2003 CHEVROLET MALIBU trunk

6. Carefully remove the backplate by gently pulling up
on the two upper and two lower tabs.
7. Gently wiggle the bulb to remove it from the socket.
Replace the bulb.
8. Reverse the steps to reassemble the backplate and
attach the taillamp assembly to the vehicle. Make
sure that all four tabs of the backplate are securely
fastened to the taillamp assembly before reinstalling
it on the vehicle.
9. When securing the lamp assembly back into place,
align the assembly so that the trunk lid doesn't
contact it.
10. Close the trunk.
Replacement Bulbs
Exterior Lamp Bulb Number
Back-Up/Rear Turn 3156
Center High-Mounted Stoplamp
(Interior Mounted)912
Front Parking/Turn 3157A or 3157NA
Front Sidemarker 24
High-Beam Headlamp 9005
Low-Beam Headlamp 9006
Tail/Stoplamp 3057
For any bulb not listed here, contact your dealer.
5-47

Removing the Spare Tire and Tools
The equipment you'll need is in the trunk.
1. Turn the center retainer
nut on the compact
spare tire cover
counterclockwise to
remove it.
2. Lift and remove the cover.
You will ®nd the jacking instructions label on the
underside of the tire cover.3. Turn the wing nut
counterclockwise and
remove it. Then lift
off the adapter
and remove the
compact spare tire.
See
Compact Spare
Tire on page 5-66
for more information
about the compact
spare tire.
4. Remove the jack and wrench from the trunk. Your
vehicle's jack and wrench are stored in a foam tray.
5-58

11. Tighten the wheel nuts
®rmly in a crisscross
sequence, as shown.
{CAUTION:
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to come loose
and even come off. This could lead to an
accident. Be sure to use the correct wheel
nuts. If you have to replace them, be sure to
get new GM original equipment wheel nuts.
Stop somewhere as soon as you can and have
the nuts tightened with a torque wrench to the
proper torque speci®cation. See ªCapacities
and Speci®cationsº in the Index for wheel nut
torque speci®cation.
Notice:Improperly tightened wheel nuts can lead
to brake pulsation and rotor damage. To avoid
expensive brake repairs, evenly tighten the wheel
nuts in the proper sequence and to the proper
torque speci®cation. See ªCapacities and
Speci®cationsº in the index for the wheel nut torque
speci®cation.
Don't try to put a wheel cover on your compact spare
tire. It won't ®t. Store the wheel cover and wheel
nut caps in the trunk until you have the ¯at tire repaired
or replaced.
Notice:Wheel covers won't ®t on your compact
spare. If you try to put a wheel cover on your
compact spare, you could damage the cover or
the spare.
5-64

Instrument Panel Fuse Block
(Driver's Side)
Fuses Usage
A Wipers
BTrunk Release and Remote Keyless
Entry
C Turn Signals
D Power MirrorsFuses Usage
E Air Bag
F Body Function Control Module
G Powertrain Control Module (PCM)
H Door Locks
JBody Function Control
Module/Instrument Panel Cluster
MICRO RELAY
TRUNK RELRemote Trunk Release
CIRCUIT
BRKR
PWR SEATSPower Seats
MICRO RELAY
DR UNLOCKDoor Locks
MICRO RELAY
DR LOCKDoor Locks
MICRO RELAY
DRIVERS
DR UNLOCKDoor Locks
STOP LPS Stoplamps
HAZARD LPS Hazard Lamps
IPC/HVAC
BATTInstrument Panel Cluster,
Climate Control
5-78

Engine Compartment Fuse Block
The engine compartment fuse block is located on the
driver's side of the vehicle, near the engine air
cleaner/®lter. See
Engine Compartment Overview on
page 5-12for more information on location.
Fuses Usage
1 Ignition Switch
2Right Electrical Center-Fog Lamps,
Radio, Body Function Control
Module, Interior LampsFuses Usage
3Left Electrical Center-Stoplamps,
Hazard Lamps, Body Function
Control Module, Cluster, Climate
Control System
4 Anti-Lock Brakes
5 Ignition Switch
6 Not Used
7Left Electrical Center-Power Seats,
Power Mirrors, Door Locks, Trunk
Release and Remote Lock Control
8 Cooling Fan #1
Relays Usage
9 Rear Defogger
10 Not Used
11 Not Used
12 Cooling Fan #1
13 HVAC Blower (Climate Control)
14 Cooling Fan #2
15 Cooling Fan
16 Air Conditioning Compressor
17 Not Used
18 Fuel Pump
19 Automatic Headlamp System
5-80

