2003 CHEVROLET S10 coolant

qReplace fuel ®lter.An Emission Control Service.
(See footnote ².)
qReplace engine air cleaner ®lter. SeeEngine Air
Cleaner/Filter on page 5-19for more information.An Emission Control Service.
qRotate tires. SeeTire Inspection and Rotation on
page 5-64for proper rotation pattern and additional
information.(See footnote +.)
97,500 Miles (162 500 km)
qChange engine oil and ®lter (or every 12 months,
whichever occurs ®rst).An Emission Control
Service.
qLubricate chassis components (or every 12 months,
whichever occurs ®rst).(See footnote #.)
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
(See footnote **.)
qRotate tires. SeeTire Inspection and Rotation on
page 5-64for proper rotation pattern and additional
information.(See footnote +.)
100,000 Miles (166 000 km)
qInspect spark plug wires.An Emission Control
Service.
qReplace spark plugs.An Emission Control Service.
qIf you haven't used your vehicle under severe service
conditions listed previously and, therefore, haven't
changed your automatic transmission ¯uid, change
both the ¯uid and ®lter. Manual transmission
¯uid doesn't require change.
q4.3L V6 Engine Only: Inspect Positive Crankcase
Ventilation (PCV) valve.
An Emission Control
Service.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll cooling system (or every
60 months since last service, whichever occurs ®rst).
See
Engine Coolant on page 5-27for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-25

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals speci®ed to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any ¯uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel ®ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-15for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOLž
coolant mixture if necessary. SeeEngine Coolant
on page 5-27for further details.
Windshield Washer Fluid Level Check
Check the windshield washer ¯uid level in the windshield
washer tank and add the proper ¯uid if necessary.
See
Windshield Washer Fluid on page 5-40for further
details.
At Least Once a Month
Tire In¯ation Check
Visually inspect your tires and make sure tires are
in¯ated to the correct pressures. Don't forget to check
your spare tire. See
Tires on page 5-62for further
details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-40for further details.
6-26

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engine Oil on
page 5-15.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
ž
Coolant. SeeEngine Coolant on
page 5-27.
Hydraulic Brake
SystemDelco Supreme 11žBrake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part
No. U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brake ¯uid).
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Usage Fluid/Lubricant
Manual
Transmission
with V6 EngineSynchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465, or equivalent).
Manual
Transmission
with L4 EngineFriction Modi®ed Synchromesh
Transmission Fluid (GM Part
No. U.S. 12377916, in Canada
10953509).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
ž
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part
No. U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Wheel
BearingsWheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037, or
equivalent).
Front and Rear
Axle (Standard
Differential)SAE 80W-90 Axle Lubricant (GM
Part No. U.S. 1052271, in Canada
10950849, or equivalent).
Rear Axle
(Locking
Differential)Axle Lubricant; use only GM Part
No. U.S. 1052271, in Canada
10950849.
Do not add friction
modi®er.
6-33

Chains, Tires..................................................5-70
Charging System Light....................................3-29
Checking Brake Fluid......................................5-43
Checking Coolant............................................5-28
Checking Engine Oil........................................5-15
Checking the Fluid Level..................................5-23
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-65
Check...........................................................3-33
Engine Light...............................................3-33
Gages Warning Light...................................3-38
Chemical Paint Spotting...................................5-90
Child Restraints..............................................1-36
Child Restraint Systems...............................1-36
Infants and Young Children...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-44
Older Children.............................................1-30
Securing a Child Restraint Designed for the
LATCH System........................................1-46
Securing a Child Restraint in a Center Seat
Position..................................................1-49
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-46
Securing a Child Restraint in the Right Front
Seat Position...........................................1-49
Top Strap Anchor Location............................1-43
Top Strap...................................................1-41
Where to Put the Restraint...................1-39, 1-40
Cigarette Lighter.............................................3-18Cleaning Aluminum Wheels..............................5-89
Cleaning Exterior Lamps/Lenses.......................5-87
Cleaning Fabric/Carpet....................................5-84
Cleaning Glass Surfaces..................................5-86
Cleaning Interior Plastic Components.................5-86
Cleaning Leather............................................5-85
Cleaning the Mirror.........................................2-39
Cleaning the Photocells...................................2-39
Cleaning the Top of the Instrument Panel...........5-86
Cleaning the Windshield and Wiper Blades.........5-88
Cleaning Tires................................................5-89
Cleaning Vinyl................................................5-85
Cleaning Wood Panels....................................5-86
Cleaning........................................................5-84
Inside of Your Vehicle..................................5-84
Outside of Your Vehicle................................5-87
Underbody Maintenance...............................5-90
Weatherstrips..............................................5-87
Climate Control System...................................3-18
Outlet Adjustment........................................3-21
Clutch, Hydraulic.............................................5-26
Compact Disc Messages.................3-52, 3-62, 3-73
Compact Spare Tire........................................5-83
Content Theft-Deferrent....................................2-17
Control of a Vehicle.......................................... 4-6
Coolant.........................................................3-32
Engine Temperature Gage............................3-32
Heater, Engine............................................2-24
Cooling System..............................................5-32
Cooling.........................................................3-19
3

