2003 FIAT PALIO check oil

69
Water, ice or salt sprin-
kled on the road can de-
posit on the brake discs
and reduce efficiency of the first
braking.
Consider that fitting ex-
tra spoilers, alloy rims or
non standard wheel caps
can reduce ventilation of the
brakes and reduce their efficien-
cy under conditions of violent or
repeated braking or long down-
hill travel.
BEFORE GETTING BEHIND
THE WHEEL
– Make sure all lights including the
headlights are working properly.
– Adjust the position of the seats, the
steering wheel and the rearview mir-
rors properly for the best driving po-
sition.
– Carefully adjust the head restraints
so the back of the head and not the
nape of the neck is supported.
– Make sure that nothing (mats etc.)
gets in the way of the pedals when
they are pushed down.
– Do not drive using the clutch ped-
al as a foot rest. Such behaviour can
cause a premature wear of the clutch.
– Make sure that any child restraint
systems (child seats, carriers, etc.) are
properly fixed preferably on the back
seat. Follow the precautions listed in
the “Transporting children in safety”
paragraph in the “Getting to know the
car” chapter.
– Arrange the load in the boot in such
a way that it cannot be thrown for-
wards in the event of an accident.– Do not place clear objects or
sheets of paper on the dashboard that
reflect on the windscreen.
– Do not eat a heavy meal before
travelling. Light eating will help keep
your reflexes prompt. Above all, do
not have anything alcoholic to drink.
The use of some medicines can reduce
the driving capability: carefully read the
relevant use warnings.
Remember to periodically carry out
the checks specified in the “Repeated
checks before long trips” paragraph
given in this section.
64-79 03/03/2003 06:45 PM Page 69

78
RECURRENT
CHECKS AND
BEFORE LONG
DISTANCE TRIPS
Periodically, remember to check:
– tyre pressure and conditions
– level of battery fluid
– engine oil level
– coolant level and conditions of the
system
– brake fluid level
– windscreen washer liquid level
– power steering fluid level.
STORING THE
CAR
The following precautions should be
taken if the car will not be used for
more than a month:
– Park the car in covered, dry and if
possible well-ventilated premises.
– Engage a gear.
– Make sure the handbrake is not en-
gaged.
– Remove the cables from the bat-
tery terminals (first remove the cable
to the negative terminal), and check
the battery charge. If the car is to be
stored for long periods the battery
charge should be checked every
month and recharged if it falls below
12,5V.
– Clean and protect the painted parts
using protective wax.– Clean and protect the shiny metal
parts using special compounds readi-
ly available.
– Sprinkle talcum powder on the
rubber windscreen and rear window
wiper blades and lift them off the glass.
– Slightly open the windows.
– Cover the car with a cloth or per-
forated plastic sheet. Do not use
sheets of no-perforated plastic as they
do not allow moisture on the car body
to evaporate.
– Inflate the tyres to +0.5 bar above
the normal specified pressure and
check it at intervals.
– Do not drain the engine cooling
system.
64-79 03/03/2003 06:45 PM Page 78

107
Thousands of Kilometers 15 3045 6075 90105 120135 150165 180









(*) or every 3 years if the car is used in the following harsh conditions:
- Prolonged use in cold/hot climates, sity driving with prolonged lengths of time at idle speed, driving on dusty roads or roads covered with sand/salt.
- or every 5 years regardless of km covered and use conditions.
NOTE: For every 7,500 km service please refer Owner’s Warranty & Service Policy book.
For every 7,500 km or 6 months (whichever is erlier from previous service) replace engine oil and oil filter.
Top up fluids (engine coolant, brakes, power steering, windscreen washer etc.)
Timing command toothed belt check
Timing command toothed belt replacement
Spark plugs replacement, wire control (*)
Engine control system functionality check
(through autodiagnostic socket)
Change gear/differential gear oil level check
Changing engine oil (every 7,500 km or 6 months)
Replace engine oil filter (every 7,500 km or 6 months)
Brake fluid replacement (or every 24 months)
104-127 03/03/2003 06:53 PM Page 107

108
ADDITIONAL
INTERVENTIONS
Every 1000 kmor prior to long
travels, check and possibly restore:
– engine coolant level
– brake - clutch fluid level
– Power steering fluid level
– battery fluid level
– windscreen washer fluid level
– pressure and condition of the tyres.
Every 3000 kmcheck and top up
as necessary: engine oil level.We suggest the use of
FL Group
product expressly recommended,
studied and realized for Fiat cars (see
the “Refuelling” table in the “Techni-
cal Specifications” chapter).
IMPORTANT - Engine oil
Replace the engine oil more fre-
quently than indicated in the Sched-
uled Servicing Plan, in the event that
the car is mainly used in one of the fol-
lowing particularly severe conditions:
– dusty, sandy or muddy roads;
– repeated and short distances (less
than 7-8 km) and with external tem-
perature less than zero;– with engine frequently idling or for
long distances at low speed (e.g. taxi,
door-to-door deliveries or for long
storage).
For any doubt on the engine oil re-
placement, in relation to how the car
is used, contact the
Fiat Dealership.
104-127 03/03/2003 06:53 PM Page 108

