2003 GMC SONOMA brake fluid

Long Trip/Highway Scheduled
Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be repeated after 100,000 miles
(166 000 km) at the same intervals for the life of
this vehicle. The services shown at 150,000 miles
(240 000 km) should be repeated at the same interval
after 150,000 miles (240 000 km) for the life of this
vehicle.
SeePart B: Owner Checks and Services on page 6-26
andPart C: Periodic Maintenance Inspections on
page 6-31.
Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
#Lubricate the front suspension, ball joints, steering
linkage, parking brake cable guides, propshaft splines,
universal joints, constant velocity joint and brake
pedal springs.+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 6-32.
**Drive axle service. See Part D: Recommended Fluids
and Lubricants on page 6-33 for proper lubricant to use:
❑Checkuid level and adduid as needed.
❑If your vehicle has a locking differential, drainuid and
rell atrst engine oil change.
7,500 Miles (12 500 km)
❑Change engine oil andlter (or every 12 months,
whichever occursrst).An Emission Control
Service.
❑Lubricate chassis components (or every 12 months,
whichever occursrst).(See footnote #.)
❑Check rear/front axleuid level and adduid as
needed. Check constant velocity joints and axle seals
for leaking.(See footnote **.)
❑Rotate tires. SeeTire Inspection and Rotation on
page 5-60for proper rotation pattern and additional
information.(See footnote +.)
6-18
2003 - Sonoma OM

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certied for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle’s engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-25.
Hydraulic Brake
SystemDelco Supreme 11
®Brake Fluid or
equivalent DOT-3 brakeuid.
Windshield
Washer SolventGM Optilkeen
®Washer Solvent or
equivalent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brakeuid).
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Manual
Transmission
with V6 EngineSynchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465, or equivalent).
Manual
Transmission
with L4 EngineFriction Modied Synchromesh
Transmission Fluid (GM Part No.
U.S. 12377916, in Canada
10953509).
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
®
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Wheel
BearingsWheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037, or
equivalent).
Front and Rear
Axle (Standard
Differential)SAE 80W-90 Axle Lubricant (GM
Part No. U.S. 1052271, in Canada
10950849, or equivalent).
6-33
2003 - Sonoma OM

A
Accessory Power Outlets.................................3-15
Adding Equipment to Your Air Bag-Equipped
Vehicle.......................................................1-63
Adding Washer Fluid.......................................5-38
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-5
Add-On Electrical Equipment............................5-88
Add-On Equipment..........................................4-48
Adjusting the Speakers
(Balance/Fade)....................3-39, 3-42, 3-49, 3-59
After Off-Road Driving.....................................4-26
Air Bag
Off Light.....................................................3-24
Readiness Light..........................................3-24
Air Bag System..............................................1-54
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-63
Air Bag Off Switch.......................................1-60
How Does an Air Bag Restrain?....................1-58
Servicing Your Air Bag-Equipped Vehicle.........1-63
What Makes an Air Bag Inflate?....................1-58
What Will You See After an Air Bag
Inflates?..................................................1-58
When Should an Air Bag Inflate?...................1-57
Where Are the Air Bags?..............................1-56
Air Cleaner/Filter, Engine.................................5-18
All Overseas Locations...................................... 7-4Aluminum Wheels...........................................5-84
AM ...............................................................3-67
AM-FM Radio.................................................3-37
Antenna, Fixed Mast.......................................3-69
Anti-Lock Brake System.................................... 4-6
Anti-Lock Brake, System Warning Light..............3-28
Appearance Care............................................5-79
Care of Safety Belts....................................5-82
Chemical Paint Spotting...............................5-85
Cleaning the Inside of Your Vehicle................5-79
Cleaning the Outside of Your Vehicle..............5-82
Finish Damage............................................5-85
GM Vehicle Care/Appearance Materials..........5-86
Sheet Metal Damage...................................5-85
Underbody Maintenance
...............................5-85
Weatherstrips
..............................................5-82
Approaching a Hill
..........................................4-18
Ashtrays
........................................................3-16
Assist Handles
...............................................2-50
Audio System(s)
.............................................3-36
AM-FM Radio
.............................................3-37
Care of Your Cassette Tape Player
................3-68
Care of Your CD Player
...............................3-69
Care of Your CDs
........................................3-69
Fixed Mast Antenna
.....................................3-69
Radio with Cassette and CD
.........................3-47
Radio with CD
............................................3-40
Radio with Six-Disc CD
................................3-56
1
2003 - Sonoma OM

