesitation


Unstable idle


Knocking/pinging


Misfire


Power loss
Do not blend other specific fuel additives
with fuel. This only results in unnecessary
cost and may be harmful to the engine op-
eration.Damage or malfunctions resulting from
poor fuel quality or from blending specific
fuel additives are not covered by the
Mercedes-Benz Limited Warranty.
Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).The coolant solution must be used year
round to provide the necessary corrosion
protection and increase in the boil-over
protection. You should have it replaced
every 3 years.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]).
If you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.
If the coolant level is low, water and MB
anticorrosion /antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
Please make sure that the mixture is in ac-
cordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you

333 Index
Battery, vehicle 223, 295
Charging 295
Disconnecting 296
Messages in display 266
Reconnecting 296
Block heater 228
Blocking
Rear door window operation 69
Brake assist system (BAS) 325
Brake fluid 215, 318
Brake lamp bulbs, left and right 280
Brake lamp, high mounted 280
Brake pads
Message in display 250
Brakes 198
Warning lamp 241, 242
Break-in period 196
Brush guard* 277
Lowering 278
Bulbs, replacing
Additional turn signals 279
Backup lamp 287
Backup lamps 280
Brake lamps 280
Fog lamps 279
Front fog lamps 283Front lamps 279
Front turn signal lamps 284
High and low beam 279
High beam lamps 281
High mounted brake lamp 280
License plate lamps 280, 288
Low beam lamps 281
Parking lamps 279, 280, 281
Rear fog lamp 287
Side marker lamps 279, 285
Standing lamps 279, 280, 281
Tail lamp assemblies 280, 286
Turn signal lamp, side 284
Turn signal lamps 279, 280
C
CAC (Customer Assistance Center) 325
Calling up
Range (distance to empty) 131
Service indicator 231
CAN system 325
Capacities
Fuels, coolants, lubricants, etc. 316
Cargo area cover 168
Installing 169
Removing 169Cargo area see Cargo compartment 87, 88
Cargo compartment
Tailgate 87, 88
Tie-down rings 175
Cargo tie-down rings 175
Catalytic converter 211
CD player
Operating 117
Center console 27
AIRBAG OFF indicator lamp 244
Lower part 28
Upper part 27
Centigrade
Setting temperature units 122
Central locking
From inside 89
Switch 89
Switching on/off (control system) 128
Unlocking from inside 89
Central locking switch 89
Certification label 310
Changing
Batteries (SmartKey) 273
Key setting 128
Charging
Vehicle battery 295

338 IndexFuel 215
Additives 319
Fuel reserve warning lamp 243, 244
Gasoline additives 319
Premium unleaded gasoline 215, 316,
318
Requirements 318
Reserve warning 25
Technical data 316
Fuel additives 319
Fuel consumption statistics
After start 130
Since last reset 131
Fuel filler flap 214
Locking 214
Opening 274
Unlocking 214
Fuel requirements 318
Fuel reserve tank
Message in display 263
Fuel tank
Capacity 316
Filler flap 214
Fuels, coolants, lubricants etc.
Capacities 316Functions (control system) 112, 115
Resetting 120
Fuse box 303, 304, 305
Fuses 303
Fuse box in battery box 303
Fuse box in front passenger footwell
304
Fuse box in middle tunnel 305
Fuse box in passenger
compartment 303
G
Garage door opener 29, 191
Gasoline see Fuel 215
Gasoline additives 319
Gear range 326
Automatic transmission 137
Limiting 137
Shifting into optimal 137
Transfer case 141
Gear range limit
Canceling 137
Gear selector lever
Cleaning 235
Position 138Global
Locking 85
Unlocking 85
Global Positioning System (GPS) 326
Glossary 325
Glove box 23, 176
Closing 176
Opening 176
Good visibility 147
GPS 326
GPS see COMAND 189
H
Hard plastic trim items
Cleaning 236
Hazard warning flasher 103
Switching off 104
Switching on 104
Head restraints 92
Power seats 36
Synchronizing 93
Headlamp cleaning system 222
Headlamp switch-off delay see Delayed
switch-off, exterior lamps