2003 HONDA PILOT power steering

Always use Honda Power Steering
Fluid. If it is not available, you may
use another power steering f luid as
an emergency replacement.
However, continued use can cause
increased wear and poor steering in
cold weather. Have the power
steering system f lushed and ref illed
with Honda PSF as soon as possible.
Check the level when the engine is
cold. Look at the side of the
reservoir. The f luid should be
between the UPPER LEVEL and
LOWER LEVEL. If it is below the
LOWER LEVEL, add power steering
f luid to the UPPER LEVEL. A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently and have
the system inspected as soon as
possible.
Power Steering
Maint enance296
LOWER LEVELUPPER LEVEL
T urning the steering wheel to f ull lef t
or right lock and holding it there can
damage the power steering pump.

µµ
Check the condition of the two drive
belts (power steering belt and
alternator belt). Examine the edges
of each belt f or cracks or f raying. If you see signs of wear or looseness,
have your dealer adjust or replace
the belts. Power steering belt: Thebeltshouldhavethefollowing
‘‘play’’ or def lection.
Check the tension of the power
steering belt by pushing on it with
your thumb midway between the
pulleys.
The dust and pollen f ilter removes
pollen and dust that is brought in
f rom the outside through the heating
and cooling system/climate control
system.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if air f low f rom the
climate control system becomes less
than usual. Have the dust and pollen
f ilter replaced by your Honda dealer.
Drive Belts
Dust and Pollen Filter
Maint enance
Dust and Pollen Filter, Drive Belts
307
POWER STEERING BELT
ALTERNATOR BELT
0.51 0.65 in (13.0 16.5 mm)

ÎÎ
Î
Î
µµ Î Î
Î
Î
Specif ications
T echnical Inf ormation362
Capacities
Dimensions
Weights
Air Conditioning Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid
Windshield
washer
reservoir
1.74 US gal (6.6
, 1.45 Imp gal)
2.25 US gal (8.5, 1.87 Imp gal)
5.1 US qt (4.8
, 4.2 Imp qt)
4.5 US qt (4.3
, 3.8 Imp qt)
5.8 US qt (5.5
, 4.8 Imp qt)
3.2 US qt (3.0, 2.6 Imp qt)
8.2 US qt (7.8, 6.9 Imp qt)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
, 0.13 Imp gal)
Excluding the oil remaining in the engine. 19.3 US gal (73
, 16.1 Imp gal)
2.79 US qt (2.64
,2.32Impqt)
188.0 in (4,775 mm)
76.3 in (1,938 mm)
70.6 in (1,793 mm)
4.8 US qt (4.5
, 4.0 Imp qt)
66.3 in (1,685 mm)
66.5 in (1,690 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating
Gross combined weight
rating (GCWR)
See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
Refrigerant type
Charge quantity
Lubricant type HFC-134a (R-134a)
24.7 26.5 oz (700 750 g) ND-OIL8
106.3 in (2,700 mm)
Approx.
Front
Rear
1:
2:
Equipped with transmission fluid cooler and power steering fluid
cooler. Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
1:
2:
2 1
2
1

CONT INUED
...
Accessories and Modif ications . 223
................................
Accessories .223
...
Additional Safety Precaution . 224
............................
Modif ications .224
ACCESSORY (Ignition Key .......................................
Position) .82
............
Accessory Power Sockets . 110
....................
Additives, Engine Oil . 284
...............................
Airbag (SRS) .9, 50
.....................
Air Cleaner Element .297
......
Air Conditioning System . 118,130
..............................
Maintenance .306
.....................
Rear A/C Control .135
.................................
Usage .118, 130
...............
Air Outlets (Vents) . 120,128
.......................
Air Pressure, Tires .308
.......................
Alcohol in Gasoline .366
.......
Aluminum Wheels, Cleaning . 327
......................................
Antif reeze .287
Anti-lock Brakes (ABS) ....................
Indicator Light .63, 243
...................................
Operation .242
..............
Anti-thef t, Audio System . 153
.
Anti-thef t Steering Column Lock . 81..........................
Appearance Care .325
................
Audio System . 137,153,168
...
Automatic Seat Belt Tensioners . 48
...
Automatic Lighting Off Feature . 73
.............
Automatic Speed Control . 207
..............
Automatic Transmission . 233
..........................
Capacity, Fluid .362
...............
Checking Fluid Level . 293
.......................................
Shif ting .234
.
Shif t Lever Position Indicator . 233
................
Shif t Lever Positions . 234
....................
Shif t Lock Release . 236
Battery Charging System ...........................
Indicator .62, 348
............................
Jump Starting .343
..............................
Maintenance .302
............................
Specif ications .363
..............................
Bef ore Driving .215
....................................
Belts,Seat .8,46
.........................
Beverage Holders .105
.................................
Body Repairs .332 Brakes
...........
Anti-lock System (ABS) . 242
.............
Break-in, New Linings . 216
...........................................
Fluid .295
....................
Bulb Replacement .320
.......................................
Parking .104
.................
System Indicator . 63,351
........................
Wear Indicators .241
.............................
Braking System .241
.................
Break-in, New Vehicle . 216
..
Brightness Control, Instruments . 73
........................
Brights, Headlights .72
Bulb Replacement ..........................
Back-up Lights .321
..............................
Brake Lights .320
......................
Cargo Area Light .323
................
Front Parking Lights . 318
........
Front Side Marker Lights . 319
.................................
Headlights .317
..............
Individual Map Lights . 322
...................
License Plate Light . 321
.................................
Rear Bulbs .320
............................
Specif ications .363
............
Turn Signal Lights . 318,320
..............................
Bulbs, Halogen .317
Index
A
B
I

