2003 CHEVROLET SSR coolant level

How to Add Coolant to the Coolant
Surge Tank
If you have not found a problem yet, but the coolant
level is not at the FULL COLD mark, add a 50/50
mixture ofclean drinkable waterand DEX-COOL
®
engine coolant at the coolant recovery tank. See
Engine Coolant on page 5-24for more information.
{CAUTION:
Adding only plain water to your cooling
system can be dangerous. Plain water, or
some other liquid such as alcohol, can boil
before the proper coolant mixture will. Your
vehicle’s coolant warning system is set for the
proper coolant mixture. With plain water or the
wrong mixture, your engine could get too hot
but you would not get the overheat warning.
Your engine could catch re and you or others
could be burned. Use a 50/50 mixture of clean,
drinkable water and DEX-COOL
®coolant.Notice:In cold weather, water can freeze and crack
the engine, radiator, heater core and other parts.
Use the recommended coolant and the proper
coolant mixture.
{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol
and it will burn if the engine parts are hot
enough. Do not spill coolant on a hot engine.
When the coolant in the coolant surge tank is at the
FULL COLD mark, start your vehicle.
5-30

90,000 Miles (150 000 km)
❑Change automatic transmission uid and lter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
❑Check rear axle uid level and add uid as needed.
❑Replace fuel lter.An Emission Control Service.
(See Footnote †.)
❑Replace engine air cleaner lter. SeeEngine Air
Cleaner/Filter on page 5-20for more information.
An Emission Control Service.
97,500 Miles (162 500 km)
❑Check rear axle uid level and add uid as needed.
100,000 Miles (166 000 km)
❑Inspect spark plug wires.An Emission Control
Service.
❑Replace spark plugs.An Emission Control Service.
150,000 Miles (240 000 km)
❑Drain, ush and rell cooling system (or every
60 months since last service, whichever occurs rst).
SeeEngine Coolant on page 5-24for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.An Emission Control Service.
❑Inspect engine accessory drive belt.An Emission
Control Service.
6-8

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specied
to help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any uids or lubricants are added to your
vehicle, make sure they are the proper ones, as
shown in Part D.
At Each Fuel Fill
It is important for you or a service station attendant
to perform these underhood checks at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-14for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL®
coolant mixture if necessary. SeeEngine Coolant
on page 5-24for further details.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in the windshield
washer tank and add the proper uid if necessary.
SeeWindshield Washer Fluid on page 5-32for further
details.
At Least Once a Month
Tire Inspection and Ination Check
Visually inspect your tires for wear and make sure
tires are inated to the correct pressures. SeeTires
on page 5-51for further details.
At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety
belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
6-9

Certication/Tire Label.....................................4-35
Chains, Tire...................................................5-64
Change Trans (Transmission) Fluid....................3-46
Charging System Light....................................3-27
Check
Engine Light...............................................3-30
Gages Warning Light...................................3-36
Check Engine Light.........................................3-30
Check Oil Level..............................................3-46
Checking Brake Fluid......................................5-34
Checking Coolant............................................5-26
Checking Engine Oil........................................5-14
Checking the Automatic Transmission
Fluid Level.................................................5-23
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-78
Child Restraints
Child Restraint Systems...............................1-25
Infants and Young Children...........................1-22
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-31
Older Children.............................................1-20
Securing a Child Restraint Designed for the
LATCH System........................................1-33Child Restraints (cont.)
Securing a Child Restraint in the Passenger
Seat Position...........................................1-36
Top Strap...................................................1-29
Top Strap Anchor Location............................1-31
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-73
Outside of Your Vehicle................................5-75
Underbody Maintenance...............................5-78
Weatherstrips..............................................5-75
Cleaning Aluminum Wheels..............................5-77
Cleaning Exterior Lamps/Lenses.......................5-76
Cleaning Fabric/Carpet....................................5-73
Cleaning Glass Surfaces..................................5-75
Cleaning Interior Plastic Components.................5-75
Cleaning Leather............................................5-74
Cleaning the Top of the Instrument Panel...........5-75
Cleaning the Windshield and Wiper Blades.........5-77
Cleaning Tires................................................5-78
Cleaning Vinyl................................................5-74
Climate Control System...................................3-18
Outlet Adjustment........................................3-21
Content Theft-Deterrent....................................2-12
3

Driving On Grades..........................................4-47
Driving on Snow or Ice....................................4-26
Driving Through Deep Standing Water...............4-19
Driving Through Flowing Water.........................4-19
Driving with a Trailer.......................................4-46
E
Electrical System
Add-On Equipment......................................5-81
Fuses and Circuit Breakers...........................5-82
Headlamps.................................................5-81
Power Windows and Other Power Options......5-81
Windshield Wiper Fuses...............................5-81
Emergency Cargo Cover Release Handle...........2-34
Emissions Inspection and Maintenance
Programs...................................................3-33
Engine
Air Cleaner/Filter.........................................5-20
Battery.......................................................5-36
Change Engine Oil Light...............................3-35
Check and Service Engine Soon Light............3-30
Compartment Overview................................5-12
Coolant......................................................5-24
Coolant Temperature Gage...........................3-30
Cooling System Inspection............................6-14
Cover........................................................5-19
Exhaust.....................................................2-22
Oil .............................................................5-14Engine (cont.)
Overheating................................................5-27
Reduced Power Light...................................3-36
Starting......................................................2-16
Engine Compartment Fuse Block......................5-85
Engine Coolant Hot Idle Engine........................3-46
Engine Coolant Level Check.............................. 6-9
Engine Cover Insert........................................5-19
Engine Oil Additives........................................5-17
Engine Oil Level Check..................................... 6-9
Engine Oil Scheduled Maintenance..................... 6-5
Engine Overheated Stop Engine.......................3-47
Erasing HomeLink
®Buttons..............................2-30
Exit Lighting...................................................3-14
Express Down Window....................................2-11
Extender, Safety Belt.......................................1-19
Exterior Lamps...............................................3-11
F
Fan Knob......................................................3-19
Filter
Engine Air Cleaner......................................5-20
Finding a Program Type (PTY) Station.......3-63, 3-72
Finding a Station....................................3-60, 3-69
Finish Care....................................................5-76
Finish Damage...............................................5-78
Flash-to-Pass................................................... 3-6
Flat Tire........................................................5-65
5

Flip Hall Switch Fault......................................3-47
Fluid
Automatic Transmission................................5-21
Power Steering...........................................5-31
Windshield Washer......................................5-32
FM ...............................................................3-81
Fog Lamps....................................................3-13
Following Distance..........................................4-46
Footnotes........................................................ 6-5
Front Map Lamps...........................................3-15
Front Turn and Parking Lamps.........................5-44
Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-37
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-6
System Inspection.......................................6-13
Fuel Information..............................................3-43Fuel Level Low...............................................3-47
Fuses
Fuses and Circuit Breakers...........................5-82
Windshield Wiper.........................................5-81
G
Gage
Check Gages Warning Light..........................3-36
Engine Coolant Temperature.........................3-30
Fuel..........................................................3-37
Oil Pressure...............................................3-34
Speedometer..............................................3-24
Tachometer.................................................3-24
Gage, Auxiliary Package..................................3-38
Garage Door Opener.......................................2-26
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Gate Operator and Canadian Programming........2-29
Glove Box.....................................................2-31
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
6