2003 FIAT PALIO maintenance schedule

75
CONTAINING RUNNING COSTS
AND POLLUTION
Tyres
Tyre pressure should be checked at
least once every four weeks: if the
pressure is too low fuel consumption
increases as the resistance to the
rolling movement of the tyre is
greater. In this state, tyre wear is in-
creased and handling suffers which will
effect safety.
Unnecessary loads
Do not travel with too much load in
the boot. The weight of the car (above
all in the urban traffic)and its trim
greatly effects consumption and sta-
bility.
Roof rack/ski rack
Remove roof racks and ski racks
from the roof of the car as soon as
they are no longer needed. These ac-
cessories reduce the aerodynamic
penetration of the car and will increase
consumption.
Electrical devices
Use electric devices for the neces-
sary time only. The heated rear win-
dow, additional lights, windscreen
wipers, heater, fan of the heating sys-
tem require large amounts of elec-
tricity and increasing the request for
power will also increase fuel con-
sumption (up to +25% when driving in
towns). Some suggestions which may help
you to keep the running costs of the
car down and lower the amount of
toxic emissions released into the at-
mosphere are given below.
GENERAL
CONSIDERATIONS
Car maintenance
The overall state of the car is an im-
portant factor which has a marked in-
fluence over fuel consumption and dri-
ving comfort and on the life span of
your car. For this reason care should
be taken to maintain your car by car-
rying out the necessary checks and
regulations in accordance with the
specifications given in the service
schedule (see sections: spark plugs,
idling, air cleaners, timing).
64-79 03/03/2003 06:45 PM Page 75

CAR MAINTENANCE
The Fiat Palio is new throughout, even in its ser-
vicing schedule.
For instance: the first scheduled servicing coupon
is prescribed at 1,000-1,500 kms or 3 months
whichever is earlier from the date of sale of vehicle.
However, it is useful to remember that the car
needs always ordinary attentions such as systematic
control with possible fluid level refuelling, tyre pres-
sure restoration, etc.
You should nonetheless bear in mind that the
proper maintenance of your car is certainly the best
way to keep it in tip-top conditions for years to
come and safeguard its performance and safety fea-
tures, while respecting the environment and keeping
running costs down.
Remember that the scrupulous compliance with
the servicing rules marked by the symbol ∑
can
constitute the condition necessary for the mainte-
nance of the warranty.
SCHEDULED SERVICING .................................... PAGE 105
SCHEDULED SERVICING
PLAN ............................................................................ PAGE 106
ADDITIONAL INTERVENTIONS ....................... PAGE 108
LEVEL CHECK ........................................................... PAGE 110
AIR CLEANER ............................................................ PAGE 116
BATTERY .................................................................... PAGE 117
ELECTRONIC CONTROL UNITS ..................... PAGE 120
SPARK PLUGS ........................................................... PAGE 121
WHEELS AND TYRES ............................................ PAGE 121
RUBBER PIPES ........................................................... PAGE 123
WINDSCREEN/REAR WINDOW WIPER......... PAGE 123
MANUAL CLIMATE SYSTEM ............................... PAGE 125
BODYWORK ............................................................ PAGE 125
INTERIORS ................................................................. PAGE 127
104
104-127 03/03/2003 06:53 PM Page 104

105
SCHEDULED
SERVICING
Correct maintenance of the car is es-
sential for ensuring it stays in tip-top
condition for a long time to come.
For this reason, Fiat prepared a se-
ries of maintenance controls and in-
terventions, from 1000-1500, 7500 &
15000 km and so on.
However it is useful to remember
that the Scheduled Servicing does not
completely exhaust all the exigencies
of the car: also in the initial period of
time prior to the coupon of 1000-
1500 km and later on, between one
coupon and an other, the ordinary at-
tentions are always necessary such as
systematic control with possible fluid
level refuelling, tyre pressure restora-
tion etc…
IMPORTANTThe Scheduled Ser-
vicing Coupons are prescribed by the
Manufacturer. The failure in the exe-
cution of the coupons can cause the
cancellation of the warranty.
The service of Scheduled Servicing is
performed by all
Fiat Dealership,
with prefixed times.
If performing each intervention, in
addition to the prescribed operations,
the necessity of further replacements
or repairs occurs, these latter can be
performed only with the explicit
agreement of the Customer.
IMPORTANT We suggest you to
immediately signal to
Fiat Dealer-
ship
possible small operational non
conformities, without waiting for the
next coupon execution.
104-127 03/03/2003 06:53 PM Page 105

