2003 Hyundai Elantra Brake system
[x] Cancel search: Brake systemPage 142 of 172
DO-IT-YOURSELF MAINTENANCE DO-IT-YOURSELF MAINTENANCEDO-IT-YOURSELF MAINTENANCE DO-IT-YOURSELF MAINTENANCE
DO-IT-YOURSELF MAINTENANCE
6-6
Ambient
temperature
°C ( °F)
G050C01A-AAT
To Check the Coolant Level To Check the Coolant LevelTo Check the Coolant Level To Check the Coolant Level
To Check the Coolant Level
The coolant level can be seen on the side of the
plastic coolant reservoir. The level of the cool-
ant should be between the "LOW" and "FULL"
lines on the reservoir when the engine is cold.
If the level is below the "LOW" mark, add
engine coolant to bring it up between "LOW"
and "FULL". If the level is low, inspect for
coolant leaks and recheck the fluid level fre-quently. If the level drops again, visit your
Hyundai dealer for an inspection and diagnosis
of the reason.
G050D02A-AAT
To Change the Engine Coolant To Change the Engine CoolantTo Change the Engine Coolant To Change the Engine Coolant
To Change the Engine CoolantThe engine coolant should be changed at those
intervals specified in the vehicle maintenance
schedule in Section 5.
CAUTION: CAUTION:CAUTION: CAUTION:
CAUTION:Engine coolant can damage the finish of Engine coolant can damage the finish ofEngine coolant can damage the finish of Engine coolant can damage the finish of
Engine coolant can damage the finish of
your car. If you spill engine coolant on the your car. If you spill engine coolant on theyour car. If you spill engine coolant on the your car. If you spill engine coolant on the
your car. If you spill engine coolant on the
car, wash it off thoroughly with clean water. car, wash it off thoroughly with clean water.car, wash it off thoroughly with clean water. car, wash it off thoroughly with clean water.
car, wash it off thoroughly with clean water.
1. Park the car on level ground, set the park-
ing brake and remove the radiator cap when
cool.
2. Be sure your drain receptacle is in place.
Open the drain cock on the radiator. Allow
all the engine coolant to drain from the
cooling system, then securely close the drain
cock.
3. Check Section 9 for the capacity of the
cooling system in your car. Then, following
the manufacturer's directions on the engine
coolant container, add the appropriate quan-
tity of coolant to the radiator.
G050D01E
Engine Coolant concentration
Antifreeze
solutionWater
35%
40%
50%
60% -15 (5)
-25 (-13)
-35 (-31)
-45 (-49)65%
60%
50%
40%
4. Turn the radiator cap counterclockwise with-
out pressing down on it, until it stops. This
relieves any pressure remaining in the cool-
ing system. And remove the radiator cap by
pushing down and turning counterclockwise.
Now fill the radiator with clean demineral-
ized or distilled water. Continue to add clean
demineralized or distilled water in small quan-
tities until the fluid level stays up in the
radiator neck.
G050D03E
Page 148 of 172
DO-IT-YOURSELF MAINTENANCE DO-IT-YOURSELF MAINTENANCEDO-IT-YOURSELF MAINTENANCE DO-IT-YOURSELF MAINTENANCE
DO-IT-YOURSELF MAINTENANCE
6-12
G120C02A-AAT
Recommended Brake Fluid Recommended Brake FluidRecommended Brake Fluid Recommended Brake Fluid
Recommended Brake FluidUse only hydraulic brake fluid conforming to
DOT 3 or DOT 4 specifications in your braking
system. Follow the instructions printed on the
container.
G120D01A-AAT
To Check the Fluid Level To Check the Fluid LevelTo Check the Fluid Level To Check the Fluid Level
To Check the Fluid LevelThe fluid level in the brake fluid reservoir should
be checked periodically. The level should be
between the "MIN" and "MAX" marks on the
side of the reservoir. If the level is at or below
the "MIN" mark, carefully add fluid to bring it up
to "MAX". Do not overfill.