CONT INUED
..........
DOT Tire Quality Grading . 364
.....................................
Drive Belts .307
...........
Driver and Passenger Safety . 5
...........................................
Driving .229
....................................
Economy .222
.........................
In Bad Weather .245
................
In Foreign Countries . 367
..................
Dust and Pollen Filter . 307
...................................
DVD Player .190
..............................
Economy, Fuel .222
............
Emergencies on the Road . 333
.............
Battery, Jump Starting . 343
...........
Brake System Indicator . 351
................
Changing a Flat Tire . 335
.....
Charging System Indicator . 348
..................
Checking the Fuses . 353
.....
Low Oil Pressure Indicator . 347
...
Malf unction Indicator Lamp . 349
..................
Overheated Engine . 345
.........................
Emergency Brake .104
......................
Emergency Flashers .76
......................
Emergency Towing .358
.......................
Emissions Controls .368 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts .307
Malf unction Indicator ................................
Lamp .62, 349
........
Oil Pressure Indicator . 62,347
..............
Oil, What Kind to Use . 283
...............................
Overheating .345
............................
Specif ications .363
............................
Speed Limiter .236
.......................................
Starting .232
......................
Ethanol in Gasoline .366
.
Evaporative Emissions Controls . 368
...............................
Exhaust Fumes .56
Exhaust Gas Recirculation ........................................
System .369
Expectant Mothers, Use of Seat ........................................
Belts by .19
..................
Exterior, Cleaning the . 326
............................
Fabric, Cleaning .329
..........................
Fan, Interior .118, 131
Features, Comfort and ..............................
Convenience .117 ....................
Filling the Fuel Tank . 217
Filters ...............................................
Air .297
.......................
Air Conditioning .306
...............................................
Oil .285
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 335
Fluids ..........
Automatic Transmission . 293
..........................................
Brake .295
..........................
Power Steering .296
..................
Windshield Washer . 292
FM Stereo Radio ...................................
Reception .176
...................
Folding the Third Seat . 95
.....
Foreign Countries, Driving in . 367
..........................
Four-way Flashers .76
.................................................
Fuel .216
......................
Fill Door and Cap .217
...........................................
Gauge .68
................
Octane Requirement . 216
...............................
Oxygenated .366
........................
Reserve Indicator .65
........................
Tank, Filling the .217
.....................
Fuses, Checking the .353
Index
E
F
III

