2003 MERCEDES-BENZ E320 sbc

306 Practical hintsWhat to do if …Except Canada:;Canada only:3
Reduced braking effect
Visit workshop!
Increased braking dis-
tance
Visit workshop!
The SBC brake system is in the limp-home
(emergency operation) mode. Consider-
able brake pedal force is required and the
stopping distance is increased.

Continue driving with added caution.

Adjust driving to be consistent with
reduced braking responsiveness.
Brake fluid
Visit workshop!
There is insufficient brake fluid in the reser-
voir.

Risk of accident! Stop the vehicle
and notify an authorized
Mercedes-Benz Center. Do not add
brake fluid! This will not solve the
problem.
Except Canada:;Canada only:3
Service brake
Visit workshop!
There are malfunctions, but the SBC brake
system is operating normally.

Visit an authorized Mercedes-Benz
Center as soon as possible.
Display
Possible cause
Suggested solution

307 Practical hints
What to do if …
Except Canada:;Canada only:3
Brakes overheated!
Drive carefully!
The brake system is overheated due to an
excessive load on the brakes.

Relieve the load on the brake sys-
tem.

Drive more smoothly and think
ahead to avoid unnecessary braking.

When driving down slopes, shift into
a lower gear to use the engine’s brak-
ing power (
page 153).

Cautiously continue driving so that
the air stream will cool down the
brakes.
Display
Possible cause
Suggested solution
Warning!
G
Driving while these messages are displayed
can result in an accident. Have your brake
system checked immediately.
If there is a malfunction in the SBC brake
system, we recommend that the vehicle be
transported with all wheels off the ground
using flatbed or appropriate wheel lift/dolly
equipment. A tow bar must be used if cir-
cumstances do not permit the use of the
recommended towing methods and the ve-
hicle requires towing with all four wheels on
the ground. Towing the vehicle with all four
wheels on the ground is only permissible for
distances up to 30 miles (50 km) and at a
speed not to exceed 30 mph (50 km/h). For
more information, refer to "Towing the vehi-
cle" (
page 348).
If the SBC brake system enters its
limp-home (emergency operation) mode,
the driver must apply significantly greater
brake pedal pressure and depress the pedal
much further than normal to obtain braking
effect. If necessary, apply full pressure to
the brake pedal. Brakes are only applied to
the front wheels. Stopping distance is in-
creased!
Low brake fluid in the reservoir may cause
the braking system to fail!
Don’t add brake fluid before checking the
brake system. Overfilling the brake fluid

349 Practical hints
Towing the vehicle
Warning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the SBC brake
system


there is a malfunction in the power sup-
ply or in the vehicle’s electrical system
as that will be necessary to adequately con-
trol the towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the key is in
starter switch position2.
If the key is left in the starter switch
position0 for an extended period of time, it
can no longer be turned in the switch. In this
case, the steering is locked. To unlock, re-
move key from starter switch and reinsert.
iTo signal turns while being towed with
the hazard warning flasher in use, turn
key in starter switch to position2 and
activate the combination switch for the
left or right turn signal in the usual
manner – only the selected turn signal
will operate.
Upon canceling the turn signal, the haz-
ard warning flasher will operate again.
Warning!
G
The brake system requires electrical power
to operate.
A malfunction in the vehicle’s power supply
or electrical system may impair brake sys-
tem operation and switch it into its
limp-home (emergency operation) mode. To
brake, the driver must then apply signifi-
cantly greater brake pedal pressure and de-
press the pedal much further to obtain the
expected braking effect. If necessary, apply
full pressure to the brake pedal. Brakes are
only applied to the front wheels. Stopping
distance is increased! Adapt your driving
style accordingly. SBC brake system
(page 77).
With the engine not running, there is no
power assistance for the steering system. In
this case, it is important to keep in mind that
a considerably higher degree of effort is nec-
essary to steer the vehicle. Adapt your driv-
ing accordingly.

