2003 CHEVROLET ASTRO headlamp

13
14
15
16
Fuse/Circuit Usage Breaker
10 Air Bag System
11 Not Used
12 L, MI, M2 Blower Motor, Rear Air
Conditioning Relay Coil, Front Cont.
Temp. Door Motor, HI Blower Relay.
Defogger Timer Coil
Cigarette Lighter, Door Lock
Switches, Dutch Door Release Module
Cluster Illum, Climate Controls,
Chime Module, Radio Illumination,
Rear Heat Switch Illumination, Rear
Wipermasher Switch Illumination,
Rear Liftgate Switch Illumination,
Remote Cassette Illumination,
Overhead Console, Truck Body
Control Illurnination
Truck Body Module, Headlamp Relay
Front Turn Signals, Rear Turn
Signals, Trailer Turn Signals,
Back-up Lamps, Brake Transmission
Shift Interlock Solenoid 21
22
23
24
A
19
20
FuseKircuit
Usage
Breaker
17 Front Wipers, Front Washer Pump
18 VCM-lgn
3, VCM-Brake, Cruise
Stepper Motor Signal, ATC Module
Instrument Panel Radio: ATC
(Main Feed),
2000 Series (Standby)
PRNDUOdometer, TCC Enable and
PWM Solenoid, Shift A and Shift B
Solenoids, 3-2 Downshift Solenoid, Instrument Panel Cluster, VCM
Module
Powr Adjust Mirrors
Not Used
Rear Wiper, Rear Washer Pump
Not Used
(Circuit Breaker) Power Door Lock
Relay, 6-Way Power Seats
(Circuit Breaker) Power Windows
B
5-95

Usage
Rear/Heat and Air Conditioning
Relays
AIC Relay
(Rear Heat
and AIC)
Relay
Relay
A/C Enable
Relay
Upfitter-ACCY
Upfitter Accessory
Starter Enable Starter
Headlamps Relay
Fuel Pump
Relay Air
Conditioning
Headlamps
Fuel Pump
FuselCircuit
Usage
UPFITTER- Upfitter Battery Power Stud,
BATT Trailer Wiring Harness
UPFITTER- Upfitter Accessory Relay
ACCY
Spare Not used
Spare Not used
Breaker FuselCircuit
Breaker
Spare
ECM-1 B
HORN
AIC COMP
RR HTR/AC ATC
FRT HVAC
ENG-I
IGN-E
ECM-I
Blank
RH HDLMP
LH Headlamp
Blank
Blank
Usage
Not used
Fuel Pump Relay and Motor, VCM,
Oil Pressure Switch/Sender
Horn Relay and Horn
Air Conditioning Enable Relay and
Compressor
Rear Heater and Air Conditioning
Active Transfer Case-L Van
Front Heater and Air Conditioning
Oxygen Sensors, Camshaft Position
Sensor, Mass Air Flow Sensor,
Evaporative Emission Canister
Vent Solenoid
Air Conditioning Enable Relay Coil
Fuel Injectors
1-6, Crankshaft
Position Sensot, VCM, Coil Driver
Module (EST), Ignition Coil
Not Used
Right Headlamp
Left Headlamp
Not Used
Not Used
5-97