E
Electrical System............................................5-93
Add-On Equipment......................................5-93
Fuses and Circuit Breakers...........................5-93
Headlamps.................................................5-93
Power Windows and Other Power Options......5-93
Windshield Wiper Fuses...............................5-93
Electronic Transfer Case..................................2-30
Emissions Inspection and Maintenance
Programs...................................................3-35
Engine Compartment Fuse Block......................5-96
Engine Coolant Level Check.............................6-26
Engine Oil Additives........................................5-18
Engine Oil Level Check...................................6-26
Engine..........................................................5-19
Air Cleaner/Filter.........................................5-19
Battery.......................................................5-45
Check and Service Engine Soon Light............3-33
Compartment Overview................................5-12
Coolant Heater............................................2-24
Coolant Temperature Gage...........................3-32
Coolant......................................................5-27
Cooling System Inspection............................6-32
Exhaust.....................................................2-37
Fan Noise..................................................5-39
Oil .............................................................5-15
Overheating................................................5-30
Starting......................................................2-22
Entry Lighting.................................................3-15Environmental Concerns..................................4-16
Exit Lighting...................................................3-16
Express Down Window....................................2-15
Extended Cab (Jump Seat)..............................1-48
Extender, Safety Belt.......................................1-29
Exterior Lamps...............................................3-12
F
Filter.............................................................5-19
Engine Air Cleaner......................................5-19
Finding a PTY Station.....................3-48, 3-56, 3-66
Finding a Station....................3-42, 3-45, 3-53, 3-63
Finish Care....................................................5-88
Finish Damage...............................................5-89
Five-Speed....................................................2-28
Fixed Mast Antenna........................................3-76
Flash-To-Pass Feature....................................... 3-7
Flat Tire, Changing.........................................5-72
Flat Tire........................................................5-71
Fluid.............................................................5-22
Automatic Transmission................................5-22
Manual Transmission....................................5-25
Power Steering...........................................5-39
Windshield Washer......................................5-40
FM ...............................................................3-74
Fog Lamps....................................................3-15
Following Distance..........................................4-61
Four-Wheel Drive....................................2-29, 5-52
5

Front Axle......................................................5-53
Front Map Lamps...........................................3-16
Front Storage Area.........................................2-48
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-38
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
Low Warning Light.......................................3-39
System Inspection.......................................6-32
Fuses...........................................................5-93
Fuses and Circuit Breakers...........................5-93
Windshield Wiper.........................................5-93
G
Gage............................................................3-38
Check Gages Warning Light..........................3-38
Engine Coolant Temperature.........................3-32
Fuel..........................................................3-38
Oil Pressure...............................................3-36
Speedometer..............................................3-25
Tachometer.................................................3-26
Voltmeter Gage...........................................3-30Gage (cont.)
Garment Hooks..............................................2-49
Gasoline......................................................... 5-4
Octane........................................................ 5-4
Speci®cations............................................... 5-5
Getting Familiar with Off-Road Driving................4-17
Glove Box.....................................................2-41
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-7
Headlamp High/Low-Beam Changer.................... 3-7
Headlamps....................................................5-54
Bulb Replacement.......................................5-54
Electrical System.........................................5-93
Halogen Bulbs............................................5-54
One-Piece Front Turn Signal Lamps...............5-56
Two-Piece Front Turn Signal Lamps...............5-57
Heated Seats................................................... 1-5
Heating.........................................................3-19
Highway Hypnosis...........................................4-36
Hill and Mountain Roads..................................4-36
Hitches..........................................................4-59
Hood............................................................5-10
Checking Things Under................................5-10
6

