2003 DAEWOO MATIZ wiper

BODY AND ACCESSORIES
CONTENTS
SECTION 9A BODY WIRING SYSTEM
SECTION 9B LIGHTING SYSTEMS
SECTION 9C HORNS
SECTION 9D WIPERS / WASHER SYSTEMS
SECTION 9E INSTRUMENTATION / DRIVER INFORMATION
SECTION 9F AUDIO SYSTEMS
SECTION 9G INTERIOR TRIM
SECTION 9H SEATS
SECTION 9I WATERLEAKS
SECTION 9J WINDNOISE
SECTION 9K SQUEAKS AND RATTLES
SECTION 9L GLASS AND MIRRORS
SECTION 9M EXTERIOR TRIM
SECTION 9N FRAME AND UNDERBODY
SECTION 9O BUMPERS AND FASCIAS
SECTION 9P DOORS
SECTION 9Q ROOF
SECTION 9R BODY FRONT END
SECTION 9S BODY REAR END
SECTION 9T IMMOBILIZER ANTI–THEFT SYSTEM

GENERAL ENGINE INFORMATION 1A–3
DAEWOO M-150 BL2
COMPONENT LOCATOR
ENGINE COMPARTMENT (TYPICAL)
(Left–Hand Drive Shown, Right–Hand Drive Similar)
D102A401
1 Power Steering Oil Reservoir
2 Coolant Reservoir
3 Canister
4 Canister Solenoid
5 Manifold Absolute Pressure (MAP) Sensor
6 Intake Manifold
7 Ignition Coil
8 Idle Air Control (IAC) Valve
9 Throttle Position (TP) Sensor
10 Throttle Body
11 Brake Fluid Reservoir
12 Wiper Motor13 Battery
14 Fuse Box
15 Air Cleaner Housing
16 Resonator
17 PCV Hose
18 Distributor
19 Exhaust Manifold
20 Snorkel
21 Engine
22 Washer Fluid Reservoir
23 Oil Level Gauge
24 Oil Filler Cap

1A–4 GENERAL ENGINE INFORMATION
DAEWOO M-150 BL2
ENGINE COMPARTMENT (EURO III)
(Left–Hand Drive Shown, Right–Hand Drive Similar)
MAA1A010
1 Power Steering Oil Reservoir
2 Coolant Reservoir
3 Canister Purge Solenoid
4 Manifold Absolute Pressure (MAP) Sensor
5 Intake Manifold
6 Throttle Position (TP) Sensor
7 Throttle Body
8 Idle Air Control (IAC) Valve
9 Brake Fluid Reservoir
10 Wiper Motor11 Battery
12 Fuse Box
13 Air Cleaner Housing
14 Resonator
15 Electronic Ignition System Ignition Coil
16 Exhaust Manifold
17 Snorkel
18 Engine
20 Washer Fluid Reservoir
19 Oil Level Gauge
21 Oil Filler Cap

DAEWOO M-150 BL2
SECTION 6E
STEERING WHEEL AND COLUMN
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 6E-2. . . . . . . . . . . . . . . . . .
Steering Wheel and Column 6E-2. . . . . . . . . . . . . . . .
Component Locator 6E-3. . . . . . . . . . . . . . . . . . . . . . . .
Steering Wheel and Column 6E-3. . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 6E-4. . . . .
Steering Column Diagnosis 6E-4. . . . . . . . . . . . . . . . .
Repair Instructions 6E-7. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 6E-7. . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Wheel 6E-7. . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Column Cover 6E-8. . . . . . . . . . . . . . . . . . . .
Turn Signal Switch and Lever/
Wiper Switch and Lever 6E-8. . . . . . . . . . . . . . . . . .
Ignition Switch 6E-9. . . . . . . . . . . . . . . . . . . . . . . . . . . . Ignition Lock Cylinder and Switch
with Immobilizer 6E-9. . . . . . . . . . . . . . . . . . . . . . . . .
Switch Housing 6E-10. . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Column 6E-11. . . . . . . . . . . . . . . . . . . . . . . . .
Intermediate Shaft cover and
Intermediate Shaft 6E-12. . . . . . . . . . . . . . . . . . . . . .
Unit Repair 6E-13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Standard Steering Column 6E-13. . . . . . . . . . . . . . . . .
Specifications 6E-15. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 6E-15. . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 6E-15. . . . . . . . . .
Special Tools and Equipment 6E-16. . . . . . . . . . . . . .
Special Tools Table 6E-16. . . . . . . . . . . . . . . . . . . . . . .