Automatic Headlamp System ..................
Automatic Transmission
Fluid
................................................
Automatic Transmission Check ................
Automatic Transmission Shift Lock Control
System Check
...................................
Operation .........................................
......... 3-13
......... 5-25
......... 2-23
......... 6-27
......... 6-28
Backing Up
.................................................... 4-38
Battery
.......................................................... 5-46
Battery Replacement
......................................... 2-6
Battery Run-Down Protection
............................ 3-1 6
Before Leaving on a Long Trip
......................... 4-21
Bench Seat
............................................ 1-1 1, 1-57
Body Lubrication Service
.................................. 6-27
Brake Parking
...................................................... 2-26
System Inspection
....................................... 6-31
System Warning Light
.................................. 3-28
Brake Adjustment
............................................ 5-45
Brake Fluid
.................................................... 5-42
Brake Pedal Travel
......................................... 5-45
Brake Wear
................................................... 5-45
Brakes
.......................................................... 5-42
Braking in Emergencies
..................................... 4-9
Break-In, New Vehicle
..................................... 2-19
Braking
........................................................... 4-6
Bucket Seats, Rear
......................................... 1-12 Bulb
Replacement
........................................... 5-55
Halogen Bulbs ............................................ 5-55
Headlamps
............................ ......... 5-55
Replacement Bulbs
.............................. 5-61
Taillamps
.................................................... 5-60
Front
Turn Signal Lamps
.............................. 5-59
Buying New Tires
................................... 5-66
C
California Fuel .................................................. 5-6
Canada
........................................................... 7-5
Canadian Owners
................................................ ii
Canadian Roadside Assistance ............ ....... 7-7
Cancelling the Sliding Door
Security Lock
.......................................... 2-12
Capacities and Specifications
........................ 5-99
Carbon Monoxide
............... ..... 4-24, 4-31, 2-30
Care of
Safety Belts
.... ~ ~ ~ ~ ..................... 5-86
Care of Your
CD Player
.......... ...., ............ ..... 3-50
CDS
.......................................................... 3-50
Cargo Vans
........................................... 1-41, 1-48
Center Passenger Position, Safety Belts
............. 1-27
Chains, Tires
..................................... ..... 5-70
Charging System Light
....................... ..... 3-27
Engine Light
.............................. , ..... 3-30
Check
Gages Warning Light
................................... 3-36
2

Checking Brake Fluid .................................. 5-43
Checking Coolant ............................................ 5-29
Checking Engine Oil ........................................ 5-15
Checking Things Under the Hood ...................... 5-1 1
Checking Your Restraint Systems ...................... 1-71
Chemical Paint Spotting ................................... 5-89
Child Restraints
Child Restraint Systems
............................... 1-44
Infants and Young Children ........................... 1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)
.......................... 1-52
Older Children ............................................. 1-35
Securing a Child Restraint Designed for
the LATCH System
................................ 1-54
Securing a Child Restraint in a Center
Seat Position
....................................... 1-57
Securing a Child Restraint in a Rear
Outside Seat Position
............................... 1-54
Securing a Child Restraint in the Right
Front Seat Position
................................... 1-59
Top Strap ................................................... 1-48
Top Strap Anchor Location ............................ 1-50
Where to Put the Restraint ........................... 1-47
Cigarette Lighter ............................................. 3-1 7
Cleaning
Inside of Your Vehicle
.................................. 5-83
Outside of Your Vehicle ................................ 5-86
Underbody Maintenance ............................... 5-89
Weatherstrips .............................................. 5-86
Cleaning Exterior Lamps/Lenses ....................... 5-86
Climate Control System ................................... 3-18
Rear .......................................................... 3-21
Rear Heating System ................................... 3-19
Compact Disc Messages .................................. 3-45
Compact Spare Tire ........................................ 5-82
Composite Headlamps ..................................... 5-56
Control of a Vehicle .......................................... 4-6
Convenience Net ............................................ 2-45
Coolant
Engine Temperature Gage
............................ 3-30
Heater, Engine ............................................ 2-22
Cooling System .............................................. 5-33
Cruise Control ................................................ 3-10
Current and Past Model Order Forms ................ 7-12
Customer Assistance Information
Customer Assistance for Text
Customer Assistance
Off ices ........................... 7-4
Customer Satisfaction Procedure ..................... 7-2
GM Mobility Program for Persons with
Disabilities
................................................ 7-5
Reporting Safety Defects to General Motors ....... 7-11
Reporting Safety Defects to the
Canadian Government
.............................. 7-11
Reporting Safety Defects to the United States Government
......................... 7-10
Roadside Assistance Program ......................... 7-6
Service Publications Ordering Information ........ 7-11
Rear Air Conditioning System ........................ 3-20
Courtesy Transportation ......... ...... 7-8
Telephone (TTY) Users ............................... 7-4
3