G120E02A-AAT
Adding Brake Fluid Adding Brake FluidAdding Brake Fluid Adding Brake Fluid
Adding Brake FluidWARNING: WARNING:WARNING: WARNING:
WARNING:
Handle brake fluid carefully. It can damage Handle brake fluid carefully. It can damageHandle brake fluid carefully. It can damage Handle brake fluid carefully. It can damage
Handle brake fluid carefully. It can damage
your vision if it gets into your eyes. Use only your vision if it gets into your eyes. Use onlyyour vision if it gets into your eyes. Use only your vision if it gets into your eyes. Use only
your vision if it gets into your eyes. Use only
DOT 3 or DOT 4 specification fluid from a DOT 3 or DOT 4 specification fluid from aDOT 3 or DOT 4 specification fluid from a DOT 3 or DOT 4 specification fluid from a
DOT 3 or DOT 4 specification fluid from a
sealed container. Do not allow the fluid can sealed container. Do not allow the fluid cansealed container. Do not allow the fluid can sealed container. Do not allow the fluid can
sealed container. Do not allow the fluid can
or reservoir to remain open any longer than or reservoir to remain open any longer thanor reservoir to remain open any longer than or reservoir to remain open any longer than
or reservoir to remain open any longer than
required. This will prevent entry of dirt and required. This will prevent entry of dirt andrequired. This will prevent entry of dirt and required. This will prevent entry of dirt and
required. This will prevent entry of dirt and
moisture which can damage the brake sys- moisture which can damage the brake sys-moisture which can damage the brake sys- moisture which can damage the brake sys-
moisture which can damage the brake sys-
tem and cause improper operation. tem and cause improper operation.tem and cause improper operation. tem and cause improper operation.
tem and cause improper operation.
To add brake fluid, first wipe away any dirt then
unscrew the fluid reservoir cap. Slowly pour the
recommended fluid into the reservoir. Do not
overfill. Carefully replace the cap on the reser-
voir and tighten.
G130A01S-AAT
CHECKING THE CLUTCH FLUID CHECKING THE CLUTCH FLUIDCHECKING THE CLUTCH FLUID CHECKING THE CLUTCH FLUID
CHECKING THE CLUTCH FLUID
To Check the Clutch Fluid To Check the Clutch FluidTo Check the Clutch Fluid To Check the Clutch Fluid
To Check the Clutch Fluid
G120E01E
G130A01EG130B02A-AAT
To Replace the Fluid To Replace the FluidTo Replace the Fluid To Replace the Fluid
To Replace the FluidRecommended brake fluid conforming to DOT
3 or DOT 4 specification should be used. The
reservoir cap must be fully tightened to avoid
contamination from foreign matter or moisture.
NOTE: NOTE:NOTE: NOTE:
NOTE:Do not allow any other liquids to contami- Do not allow any other liquids to contami-Do not allow any other liquids to contami- Do not allow any other liquids to contami-
Do not allow any other liquids to contami-
nate the brake fluid. Seal damage will result. nate the brake fluid. Seal damage will result.nate the brake fluid. Seal damage will result. nate the brake fluid. Seal damage will result.
nate the brake fluid. Seal damage will result.
WARNING: WARNING:WARNING: WARNING:
WARNING:Use caution when handling brake fluid. It Use caution when handling brake fluid. ItUse caution when handling brake fluid. It Use caution when handling brake fluid. It
Use caution when handling brake fluid. It
can damage your vision if you get it in your can damage your vision if you get it in yourcan damage your vision if you get it in your can damage your vision if you get it in your
can damage your vision if you get it in your
eyes. It will also damage your vehicle's paint eyes. It will also damage your vehicle's painteyes. It will also damage your vehicle's paint eyes. It will also damage your vehicle's paint
eyes. It will also damage your vehicle's paint
if spilled on it and not removed immediately. if spilled on it and not removed immediately.if spilled on it and not removed immediately. if spilled on it and not removed immediately.
if spilled on it and not removed immediately.
The clutch fluid level in the master cylinder
should be checked when performing other un-
der hood services. The system should be
checked for leakage at the same time.
