2003 CHEVROLET CORVETTE door lock

The fuel ®ller door release
button is located inside of
the center console
storage compartment.If your fuel ®ller door release won't operate, there is a
manual release tab. The tab is located against the upper
trim on the driver's side in the rear compartment. Pull
the tab to manually release the fuel ®ller door.
While refueling, rest the tether across the tab on the
fuel ®ller door to prevent damage to your vehicle's ®nish.
To remove the fuel cap, turn it slowly to the left
(counterclockwise). The fuel cap has a spring in it; if
you let go of the cap too soon, it will spring back to
the right.
5-8

Bulb Replacement
For the proper type of replacement bulb, seeBulb
Replacement on page 5-47.
For any bulb changing procedure not listed in this
section, contact your dealer's service department.
Halogen Bulbs
{CAUTION:
Halogen bulbs have pressurized gas inside
and can burst if you drop or scratch the bulb.
You or others could be injured. Be sure to read
and follow the instructions on the bulb
package.
Headlamps
1. The headlamp doors need to be halfway open.
Turn the headlamps on, then quickly back to the
parking lamps setting. You may have to do
this a few times to get the half-open position.
You can also open the headlamp doors manually
by turning the adjuster counterclockwise.
5-47

Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of maxi-fuses, mini-fuses
and circuit breakers. This greatly reduces the chance
of ®res caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the identical
size and rating.
If you ever have a problem on the road and don't have
a spare fuse, you can borrow one that has the same
amperage. Just pick some feature of your vehicle
that you can get along without ± like the radio or
cigarette lighter ± and use its fuse, if it is the correct
amperage. Replace it as soon as you can.
Instrument Panel Fuse Block
The instrument panel fuse
block is located on the
passenger's side of
the vehicle, under the
instrument panel and
under the toe-board.
Remove the carpet and toe-board covering to access
the fuse block by pulling at the top of each corner of the
panel. Then turn the fuse block door knob
counterclockwise and pull the door to access the fuses.
5-86

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-78.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page 6-14.
Manual Transmission Check
Check the transmission ¯uid level; add if needed. SeeManual Transmission Fluid on page 5-20. Check
for leaks. A ¯uid leak is the only reason for ¯uid loss.
Have the system inspected and repaired if needed.
Automatic Transmission Check
It is not necessary to check the transmission ¯uid level.
A transmission ¯uid leak is the only reason for ¯uid
loss. Check for leaks. If a leak occurs, take the vehicle
to your dealer and have it repaired as soon as
possible.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
speci®ed in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, console door and any folding seat
hardware. Part D tells you what to use. More frequent
lubrication may be required when exposed to a corrosive
environment.
6-9

Usage Fluid/Lubricant
Key Lock
CylindersMulit-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Rear Axle
(Limited-Slip
Differential)SAE 75W-90 Synthetic Axle
Lubricant (GM Part No. U.S.
12378261, in Canada 10953455, or
equivalent) meeting GM
Speci®cation 9986115. With a
complete drain and re®ll add
4 ounces (118 ml) of Limited-Slip
Axle Lubricant Additive (GM Part
No. U.S. 1052358, in Canada
992694, or equivalent) where
required. See
Rear Axle on
page 5-46.
Usage Fluid/Lubricant
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol (GM
Part No. U.S. 12346293, in Canada
992723, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
10953014, or equivalent).
6-15

Customer Assistance Information........................ 7-7
Courtesy Transportation.................................. 7-7
Customer Assistance for Text Telephone
(TTY) Users.............................................. 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to General Motors....7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government.............................................. 7-9
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-10
D
Daytime Running Lamps..................................3-13
Defensive Driving............................................. 4-2
Defogging and Defrosting.................................3-27
Disabling the Theft-Deterrent Feature.................3-77
Disarming the System.....................................2-17
Doing Your Own Service Work........................... 5-3
Door............................................................... 2-9
Locks.......................................................... 2-9
Power Door Locks.......................................2-10
Downshifting (Manual Transmission)..................2-29Driver Information Center (DIC).........................3-44
DIC Controls and Displays............................3-45
DIC Warnings and Messages........................3-53
Other Messages..........................................3-61
Driver............................................................1-13
Position, Safety Belt.....................................1-13
Driving On Snow or Ice...................................4-28
Driving Through Deep Standing Water...............4-21
Driving Through Flowing Water.........................4-21
Driving..........................................................4-18
At Night.....................................................4-18
City...........................................................4-22
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-23
Hill and Mountain Roads..............................4-25
In Rain and on Wet Roads...........................4-19
Winter........................................................4-27
Dual Automatic Climate Control System.............3-22
E
Electrical System............................................5-84
Accessory Power Plug.................................5-84
Add-On Equipment......................................5-84
Fuses and Circuit Breakers...........................5-86
Headlamp Wiring.........................................5-85
4