379 Technical terms
Restraint systems
Seat belts, belt tensioners, airbags and
child restraint systems. As indepen-
dent systems, their protective func-
tions complement one another.
RON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as
ANTI-KNOCK INDEX.
SBC
(S
ensotronic B
rake C
ontrol)
Electronically controlled hydraulic
braking system for increased braking
safety and comfort.Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being moved out of positionP
without key turned and brake pedal de-
pressed.
SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and airbags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.
Tele Aid System
(T
elematic A
larm I
dentification on D
e-
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.The Tele Aid system is operational pro-
viding that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.
Telematics*
A combination of the terms "telecom-
munications" and "informatics".
Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.
Tire speed rating
Part of a tire designation; indicates the
speed range for which a tire is ap-
proved.
Traction
Force exerted by the vehicle on the
road via the tires.

386 IndexDoors
Message in display 323
Opening from inside vehicle 93
Opening from outside 87, 91
Downhill driving
Cruise control 195
Downshifting 152
Driving
General instructions 40
Problems 48
Safety systems 73
With Distronic* 206
Driving hints
SBC brake system 79
Driving safety systems
ABS 73
BAS 74
ESP 75, 376
SBC brake system 77
Driving systems 194
AIRMATIC DC 209
Cruise control 194
Distronic* 197
Driving safety systems 73
Vehicle level control 209
DTR see Distronic* 376Dual control
AIRMATIC DC 209
E
Easy-entry/exit
Message in display 310
Easy-entry/exit feature* 102
Activating 143
Interrupting movement 102, 143
Electrical fuses 352
Electrical system 363
Electronic Stability Program see ESP 75,
376
Emergency call system* 235
Emergency calls
Initiating an emergency call 237
With Tele Aid* 236
Emergency operation (Limp Home
Mode) 156
Emergency operations
Releasing trunk lid from inside 97
Remote door unlock 241
Sliding/pop-up roof* or panorama slid-
ing/pop-up roof* 331
Unlocking the vehicle 327Emergency tensioning device 377
Emergency tensioning device see
ETD 377
Ending
A call (telephone) 149
Engine 360
Starting 43
Starting with KEYLESS-GO* 44
Starting with the key 44
Turning off with the key 52
Engine number 376
Engine oil
Adding 263
Additives 368
Checking level 262
Display messages 299, 300
Filler neck 263
Messages in display 264, 300
Viscosity 376
ESP 75, 376
Switching off 76
Switching on 77
Warning lamp 288
ETD 377
Safety guidelines 59
Exterior lamp switch 112

389 Index
Key, Mechanical 327
Key, SmartKey
Battery check lamp 87
Checking the batteries 88
Factory setting 87
Global locking 87
Global unlocking 87
Loss of 89
Positions in starter switch 31
Remote controls 86
Restoring to factory setting 87
Selective setting 87
Starting the engine 44
Turning off the engine 52
Unlocking the trunk lid 88
Unlocking with 30
Key, SmartKey with KEYLESS-GO*
Turning off the engine 53
KEYLESS-GO*
Activating ignition with 33
Closing side windows 92
Closing sliding/pop-up roof* 92
Factory setting 91
Global locking 91
Global unlocking 91
Important notes 90Locking the vehicle 92
Remote controls 89
Starting the engine 44
Turning off engine 53
Unlocking with 32
Unlocking, trunk lid 92
KEYLESS-GO* card
Messages in display 309
Keys 86
Kickdown 156, 377
Kilometers/miles in speedometer 134
Km/h or mph in speedometer 134
L
Lamp bulbs, exterior 332
Lamps, exterior
Front 332
Light sensor 313
Messages in display 313–??
Replacing bulbs for rear 333, 336
Lamps, indicator and warning
ABS 289
Airbag Off 61
Battery (SmartKey) 87
Brakes 291
Coolant 292
DTR* 199ESP 288
SBC 77
Seat belts 293
SRS 56
Language
Multifunction display 135
Setting 135
Layout of poly-V-belt drive 359
Level control system
AIRMATIC DC 209
Lever
Cruise control 201
License plate lamps 333
Messages in display 316
Replacing bulbs 336
Light sensor 313
Lighter see Cigarette lighter 232
Lighting 112
Automatic headlamp mode 113
Combination switch 115
Daytime running lamp mode 114
Door entry lamps 117
Exterior lamp switch 112
Front fog lamps 114
High beams 115
Instrument cluster illumination 118