Check to make certain that the clutch fluid level
is always between the "MAX" and "MIN" level
markings on the fluid reservoir. Fill as required.
Fluid loss indicates a leak in the clutch system
which should be inspected and repaired imme-
diately. Consult your Hyundai dealer.
Page 165 of 172
VEHICLE SPECIFICATIONS VEHICLE SPECIFICATIONSVEHICLE SPECIFICATIONS VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
9-1 Liter
55
Item
Battery
Alternator
9. 9.9. 9.
9.
VEHICLE SPECIFICA VEHICLE SPECIFICAVEHICLE SPECIFICA VEHICLE SPECIFICA
VEHICLE SPECIFICA
TIONS TIONSTIONS TIONS
TIONS
Rack and pinion
0 ~ 1.18 in. (0 ~ 30 mm)
5.4 in. (138 mm)
Vane type
in. (mm)
9 99 9
9
Overall length
Overall width
Overall height (unladen)
Wheel base
Wheel tread
J010A01E-AAT
MEASUREMENT MEASUREMENTMEASUREMENT MEASUREMENT
MEASUREMENT
177.5(4510 )
67.7 (1720)
56.1 (1425)
102.8 (2610)
58.5 (1485)
58.1(1475 ) Front
Rear
J020A01S-AAT
POWER STEERING POWER STEERINGPOWER STEERING POWER STEERING
POWER STEERING
Type
Wheel free play
Rack stroke
Oil pump type
J060A01S-AAT
FUEL SYSTEM FUEL SYSTEMFUEL SYSTEM FUEL SYSTEM
FUEL SYSTEM
Fuel tank
capacityUS.gal
14.5Imp.gal
12
J040A02E-AAT
ELECTRICAL ELECTRICALELECTRICAL ELECTRICAL
ELECTRICAL
MF60AH (12V)
90A (13.5V)
J050A01S-AAT
BRAKE BRAKEBRAKE BRAKE
BRAKE
Type
Front brake type
Rear brake type
Parking brakeDual hydraulic with brake booster
Ventilated disc
Ventilated disc (With ABS)
Drum (Without ABS)
Cable Tire
Standard
Spare
Size
P195/60 R15
T125/70(R)D15
J030A02E-AAT
TIRE TIRETIRE TIRE
TIRE
Tire pressure
30(210)
60(420)
psi (kpa)
Page 168 of 172
INDEX INDEXINDEX INDEX
INDEX
10-1 Catalytic Converter .................................................................... 7-1 ~ 7-2
CD Auto Changer .............................................................................1-51
CD Auto Changer (H260, H290) ...................... 1-78 ~ 1-79, 1-87 ~ 1-88
Child-Protector Rear Door Lock ......................................................... 1-4
Child Restraint System .......................................................... 1-16 ~ 1-19
Cigarette Lighter ................................................................................1-40
Clock .................................................................................................1-40
Clutch
Checking fluid ................................................................................6-12
Pedal free play ..............................................................................6-14
Combination Light
Headlight flasher ...........................................................................1-37
Headlight switch ............................................................................1-37
High-beam switch ..........................................................................1-37
Lane change signal .......................................................................1-37
Turn signal operation ....................................................................1-36
Compact Disc Player Operation (H260, H290)..1-76 ~ 1-77, 1-85 ~ 1-86
Consumer Information ......................................................................... 8-4
Cooling Fans .....................................................................................6-17
Corrosion Protection
Cleaning the interior ........................................................................ 4-3
Protecting your Hyundai from corrosion ......................................... 4-1
Washing and waxing ....................................................................... 4-2
Cruise Control ........................................................................ 1-52 ~ 1-54
D DD D
D
Defrosting/Defogging .........................................................................1-57
Door
Central door lock ............................................................................. 1-4
Door locks ....................................................................................... 1-2
Front door edge warning light .......................................................1-48
Locking and unlocking front doors with a key ................................ 1-3
Drink Holder ......................................................................................1-41
Drive Belts ............................................................................... 6-13, 6-15
ZK000A1-G
10. INDEX 10. INDEX10. INDEX 10. INDEX
10. INDEX
A AA A
A
Air Bag ................................................................................... 1-21 ~ 1-26
Air Cleaner Filter ................................................................................. 6-9
Air Conditioning
Care ..............................................................................................6-13
Operation.......................................................................................6-13
Switch ............................................................................................1-58
Air Filter ................................................................................. 1-64 ~ 1-65
Antenna.............................................................................................1-92
Ashtray ..............................................................................................1-41
Automatic Heating and Cooling Control System ................... 1-60 ~ 1-65
B BB B
B
Battery ...................................................................................... 2-11, 6-16
Brake
Anti-lock system .............................................................................. 2-8
Checking the brakes .....................................................................6-11
Fluid...............................................................................................6-11