CONT INUED
..................................................
Keys .79
..................................
Maintenance .269
...
Owner Maintenance Checks . 281
.................................
Record .279-280
......................
Required Indicator .69
..........................................
Saf ety .270
.............................
Schedule .274-276
.
Malf unction Indicator Lamp . 62,349
..............
Manual Seat Adjustments . 91
...............................
Meters, Gauges .67
...................
Methanol in Gasoline . 366
........................
Mirrors, Adjusting .103
...................
Neutral Gear Position . 235
..................
New Vehicle Break-in . 216
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 360..............................
Paint Touch-up .327
..............
Panel Brightness Control . 73
........................
Park Gear Position .234
................................
Jump Starting .343
.......................
Label, Certif ication .360
.................
Lane Change, Signaling . 74
..................
Lap/Shoulder Belts . 15,46
....................
Light Control Switch .112
.............................................
Lights .315
....................
Bulb Replacement .317
.......................................
Indicator .61
.......................................
Interior .112
.........................................
Parking .72
..................................
Turn Signal .74
....................................
Load Limits .226
......
LOCK (Ignition Key Position) . 81
Locks .......
Anti-thef t Steering Column . 81
............................
Fuel Fill Door .217
....................................
Glove Box .88
....................
Lockout Prevention . 83
.................................
Power Door .82 ........................
Low Coolant Level .221
.........................
Low Fuel Indicator .65
...
Low Oil Pressure Indicator . 62,347
...
Lubricant Specif ications Chart . 362
.........................................
Luggage .225 ...
Octane Requirement, Gasoline . 216
.........................................
Odometer .67
...............................
Odometer, Trip .67
Oil ........................
Change, How to .285
..............
Change, When to . 274,276
......................
Checking Engine .220
..............
Pressure Indicator . 62,347
Selecting Proper Viscosity ......................................
Chart .284
...........
ON (Ignition Key Position) . 82
..
Operation in Foreign Countries . 367
............................
Outside Mirrors .102
....................
Overheating, Engine .345
.......
Owner Maintenance Checks . 281
.........................
Oxygenated Fuels .366
Index
L K
N MO
P
V

Î
....................................
Tire Chains .314
.........
Tire, How to Change a Flat . 335
...............................................
Tires .308
..............................
Air Pressure .308
...................................
Balancing .311
.........................
Checking Wear .310
..........................
Compact Spare .334
......
DOT Tire Quality Grading . 364
......................................
Inf lation .308
..................................
Inspection .310
...................................
Replacing .312
......................................
Rotating .311
...........................................
Snow .314
............................
Specif ications .363
................................
Tire Chains .314
Towing .....................................
A Trailer .247
................
Emergency Wrecker . 358
Your Vehicle Behind a ............................
Motorhome .259
Transmission ...............
Checking Fluid Level . 293
...........................
Fluid Selection .293
..............
Identif ication Number . 360
.............
Shif ting the Automatic . 233
.....................................
Treadwear .364 .......................................
Trip Meter .68
....................................
Turn Signals .74
...................
Tools, Tire Changing . 335
.....................
Underside, Cleaning .331
Unexpected, Taking Care ..........................................
of the .333
....
Unif orm Tire Quality Grading . 364
........................
Unleaded Gasoline .216
.....................
Upholstery Cleaning .328
.......
Used Oil, How to Dispose of . 286
................................
Vanity Mirror .109
.................
Vehicle Capacity Load . 226
......................
Vehicle Dimensions .362
....
Vehicle Identif ication Number . 360
.............................
Vehicle Storage .324
.....................................
Ventilation .123
.................................................
VIN .360
...............................
Vinyl Cleaning .329
..................................
Viscosity, Oil .284
..................................
VTM-4 Lock .238 .............
WARNING, Explanation of . ii
.........
Warning Labels, Location of . 57
..................
Warranty Coverages .375
Washer, Windshield ........
Checking the Fluid Level . 292
............................
Level Indicator .65
.....................................
Operation .76
.........................................
Washing .326
..................
Waxing and Polishing . 327
Wheels ...............
Adjusting the Steering . 78
............
Alignment and Balance . 311
..........................
Compact Spare .334
......................................
Wrench .337
Windows .....................................
Cleaning .330
..................
Operating the Power . 99
...........................
Rear, Def ogger .77
Windshield .....................................
Cleaning .330
...........................
Def roster .125, 133
.......................................
Washers .76
Wipers, Windshield .......................
Changing Blades .304
Index
V W
U
VIII

Service Inf ormat ion Summary
Gasoline:Tire Pressure (measured cold):
Power Steering Fluid:
Brake Fluid:
Rear Differential Fluid:
Fuel Tank Capacity:
Recommended Engine Oil:
Automatic Transmission Fluid: 32 psi (220 kPa , 2.2 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ). Front/Rear:
Compact Spare Tire:
Honda VTM-4 Differential Fluid
(see page ).
Unleaded gasoline, pump octane
number of 86 or higher.
API Service SJ ‘‘Energy
Conserving’’ oil, SAE 5W-20
viscosity (see page ).
Oil change capacity (including
filter):
5.1 US qt (4.8
, 4.2 Imp qt)
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ). 296
295
294
283
293
19.3 US gal (73, 16.1 Imp gal)