2003 GMC SONOMA boot

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Your Vehicle and the Environment....................6-2
Maintenance Requirements..............................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Selecting the Right Schedule...........................6-5
Short Trip/City Scheduled Maintenance..............6-7
Long Trip/Highway Scheduled Maintenance......6-18
Part B: Owner Checks and Services................6-26
At Each Fuel Fill..........................................6-26
At Least Once a Month.................................6-26
At Least Twice a Year...................................6-26At Least Four Times a Year...........................6-27
At Least Once a Year...................................6-28
Part C: Periodic Maintenance Inspections.........6-31
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection............................6-31
Exhaust System Inspection............................6-31
Fuel System Inspection..................................6-31
Engine Cooling System Inspection...................6-31
Throttle System Inspection.............................6-32
Transfer Case and Front Axle (Four-Wheel
Drive) Inspection.......................................6-32
Brake System Inspection................................6-32
Part D: Recommended Fluids and Lubricants. . . .6-33
Part E: Maintenance Record...........................6-35
Section 6 Maintenance Schedule
6-1
2003 - Sonoma OM

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).You should let your dealer’s
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-9.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chang, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in theoor pan or could let
exhaust fumes into the vehicle. SeeEngine Exhaust
on page 2-37.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-31
2003 - Sonoma OM

Headlamps (cont.)
Halogen Bulbs............................................5-50
One-Piece Front Turn Signal Lamps...............5-52
Two-Piece Front Turn Signal Lamps...............5-53
Heated Seats................................................... 1-5
Heating.........................................................3-18
Highway Hypnosis...........................................4-34
Hill and Mountain Roads..................................4-34
Hitches..........................................................4-56
Hood
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn ............................................................... 3-4
How to Add Coolant to the Coolant
Recovery Tank............................................5-32
How to Add Coolant to the Radiator..................5-34
How to Add Fluid....................................5-22, 5-24
How to Check................................5-20, 5-23, 5-59
How to Check and Add Fluid
............................5-25
How to Check Lubricant
..........................5-47, 5-49
How to Check Power Steering Fluid
..................5-37
How to Inspect the Engine Air Cleaner/Filter
.......5-19
How to Use This Manual
...................................... ii
How to Wear Safety Belts Properly
...................1-15
Hydraulic Clutch
.............................................5-24
Hydraulic Clutch System Check
........................6-27
Hydroplaning
..................................................4-30I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-30
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-40
If You Do Decide To Pull A Trailer.....................4-52
If You’re Caught in a Blizzard...........................4-38
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-29
Infants and Young Children, Restraints...............1-32
Inflation–Tire Pressure...................................5-58
Inspection
Brake System.............................................6-32
Engine Cooling System................................6-31
Exhaust System..........................................6-31
Fuel System...............................................6-31
Part C - Periodic Maintenance.......................6-31
Steering, Suspension and Front Drive
Axle Boot and Seal..................................6-31
Throttle System...........................................6-32
Transfer Case and Front Axle
(Four-Wheel Drive)...................................6-32
Installing a Garage Door Opener.......................2-43
Instrument Panel
Cluster.......................................................3-21
Overview..................................................... 3-2
7
2003 - Sonoma OM

Locks
Door ........................................................... 2-8
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door .................................................. 2-9
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks.............................2-11
Long Trip/Highway Definition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-18
Loss of Control...............................................4-12
Low Fuel Warning Light...................................3-35
Luggage Carrier..............................................2-50
Lumbar
Manual Controls............................................ 1-4
Power Controls............................................. 1-5
M
Maintenance, Normal Replacement Parts............5-96
Maintenance Schedule
At Each Fuel Fill.........................................6-26
At Least Four Times a Year..........................6-27
At Least Once a Month................................6-26
At Least Once a Year..................................6-28
At Least Twice a Year..................................6-26Maintenance Schedule (cont.)
Brake System Inspection..............................6-32
Engine Cooling System Inspection.................6-31
Exhaust System Inspection...........................6-31
Fuel System Inspection................................6-31
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-18
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-26
Part C - Periodic Maintenance Inspections......6-31
PartD-Recommended Fluids and
Lubricants...............................................6-33
PartE-Maintenance Record........................6-35
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
...................6-31
Throttle System Inspection
............................6-32
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection
....................6-32
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
.....................4-60
Making Turns
.................................................4-58
9
2003 - Sonoma OM

Stalling on an Incline.......................................4-24
Starter Switch Check.......................................6-28
Starting Your Engine.......................................2-22
Shifting Into................................................2-22
Starting Your VORTEC™2200 L4 Engine............ 6-4
Starting Your VORTEC™4300 V6 Engine..........2-23
Steering.......................................................... 4-8
Steering in Emergencies.................................... 4-9
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection.......................6-31
Steering Tips................................................... 4-8
Storage
Garment Hooks...........................................2-50
Storage Areas
Front Storage Area......................................2-49
Glove Box..................................................2-41
Luggage Carrier..........................................2-50
Overhead Console.......................................2-42
Storing a Flat or Spare Tire and Tools...............5-76
Stuck in Sand, Mud, Ice or Snow......................4-40
Sun Visors.....................................................2-16
Sunglasses Storage Compartment.....................2-46
Sunroof.........................................................2-52
Swing-Out Windows........................................2-16
T
Tachometer....................................................3-23
Tailgate.........................................................2-12Tailgate Lubrication Service..............................6-27
Taillamps.......................................................5-55
Temperature and Compass Display....................2-44
Testing the Alarm............................................2-18
Theft-Deterrent, Radio.....................................3-67
Theft-Deterrent Systems...................................2-17
Content Theft-Deterrent
................................2-17
Passlock
®...................................................2-19
Third Door
.....................................................2-12
Throttle System Inspection
...............................6-32
Tilt Wheel
........................................................ 3-4
Time Delay
....................................................2-39
Tire Inflation Check
.........................................6-26
Tires
.....................................................5-58, 5-84
Buying New Tires
........................................5-62
Chains
.......................................................5-66
Changing a Flat Tire
....................................5-68
Compact Spare Tire
.....................................5-78
If a Tire Goes Flat
.......................................5-67
Inflation–Tire Pressure
...............................5-58
Inspection and Rotation
................................5-60
Uniform Tire Quality Grading
.........................5-63
Wheel Alignment and Tire Balance
.................5-64
Wheel Replacement
.....................................5-65
When It Is Time for New Tires
......................5-61
To Use the Engine Coolant Heater
....................2-24
Top of the Instrument Panel
.............................5-81
Top Strap
......................................................1-41
14
2003 - Sonoma OM