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your belts,
buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-71.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page 6-21.
Automatic Transaxle Inspection
It is not necessary to check the transaxle ¯uid level.
A transaxle ¯uid leak is the only reason for ¯uid
loss. Check for leaks. If a leak occurs, take the vehicle
to your dealer and have it repaired as soon as
possible.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
speci®ed in Part D.
Body Lubrication Service
Lubricate all the body door hinges and latches, including
those for the hood and trunk lid. Part D tells you what
to use. More frequent lubrication may be required when
exposed to a corrosive environment.
6-16

E
Electrical System............................................5-76
Add-On Equipment......................................5-76
Fuses and Circuit Breakers...........................5-77
Headlamp Wiring.........................................5-76
Power Windows and Other Power Options......5-76
Windshield Wiper Fuses...............................5-76
Emergency Trunk Release Handle.....................2-13
Emissions Inspection and Maintenance
Programs...................................................3-32
Engine..........................................................5-17
Air Cleaner/Filter.........................................5-17
Battery.......................................................5-36
Check and Service Engine Soon Light............3-30
Compartment Overview................................5-12
Coolant Heater............................................2-19
Coolant Temperature Gage...........................3-29
Coolant......................................................5-19
Cooling System Inspection............................6-20
Exhaust.....................................................2-26
Oil .............................................................5-13
Overheating................................................5-22
Starting......................................................2-18
Engine Compartment Fuse Block......................5-80
Engine Coolant Level Check.............................6-15
Engine Cooling When Trailer Towing..................4-40Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-15
Entry/Exit Lighting...........................................3-15
Express-Down Window....................................2-15
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-12
F
Filter.............................................................5-17
Engine Air Cleaner......................................5-17
Finding a Station............................3-38, 3-42, 3-48
Finding PTY Stations...............................3-44, 3-51
Finish Care....................................................5-71
Finish Damage...............................................5-73
Fixed Mast Antenna........................................3-59
Flash-to-Pass Feature....................................... 3-7
Flat Tire........................................................5-56
Flat Tire, Changing.........................................5-57
Fluid.............................................................5-18
Automatic Transaxle.....................................5-18
Power Steering...........................................5-30
Windshield Washer......................................5-31
FM ...............................................................3-57
Fog Lamps....................................................3-14
Folding the Seatback........................................ 1-5
5

Part D - Recommended Fluids and Lubricants.....6-21
Part E - Maintenance Record............................6-22
Passing.................................................4-11, 4-38
Passlock
ž......................................................2-16
Plan Ahead When Possible................................ 7-7
Playing a Cassette Tape..................................3-52
Playing a Compact Disc..................3-39, 3-46, 3-54
Playing the Radio...........................3-37, 3-41, 3-48
Power Steering................................................ 4-8
Power............................................................. 1-3
Accessory Outlets........................................3-16
Door Locks.................................................. 2-8
Electrical System.........................................5-76
Steering Fluid.............................................5-30
Windows....................................................2-15
Programmable Automatic Door Locks.................. 2-9
Q
Questions and Answers About Safety Belts.........1-11
R
Radio Messages.............................3-39, 3-45, 3-52
Radios..........................................................3-36
Care of Your Cassette Tape Player................3-58
Care of Your CD Player...............................3-59
Care of Your CDs........................................3-59Radios (cont.)
Radio with Cassette and CD.........................3-48
Radio with CD....................................3-37, 3-41
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-37
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
Theft-Deterrent............................................3-57
Understanding Reception..............................3-57
RDS Messages......................................3-45, 3-51
Rear Door Security Locks................................2-10
Rear Safety Belt Comfort Guides......................1-25
Rear Seat Operation......................................... 1-5
Rear Seat Outside Passenger Positions.............1-20
Rear Seat Passengers, Safety Belts..................1-20
Rear Window Defogger....................................3-20
Rearview Mirrors.............................................2-28
Reclining Seatbacks.......................................... 1-3
Recreational Vehicle Towing.............................4-28
Remote Keyless Entry System,
Operation..................................................... 2-4
Remote Keyless Entry System............................ 2-3
Remote Trunk Release Lockout........................2-12
Remote Trunk Release....................................2-12
Removing the Flat Tire and Installing the
Spare Tire..................................................5-59
Removing the Spare Tire and Tools...................5-58
Replacement Bulbs.........................................5-47
Replacing Brake System Parts..........................5-35
10