Audio System(s) (cont.)
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-37
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
Theft-Deterrent Feature................................3-67
Understanding Radio Reception.....................3-67
Automatic Headlamp System............................3-11
Automatic Transmission...................................2-22
Fluid..........................................................5-20
Operation...................................................2-25
Automatic Transmission Check..........................6-27
Automatic Transmission Shift Lock Control
System Check.............................................6-29
B
Backing Up....................................................4-58
Battery..........................................................5-42
Battery Replacement......................................... 2-6
Battery Rundown Protection.............................3-15
Bed Rails......................................................2-52
Before Leaving on a Long Trip.........................4-33
Before You Go Off-Roading..............................4-13
Body Lubrication Service..................................6-28
Brake
Parking......................................................2-32
System Inspection.......................................6-32Brake (cont.)
System Warning Light..................................3-27
Brake Adjustment............................................5-41
Brake Fluid....................................................5-39
Brake Pedal Travel.........................................5-41
Brake Wear...................................................5-41
Brakes..........................................................5-39
Braking........................................................... 4-5
Braking in Emergencies..................................... 4-7
Break-In, New Vehicle.....................................2-20
Bulb Replacement...........................................5-50
Center High-Mounted Stoplamp (CHMSL)........5-54
Halogen Bulbs............................................5-50
Headlamps.................................................5-50
One-Piece Front Turn Signal Lamps...............5-52
Replacement Bulbs......................................5-55
Taillamps....................................................5-55
Two-Piece Front Turn Signal Lamps...............5-53
Buying New Tires...........................................5-62
C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-6
Capacities and Specifications............................5-94
Carbon Monoxide...................4-36, 4-51, 2-12, 2-37
2
2003 - Sonoma OM

Care of
Safety Belts................................................5-82
Your Cassette Tape Player............................3-68
Your CD Player...........................................3-69
Your CDs ...................................................3-69
Cassette Tape Messages.................................3-54
Cassette Tape Player Service...........................6-26
Center High-Mounted Stoplamp (CHMSL)...........5-54
Center Passenger Position, Safety Belts.............1-23
Chains, Tires..................................................5-66
Charging System Light....................................3-26
Check
Engine Light...............................................3-29
Gages Warning Light
...................................3-34
Checking Brake Fluid
......................................5-40
Checking Coolant
............................................5-26
Checking Engine Oil
........................................5-13
Checking the Fluid Level
..................................5-21
Checking Things Under the Hood
....................... 5-8
Checking Your Restraint Systems
......................1-64
Chemical Paint Spotting
...................................5-85
Child Restraints
Child Restraint Systems
...............................1-36
Infants and Young Children
...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)
..........................1-44
Older Children
.............................................1-30Child Restraints (cont.)
Securing a Child Restraint Designed for
the LATCH System...................................1-46
Securing a Child Restraint in a Center
Seat Position...........................................1-49
Securing a Child Restraint in a Rear
Outside Seat Position...............................1-46
Securing a Child Restraint in the Right
Front Seat Position...................................1-49
Top Strap...................................................1-41
Top Strap Anchor Location............................1-43
Where to Put the Restraint...................1-39, 1-40
Cigarette Lighter.............................................3-16
Cleaning
Inside of Your Vehicle..................................5-79
Outside of Your Vehicle................................5-82
Underbody Maintenance...............................5-85
Weatherstrips..............................................5-82
Cleaning Exterior Lamps/Lenses.......................5-83
Cleaning the Mirror.........................................2-39
Cleaning the Photocells...................................2-39
Climate Control System...................................3-17
Outlet Adjustment........................................3-19
Clutch, Hydraulic.............................................5-24
Compact Disc Messages.................3-46, 3-56, 3-67
Compact Spare Tire........................................5-78
Content Theft-Deferrent....................................2-17
Control of a Vehicle.......................................... 4-5
3
2003 - Sonoma OM