Pedal clearance ............................................................................6-14
Pedal free play ..............................................................................6-14
Practices ................................................................................ 2-7 ~ 2-8
Breaking-In your new Hyundai ....................................................1-1~1-2
Bulbs Wattage ...................................................................................6-20
C CC C
CCare of Cassette Tapes ........................................................ 1-90 ~ 1-91
Care of Disc ......................................................................................1-90
Cassette Tape Player Operation (H240, H290).1-71 ~ 1-72, 1-83 ~ 1-8410 1010 10
10
Page 170 of 172
INDEX INDEXINDEX INDEX
INDEX
10-3 S SS S
S
Seat Belts
3-Point system ................................................................... 1-13 ~ 1-16
Adjustable height ...........................................................................1-13
Adjusting your seat belt ................................................................1-14
Care of seat belts .........................................................................1-12
Precautions ...................................................................................1-11
Spark Plugs ............................................................................... 6-7 ~ 6-8
Spectacle Case .................................................................................1-44
Speedometer.....................................................................................1-33
Starting Procedures ............................................................................ 2-3
Steering Wheel
Free play .......................................................................................6-13
Tilt lever ........................................................................................1-52
Stereo Radio Operation (H240, H260, H290)
................................................. 1-68 ~ 1-70, 1-73 ~ 1-75, 1-80 ~ 1-82
Stereo Sound System ............................................................ 1-66 ~ 1-67
Sun Visor ..........................................................................................1-51
Sunroof..............................................................................................1-42
Sunshade..........................................................................................1-42
T TT T
T
Tachometer............................................................................ 1-33 ~ 1-34
Tail Gate ...........................................................................................1-51
Theft Alarm System ................................................................... 1-4 ~ 1-6
Tires
Balancing ......................................................................................... 8-2
Chains ............................................................................................. 8-2
Changing a flat tire .......................................................................... 3-4
If you have a flat tire ....................................................................... 3-3
Information....................................................................................... 8-1
Pressure .......................................................................................... 8-1
Replacement................................................................................... 8-3
Rotation........................................................................................... 8-2 K KK K
K
Keys .................................................................................................... 1-2
If you lose your keys ...................................................................... 3-9
Positions .......................................................................................... 2-2
L LL L
L
Replacing Light Bulbs .......................................................................6-18
Lubrication Chart ................................................................................. 9-3
M MM M
M
Maintenance Intervals
Explanation of scheduled maintenance items ........................ 5-6 ~ 5-8
Maintenance under severe usage conditions ................................. 5-5
Scheduled maintenance ......................................................... 5-3 ~ 5-4
Service requirements ...................................................................... 5-1
Mirros
Day-night inside rearview ..............................................................1-47
Outside rear view ..........................................................................1-45
Multi Box ...........................................................................................1-45
O OO O
O
Odometer................................................................................. 1-34, 1-35
P PP P
P
Parking Brake ...................................................................................1-47
Passenger Presence Detection ........................................................1-24
Power Steering Fluid Level ...............................................................6-17
Pre-tensioner Seat Belt .......................................................... 1-20 ~ 1-21
R RR R
R
Rear Seatbacks
Fold down ............................................................................. 1-9 ~ 1-11
Drink holder ...................................................................................1-41
Rear Window Defroster Switch .........................................................1-39
Rear Window Wiper and Washor .....................................................1-39