6E – 2 STEERING WHEEL AND COLUMN
DAEWOO M-150 BL2
DESCRIPTION AND OPERATION
STEERING WHEEL AND COLUMN
In addition to the steering function, the steering column
provides safety and security.
Caution: To ensure energy-absorbing action, it is
important to use only the specified screws, bolts,
and nuts, tightened to the specified torque.
The energy-absorbing column is designed to compress
in a front-end collision to lessen the chance of driver in-
jury.
The ignition switch and the lock are mounted on the col-
umn, allowing the ignition and steering operations to be
locked to inhibit theft of the car.
The column levers trigger the turn signals, the headlight
beams, and the windshield washer and wipers.
Notice: Apply a thin coat of lithium grease to all friction
points when reassembling to ensure proper operation.
The column may be easily disassembled and assembled.
D15A001A

Safety Device
A. Steering Column Upper Bracket.
B. Steering Column.
C. Steering Column Shaft.

STEERING WHEEL AND COLUMN 6E–3
DAEWOO M-150 BL2
COMPONENT LOCATOR
STEERING WHEEL AND COLUMN
D15A401A
1. Horn Cover (Airbag Module)
2. Steering Wheel Nut
3. Locking Plate
4. Steering Wheel
5. Steering Column Upper Cover
6. Steering Column Lower Cover
7. Turn Signal Switch
8. Windshield Wiper Switch
9. Steering Column Assembly
10. Retaining Ring
11. Washer
12. Spring
13. Switch Housing
14. Bolt15. Support Bolt
16. Steering Column Housing
17. Steering Column Jacket
18. Ignition Switch Retaining Screw
19. Ignition Switch
20. Steering Lock Housing Assembly
21. Steering Column Shaft
22. Pinch Bolt
23. Intermediate Shaft
24. Steering Column Upper Nut
25. Steering Column Lower Nut

6E –6 STEERING WHEEL AND COLUMN
DAEWOO M-150 BL2
Ignition Switch
ConditionProbable CauseCorrection
Electrical System Will
Damaged ignition switch.
Replace the ignition switch.
Not Function
Improperly installed ignition switch.
Remove and inspect the ignition
switch.

Reinstall the ignition switch.

Improperly installed ignition switch electrical
connector.
Reconnect the ignition switch
electrical connector.

Replace the ignition switch electrical
connector.
Ignition Switch Will
Damaged ignition switch.
Replace the ignition switch.
Not Turn
Improperly installed ignition switch.
Remove and inspect the ignition
switch.

Reinstall the ignition switch.
Wiper Switch Lever
ConditionProbable CauseCorrection
Switch Inoperative :
Damaged wiper switch.
Replace the wiper switch.
No I, Low, High, Int
or Wash
Improperly installed wiper switch.
Remove and inspect the wiper
switch.

Reinstall the wiper switch.

6E –8 STEERING WHEEL AND COLUMN
DAEWOO M-150 BL2
D105A504
STEERING COLUMN COVER
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Removal Procedure
1. Remove the screws.
2. Remove the steering column lower and upper cover.
D105A505
Installation Procedure
1. Install the steering column lower and upper cover with
the screws.
D105A506
TURN SIGNAL SWITCH AND LEVER/
WIPER SWITCH AND LEVER
(Left–Hand Drive Shown, Right–Hand
Drive Similar)
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the steering column cover. Refer to “Steer-
ing Column Cover” in this section.
3. Remove the turn signal switch.

Disconnect the turn signal switch by pushing the
locking from the switch housing (1).

Disconnect the connector (2).
D105A507
4. Remove the wiper switch.

Disconnect the wiper switch by pushing the locking
from the switch housing (1).

Disconnect the connector (2).