Headlamps (cont.)
Halogen Bulbs............................................5-50
One-Piece Front Turn Signal Lamps...............5-52
Two-Piece Front Turn Signal Lamps...............5-53
Heated Seats................................................... 1-5
Heating.........................................................3-18
Highway Hypnosis...........................................4-34
Hill and Mountain Roads..................................4-34
Hitches..........................................................4-56
Hood
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn ............................................................... 3-4
How to Add Coolant to the Coolant
Recovery Tank............................................5-32
How to Add Coolant to the Radiator..................5-34
How to Add Fluid....................................5-22, 5-24
How to Check................................5-20, 5-23, 5-59
How to Check and Add Fluid
............................5-25
How to Check Lubricant
..........................5-47, 5-49
How to Check Power Steering Fluid
..................5-37
How to Inspect the Engine Air Cleaner/Filter
.......5-19
How to Use This Manual
...................................... ii
How to Wear Safety Belts Properly
...................1-15
Hydraulic Clutch
.............................................5-24
Hydraulic Clutch System Check
........................6-27
Hydroplaning
..................................................4-30I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-30
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-40
If You Do Decide To Pull A Trailer.....................4-52
If You’re Caught in a Blizzard...........................4-38
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-29
Infants and Young Children, Restraints...............1-32
Inflation–Tire Pressure...................................5-58
Inspection
Brake System.............................................6-32
Engine Cooling System................................6-31
Exhaust System..........................................6-31
Fuel System...............................................6-31
Part C - Periodic Maintenance.......................6-31
Steering, Suspension and Front Drive
Axle Boot and Seal..................................6-31
Throttle System...........................................6-32
Transfer Case and Front Axle
(Four-Wheel Drive)...................................6-32
Installing a Garage Door Opener.......................2-43
Instrument Panel
Cluster.......................................................3-21
Overview..................................................... 3-2
7
2003 - Sonoma OM

Locks
Door ........................................................... 2-8
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door .................................................. 2-9
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks.............................2-11
Long Trip/Highway Definition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-18
Loss of Control...............................................4-12
Low Fuel Warning Light...................................3-35
Luggage Carrier..............................................2-50
Lumbar
Manual Controls............................................ 1-4
Power Controls............................................. 1-5
M
Maintenance, Normal Replacement Parts............5-96
Maintenance Schedule
At Each Fuel Fill.........................................6-26
At Least Four Times a Year..........................6-27
At Least Once a Month................................6-26
At Least Once a Year..................................6-28
At Least Twice a Year..................................6-26Maintenance Schedule (cont.)
Brake System Inspection..............................6-32
Engine Cooling System Inspection.................6-31
Exhaust System Inspection...........................6-31
Fuel System Inspection................................6-31
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-18
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-26
Part C - Periodic Maintenance Inspections......6-31
PartD-Recommended Fluids and
Lubricants...............................................6-33
PartE-Maintenance Record........................6-35
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
...................6-31
Throttle System Inspection
............................6-32
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection
....................6-32
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
.....................4-60
Making Turns
.................................................4-58
9
2003 - Sonoma OM

Parking
Brake........................................................2-32
Over Things That Burn.................................2-36
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-30
Parking on Hills..............................................4-59
Parking Your Vehicle.......................................2-36
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-26
Part C - Periodic Maintenance Inspections..........6-31
PartD-Recommended Fluids and Lubricants....6-33
PartE-Maintenance Record...........................6-35
Passing.................................................4-10, 4-58
Passlock
®......................................................2-19
Payload.........................................................4-48
Pickup Conversion to Chassis Cab....................4-50
Plan Ahead When Possible................................ 7-7
Playing a Cassette Tape..................................3-52
Playing a Compact Disc..................3-45, 3-54, 3-62
Playing a Specific Loaded
Compact Disc
.............................................3-63
Playing the Radio
...................3-37, 3-40, 3-47, 3-56
Power
Accessory Outlets
........................................3-15
Door Locks
.................................................. 2-9
Electrical System
.........................................5-88
Lumbar Controls
........................................... 1-5
Seat
............................................................ 1-4Power (cont.)
Steering Fluid.............................................5-37
Windows....................................................2-15
Power Steering................................................ 4-8
Programmable Automatic Door Locks.................. 2-9
Q
Questions and Answers About Safety Belts.........1-15
R
Radiator Pressure Cap....................................5-27
Radio Messages.............................3-39, 3-45, 3-52
Radios..........................................................3-36
AM-FM Radio.............................................3-37
Care of Your Cassette Tape Player................3-68
Care of Your CD Player...............................3-69
Care of Your CDs ........................................3-69
Radio with Cassette and CD.........................3-47
Radio with CD............................................3-40
Radio with Six-Disc CD................................3-56
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-37
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
Theft-Deterrent............................................3-67
Understanding Reception..............................3-67
RDS Messages..............................3-43, 3-51, 3-61
11
2003 - Sonoma OM