109
IMPORTANT - Air cleaner
Using the car on dusty roads, replace
the air cleaner more frequently than
indicated in the Scheduled Servicing
Plan.
For any doubt on the air cleaner re-
placement, in relation to how the car
is used, contact the
Fiat Dealership.
The maintenance of the
car must be committed
to Fiat Dealership. For
those interventions of ordinary
and small maintenance, always
make sure to have the adequate
equipment, Fiat spare parts and
the consumption fluids; in any
event, do not perform such op-
erations, if you do not have any
experience. IMPORTANT - Fuel filter
Check the conditions of the fuel fil-
ter when changes (choking) are no-
ticed in the engine operation.
IMPORTANT - Battery
We suggest you to carry out the
check of the state of battery charge,
preferably at the beginning of the cold
season in order to avoid the possibil-
ity of freezing the electrolyte.
Such check must be carried out
more frequently if the car is mainly
used for short distances, or if it is
equipped with permanent absorption
users with disconnected key, above all
if applied in after market.
Please refer page no. 52 of 24
hours service assistance booklet
for BAT MOBILE service extend-
ed by M/s. Exide Batteries.You should check the battery fluid
(electrolyte) level more frequently
than shown in the service schedulein
this chapter if the car is used in hot cli-
mates or particularly demanding con-
ditions.
24 HOURS SERVICE
CALL - 9628 290 260
This single response num-
ber is available in 9 cities.*
AHMEDABAD - BANGALORE -
KOLKATA - CHENNAI - DELHI -
HYDERABAD - MUMBAI -
PUNE - LUCKNOW
* If you are not in, but near any of the above
cities; Dial city code followed by the single
response numberFor further information about Fiat Service Network please refer 24 Hours Service
AssistanceBooklet provided.
104-127 03/03/2003 06:53 PM Page 109

146
Main beam headlights
- control ..................................... 13-41
- flashing...................................... 13-42
- bulb replacement ................... 88
Maintenance
- Additional interventions ..... 108
- servicing schedule.................. 105
- servicing schedule plan......... 106
Max speeds ................................... 138
Paintwork identification
plate ............................................ 130
Paintwork
- maintenance .......................... 126
- Identification plate ............... 130
Parking ........................................... 67
Passenger compartment air vents 38
Performances ................................ 138
Periodic checks and before
long distances........................... 78
Plate light ...................................... 92
Power steering fluid level ......... 114
Pretensioners ................................ 32
Protecting emission control
devices ....................................... 74Protecting the environment ..... 63
Raising the car .......................... 99
Ready to start ............................... 8
Rear mirror
- rear view mirrors .................. 14-24
- driving mirror ......................... 23
Rear window washer
- control ..................................... 13-43
- fluid level ................................ 114
Rear window wiper
- controls.................................... 13-43
- blades ...................................... 127
- sprayer ..................................... 124
Rev counter................................... 34
Reversing lights
(bulb replacement) ................. 90
Roof rack ....................................... 55
Safe driving
- travelling ................................. 70
- driving with ABS ................... 73
- driving in rain.......................... 71
- driving at night ...................... 71
- driving in the mountains ...... 72- driving in fog ........................... 71
- driving on snow and ice .... 72
- before driving ........................ 69
Seat belts ........................................ 12-24
- general warnings .................... 27
- use ..................................... 12-24-26
- maintenance .......................... 28
- adjusting the height of the
seat belts ................................ 12-25
Seats
- cleaning .................................... 127
- adjustments ............................. 11-22
Side/tail lights
- control .................................... 13-41
- front bulb replacement ...... 89
- rear bulb replacement.......... 90
Side/tail lights
- control ..................................... 13-42
- front bulb replacement ...... 89
- side bulb replacement ......... 89
- rear bulb replacement.......... 90
Snow chains ................................. 77
Sound system ............................... 60
- aerial ......................................... 62
- standard equipment .............. 61
144-152 03/03/2003 07:30 PM Page 146