Hood (cont.)
Release.....................................................5-10
Horn............................................................... 3-5
How to Add Coolant to the Coolant
Recovery Tank............................................5-34
How to Add Coolant to the Radiator..................5-36
How to Add Fluid....................................5-24, 5-26
How to Check and Add Fluid............................5-27
How to Check Lubricant..........................5-51, 5-53
How to Check Power Steering Fluid..................5-40
How to Check................................5-22, 5-25, 5-63
How to Inspect the Engine Air Cleaner/Filter.......5-21
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-16
Hydraulic Clutch System Check........................6-28
Hydraulic Clutch.............................................5-26
Hydroplaning..................................................4-32
I
If No Steam Is Coming From Your Engine..........5-31
If Steam Is Coming From Your Engine...............5-30
If the Light Is Flashing.....................................3-34
If the Light Is On Steady.................................3-34
If You Are Stuck in Sand, Mud, Ice or Snow.......4-42
If You Do Decide To Pull A Trailer.....................4-55
If You're Caught in a Blizzard...........................4-40Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-30
Infants and Young Children, Restraints...............1-32
In¯ation -- Tire Pressure..................................5-63
Inspection......................................................6-32
Brake System.............................................6-32
Engine Cooling System................................6-32
Exhaust System..........................................6-31
Fuel System...............................................6-32
Part C - Periodic Maintenance.......................6-31
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-31
Throttle System...........................................6-32
Transfer Case and Front Axle (Four-Wheel
Drive).....................................................6-32
Installing a Garage Door Opener.......................2-42
Instrument Panel Brightness.............................3-15
Instrument Panel Fuse Block............................5-94
Instrument Panel.............................................3-23
Cluster.......................................................3-23
Overview..................................................... 3-2
Interior Lamps................................................3-15
J
Jump Seat.....................................................1-10
Jump Starting.................................................5-46
7

T
Tachometer....................................................3-26
Tailgate Lubrication Service..............................6-28
Tailgate.........................................................2-13
Taillamps.......................................................5-59
Temperature and Compass Display....................2-44
Testing the Alarm............................................2-18
Theft-Deterrent, Radio.....................................3-74
Theft-Deterrent Systems...................................2-17
Content Theft-Deterrent................................2-17
Passlock
ž...................................................2-19
Third Door.....................................................2-12
Throttle System Inspection...............................6-32
Tilt Wheel........................................................ 3-5
Time Delay....................................................2-39
Tire In¯ation Check.........................................6-26
Tires.............................................................5-62
Buying New Tires........................................5-66
Chains.......................................................5-70
Changing a Flat Tire....................................5-72
Compact Spare Tire.....................................5-83
If a Tire Goes Flat.......................................5-71
In¯ation -- Tire Pressure...............................5-63
Inspection and Rotation................................5-64
Uniform Tire Quality Grading.........................5-67
Wheel Alignment and Tire Balance.................5-68
Wheel Replacement.....................................5-68
When It Is Time for New Tires......................5-65Tires (cont.)
To Use the Engine Coolant Heater....................2-24
Top Strap Anchor Location...............................1-43
Top Strap......................................................1-41
Torque Lock...................................................2-35
Total Weight on Your Vehicle's Tires..................4-58
Towing..........................................................4-44
Recreational Vehicle.....................................4-44
Towing a Trailer..........................................4-54
Your Vehicle...............................................4-44
Trailer Brakes.................................................4-60
Trailer...........................................................4-53
Recommendations.......................................4-53
Transfer Case and Front Axle (Four-Wheel Drive)
Inspection...................................................6-32
Transfer Case................................................5-52
Transmission Operation, Automatic....................2-25
Transmission Operation, Manual........................2-28
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-10
Transmission..................................................5-22
Fluid, Automatic...........................................5-22
Fluid, Manual..............................................5-25
Up-Shift Light..............................................3-30
Transportation Options...................................... 7-8
Traveling to Remote Areas...............................4-16
Trip Odometer................................................3-25
Truck-Camper Loading Information....................4-51
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
14