The jack, with which the
car is equipped, is pre-
scribed only when the
wheel must be replaced. For ex-
igencies different from this latter,
the lifting of the car must re-
spect particular modalities.
Therefore, we recommend you
to perform the operation at Fiat
Dealership.
110fig. 1 - Versions 1.2
P4E02275CHECKING
FLUID LEVELS
1.Engine oil - 2.Battery -3. Brake-
clutch fluid -
4.Windscreen/rear mir-
ror washer fluid -
5. Engine coolant -
6.Power steering fluid.
Pay attention, during
refilling operations, not to
confuse the different
types of fluids: they are all in-
compatible and the car could be
seriously damaged if there is
wrong usage.
Pay attention to scarves,
ties and clothes which are
not tight: they could get
entangled in the moving parts.Never smoke during the
interventions in the en-
gine compartment: flam-
mable gas and vapours could be
present, with the risk of a fire.
104-127 03/03/2003 06:53 PM Page 110

112
ENGINE OIL
Fig. 4
: versions 1.2
Fig. 5: versions 1.6
Fig. 6: versions 1.9 D
Check the oil level with the car
parked on level ground and with the
engine still hot (about 10 minutes af-
ter having stopped the engine).
The oil level must be between the
MINIMUMand MAXIMUMmarks
on the control dipstick. The space be-
tween
MINand MAXcorresponds
to roughly one litre of oil.
IMPORTANT Check the level and
replace the engine oil respecting the
frequency indicated in the “Scheduled
Servicing Plan” and “Additional Inter-
vention”.
If the oil level is close to or even be-
low the
MIN mark, add oil through
the filler hole until the level reaches
the
MAXmark. The oil level must
never exceed the
MAX line.
IMPORTANTAfter adding or
changing the oil, let the engine run for
a few seconds then wait a few minutes
after you have turned it off before
checking the level.
IMPORTANT If the level of the en-
gine oil, when checked, is found to be
over the
MAXmark, go to a Fiat
Dealership
to have it put right.
ENGINE OIL CONSUMPTION
When the car is new, the engine
needs to run in, therefore the engine
oil consumption can only be consid-
ered stabilised after the first 5000 -
6000 km.
IMPORTANTOil consumption
depends on the driving style and the
conditions of use.
fig. 5
P4E01435
fig. 4
P4E01477
fig. 6 - 1.9 D versions
P4E02327
104-127 03/03/2003 06:53 PM Page 112

113
ENGINE COOLANT TANK
Fig. 7
: Petrol versions
Fig. 8: Diesel versionsIf the level is low, pour a 70:30 mix-
ture of distilled water and
PARAFLU11produced by the FL
Group
slowly through the filler hole.
fig. 7 - petrol versions
P4E02290
Do not take the cap of
the reservoir off when the
engine is very hot as you
run the risk of scalding yourself.
The coolant level must be checked
while the engine is cold and must be
above the
MIN mark visible on the
reservoir.
Do not add oil with dif-
ferent specifications from
the oil already in the en-
gine.
Used engine oil an re-
placed oil filters contain
substances which can
harm the environment. We rec-
ommend you have the car seen
to at a Fiat Dealership for the oil
and filter change. It is suitably
equipped for disposing of used oil
and filters in an environmentally
-friendly way that complies with
the law.
When the engine is hot
be very careful under the
bonnet: you risk burning
yourself. Remember that when
the engine is hot, the fan may cut
in and cause injuries.
The cooling system is
under pressure. When
changing the cap, use on-
ly genuine spare parts to avoid
damaging the system.
fig. 8 - diesel versions
P4E02675
104-127 03/03/2003 06:53 PM Page 113

145
Dipped beam headlights
- control ..................................... 13-41
- bulb replacement ................. 88
Doors.............................................. 17-48
Electric system ........................... 137
Electric window winder ............ 15-49
Electronic central units ............. 120
Engine compartment .................. 16-54
Engine compartment
(washing) ................................... 127
Engine cooling fluid
thermometer ........................... 34
Engine cooling fluid level ............ 113
Engine oil consumption ............. 112
Engine oil level ............................. 112
Engine oil
- consumption .......................... 112
- checking the level ................. 112
Engine
- power supply/ignition ........... 132
- engine type code .................. 130
- characteristic data ................ 131
- engine compartment
washing ................................... 127
- lubrication ............................... 132- marking .................................... 129
- cooling ...................................... 132
Filling ............................................ 140
First-aid kit ................................... 103
Flashing ........................................... 13-42
Front foglights ............................... 56
Front foglights
- switch on/off button ............ 15-44
- bulb replacement ................. 90
Fuel filler cap ................................ 18-63
Fuel flap opening lever............... 18-63
Fuel flap
- opening lever ......................... 18-63
Fuel level indicator ..................... 33
Fuel lock switch .......................... 44
Fuel
- level indicator ........................ 33
- fuel lock switch ...................... 44
- fuel flap opening level ........... 18-63
Fuses................................................ 93
- replacement ............................ 93
Gearbox
- gearbox use ........................... 68
- transmission ........................... 133Getting to know the car ........... 20
Glove compartment .................... 45
Handbrake ............................... 67-134
Hazard lights ................................. 13-43
Head rest ....................................... 11-23
Headlight trim .............................. 56
Headlights (upward slant
compensation) ......................... 56
Heated rear window .................. 15-44
Heating ........................................... 39
Identification data ..................... 129
If an accident occurs ................... 102
Ignition device .............................. 21
In an emergency .......................... 80
Instrument panel ......................... 10
Interior lights ............................... 92
Interior equipment ..................... 45
Keys ............................................. 11-21
Kilometer counter ....................... 33
Level control ............................. 111
Lubricants(specifications) .......... 141
144-152 03/03/2003 07:30 PM Page 145