LATCH System (cont.)
Latches, Seatback............................................ 1-5
Leaving Your Vehicle With the Engine Running
(Automatic Transmission)..............................2-32
Leaving Your Vehicle.......................................2-10
Lifting From the Front......................................5-66
Lifting From the Rear......................................5-67
Lifting Your Corvette, Tires...............................5-64
Lighted Visor Vanity Mirrors..............................2-15
Light.............................................................3-37
Active Handling System................................3-37
Air Bag Off .................................................3-33
Air Bag Readiness.......................................3-32
Anti-Lock Brake System Warning...................3-36
Brake System Warning.................................3-35
Check Gages Warning.................................3-42
Malfunction Indicator....................................3-38
Safety Belt Reminder...................................3-31
Security.....................................................3-42
TCS Warning Light......................................3-36
Traction Control System (TCS) Warning..........3-36
Limited-Slip Rear Axle.....................................4-11
Loading Your Vehicle.......................................4-33
Lockout Protection..........................................2-10
Locks............................................................. 2-9
Door........................................................... 2-9
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door................................................2-10Loss of Control...............................................4-17
Lowering the Convertible Top............................2-50
M
Magnesium Wheel Finish.................................5-81
Magnetic Speed Variable Assist Steering............4-13
Maintenance, Normal Replacement Parts............5-94
Maintenance Schedule...................................... 6-8
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-8
At Least Once a Year.................................... 6-9
At Least Twice a Year................................... 6-9
Brake System Inspection..............................6-13
Engine Cooling System Inspection.................6-13
Exhaust System Inspection...........................6-12
Fuel System Inspection................................6-13
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services............... 6-8
Part C - Periodic MaintenanceInspections......6-12
Part D - Recommended Fluids and
Lubricants...............................................6-14
Part E - Maintenance Record........................6-16
Rear Axle Service........................................6-13
Scheduled Maintenance................................. 6-4
Steering and Suspension Inspection...............6-12
8

P
Park (P)........................................................2-31
Shifting Into................................................2-31
Shifting Out of............................................2-33
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-11
Parking Your Vehicle.......................................2-34
Parking.........................................................2-30
Brake........................................................2-30
Over Things That Burn.................................2-34
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services.................. 6-8
Part C - Periodic MaintenanceInspections..........6-12
Part D - Recommended Fluids and Lubricants....6-14
Part E - Maintenance Record...........................6-16
Passenger Position, Safety Belts.......................1-20
Passing.........................................................4-15
PASS-Key
ž....................................................2-17
Plan Ahead When Possible................................ 7-7
Playing a Cassette Tape..................................3-65
Playing a Compact Disc...................................3-69
Playing the Radio...................................3-63, 3-67
Power Antenna Service..................................... 6-8
Power Steering...............................................4-13
Power...........................................................3-20
Accessory Outlets........................................3-20
Antenna Mast Care......................................3-79
Door Locks.................................................2-10
Electrical System.........................................5-85Power (cont.)
Seat............................................................ 1-2
Steering Fluid.............................................5-35
Windows....................................................2-15
Q
Questions and Answers About Safety Belts.........1-11
R
Racing or Other Competitive Driving..................2-22
Radios..........................................................3-62
Care of Your Cassette Tape Player................3-78
Care of Your CD Player...............................3-79
Care of Your CDs........................................3-79
Radio with Cassette.....................................3-63
Radio with CD............................................3-67
Setting the Time..........................................3-62
Theft-Deterrent............................................3-75
Trunk-Mounted CD Changer..........................3-71
Understanding Reception..............................3-77
Raising the Convertible Top..............................2-53
Reading Lamps..............................................3-16
Rear Axle......................................................5-46
Limited-Slip.................................................4-11
Service......................................................6-13
Rear Storage Area..........................................2-41
Rear Window Defogger....................................3-27
10