391 Index
Storing exterior mirror parking
position 111
MON 260
MON (Motor Octane Number) 378
Mph or km/h in speedometer 134
Multicontour seat* 104
Multifunction display 121, 378
Selecting language 135
Standard display 125
Multifunction display messages
ABS 296
BAS 297, 298
Batteries 303, 304
Brake pads 305
Coolant 311, 312
Coolant level 311
Distronic* 300
Doors 323
Easy-entry/exit feature 310
Engine oil level 300
Fuel reserve tank 313, 323
Hood 313
Key 313, 323
KEYLESS-GO* card 309
Lamps 313–??
Parking brake 310SBC brake system 305, 306
Seat belts 310
Steering gear oil level 318
Telephone* 309
Trunk lid 310
Washer fluid 311
Multifunction steering wheel 24, 122,
378
Buttons 122
N
Network provider 148
Night security illumination 114
O
Occupant safety 56
Airbags 57
Children and airbags 58
Children in the vehicle 65
Fastening the seat belt 40
Infant and child restraint systems 65
Seat belts 40, 59
Oil
Viscosity 376
One-touch gearshifting 152
Canceling gear range limit 152
Downshifting 152Upshifting 152
Opening 331
Ashtray 231
Doors from the inside 93
Glove box 226
Side windows 184
Sliding/pop-up roof* 187
Sliding/pop-up roof* with
SmartKey 188, 192
Trunk 88, 96
Trunk from the inside 94
Windows 184
Windows with SmartKey 185
Operating
Cassette player 128
CD player* 127, 128
Garage door opener 246
Integrated remote control 246
Radio 127
Safety 16
Telephone* 147
Vehicle outside the USA and
Canada 13
Operating safety 16
Operator’s Manual 10
Outside temperature indicator 120

393 Index
Placing upright 104
Rear seats 103
Rear seats
Rear seat head restraints 103
Rear view mirror automatic antiglare 157
Rear view mirrors see Mirrors
Rear window
Blocking operation 71
Rear window defroster 169, 180
Rear window sunshade* 160, 161
Regular driving style 212
Remote controls
Integrated 244
SmartKey 86
SmartKey with KEYLESS-GO* 89
Remote door unlock
With Tele Aid* 241
Remote Vehicle Diagnostics 378
Removing
Ski sack 219
Replacing
Bulbs 332
Front lamp bulbs 334
Fuses 353
High beam bulb (Bi-Xenon* headlamps
only) 334License plate lamp bulbs 336
Rear lamp bulbs 333, 336
Wiper blades 337
Reporting
Safety defects 18
Reset knob in the instrument cluster 131
Resetting
All functions (control system) 131
All functions of a submenu 131
Fuel consumption 146
Service indicator (FSS) 276, 278,
279
Stored speed in Distronic* 203
Trip odometer 119
Residual heat utilization 171, 182
Residual ventilation 171, 182
Restraint system see Infant and child re-
straint systems 65
Rims and Tires 361
Roadside assistance 12
Rolling code programming 245
RON (Research Octane Number) 260,
379
Roof rack 216
S
SafetyOccupant 56
Safety belts see Seat belts 40
Safety defects
Reporting 18
Safety systems
Driving 73
Saving current speed 195
SBC 77
SBC brake system 379
Activation 78
Deactivation 79
Driving hints 79
Messages in display 305, 306
Self-check 79
Warning lamp 77
Seat belt force limiter 64
Seat belts 61
Fastening 40
Message in display 310
Proper use of 42, 63
Safety guidelines 59
Warning lamp 293
Seat cushion depth
Adjusting 105
Seats 102
Adjusting 34