Daytime Running Lamps (DRL) ...................... 3-14
Defensive Driving
............................................. 4-2
Defogging and Defrosting
................................. 3-1 9
Directing the Airflow
........................................ 3-20
Disabling the Theft-Deterrent Feature
................. 3-49
Doing Your Own Service Work
........................... 5-3
Dome Lamps
.......................................... ~ ~~~ 3-16
Door Front Doors
............................................... 2-8
Locks
.......................................................... 2-7
Power Door Locks
......................................... 2-8
Programmable Automatic Door Locks
............... 2-9
Rear Doors
................................................. 2-13
Sliding Side Door
........................................ 2-10
Position, Safety Belt
..................................... 1-1 8
Driver Information System
................................ 2-42
At Night
..................................................... 4-14
City
........................................................... 4-19
Defensive
..................................................... 4-2
Drunken
....................................................... 4-3
Freeway
..................................................... 4-20
Hill and Mountain Roads
.............................. 4-22
In Rain and on Wet Roads ........................... 4-16
Winter
........................................................ 4-24
Driving On Grades
.......................................... 4-39
Driving on Snow or Ice
.................................... 4-24
Driver
Driving Driving
Through Deep Standing Water
............... 4-18
Driving Through Flowing Water
......................... 4-18
Driving with a Trailer
....................................... 4-37
E
Electrical System
Add-on Equipment
...................................... 5-92
Headlamp Wiring
......................................... 5-92
Fuses and
Circuit Breakers
........................... 5-93
Power Windows and Other Power Options
......... 5-92
Windshield Wiper Fuses
............................... 5-92
Emissions Inspection and
Engine Maintenance Programs
................................. 3-33
Air Cleaner/Filter
......................................... 5-24
Battery
....................................................... 5-46
Check and Service Engine Soon Light
............ 3-30
Coolant
...................................................... 5-28
Coolant Heater
............................................ 2-22
Coolant Temperature Gage
........................... 3-30
Cooling System Inspection
............................ 6-30
Cover
........................................................ 5-20
Engine Compartment Overview
...................... 5-14
Exhaust
..................................................... 2-30
Fan Noise
.................................................. 5-39
Oil
............................................................. 5-15
Starting
...................................................... 2-21
Overheating
................................................ 5-31
4

Gasoline Octane
........................................................ 5-5
Specifications
............................................... 5-5
Gate Operator and Canadian Programming
........ 2-36
Glass Surfaces
............................................... 5-85
GM Mobility Program for Persons with
Disabilities
.................................................... 7-5
Hatch R
H
e I' ease ......................... ........ 2-15
Hazard Warning Flashers
............................... 3-4
Head Restraints
............................................... 1-5
Headlamp High/Low-Beam Changer
.................... 3-7
Headlamp Wiring
............................................ 5-92
Headlamps
.................................................... 5-55
Bulb Replacement
.................................... 5-55
Front Turn Signal Lamps
.................. ..... 5-59
Halogen Bulbs
............................ ........ 5-55
Highway Hypnosis
........................................... 4-22
Hill and Mountain Roads
.................................. 4-22
Hitches
.......................................................... 4-36
HomeLink Transmitter, Programming
.................. 2-35
HomeLink@ Transmitter
.................................... 2-34
Hood Checking Things Under
................................ 5-1 1
Release
..................................................... 5-1 1
Horn
............................................................... 3-5 How
to Add Coolant to the Coolant
How to Add Coolant to the Radiator
.................. 5-37
How to Add Fluid
............................................ 5-27
How to Check
........................................ 5-25, 5-64
How to Check Lubricant
................................... 5-53
How to Check Power Steering Fluid
.................. 5-40
How to Use This Manual
...................................... ii
Recovery Tank ........................................ 5-34
How to Wear Safety Belts Properly
................... 1-18
Hydroplaning
.................................................. 4-18
I
If No Steam Is Coming From
Your Engine
............................................ 5-32
If Steam Is Coming From Your Engine ........... 5-31
If the Light
Is Flashing ..................................... 3-32
If the Light
Is On Steady ................................. 3-32
If You Are Stuck in Sand, Mud, Ice or Snow
....... 4-28
If You Do Decide
To Pull A Trailer ..................... 4-32
If You're Caught in a Blizzard ........................... 4-26
Ignition Transmission Lock Check
...................... 6-29
Infants and Young Children, Restraints
............... 1-38
Inflation
- Tire Pressure ................................... 5-64
Inspection Brake System
............................................. 6-31
Engine Cooling System
................................ 6-30
Ignition Positions
............................................. 2-19
6

Restraint System Check ..................... ... 6-26
Checking Your Restraint Systems
..... ... 1-71
Replacing Restraint System Parts
After a Crash
....................................... 1-71
Checking
.................................................... 1-71
Restraints, Head
............................................... 1-5
Retained Accessory Power (RAP)
...................... 2-20
Right Front Passenger Position, Safety Belts
......... 1-27
Roadside Assistance Program
....................................... 7-6
Rocking Your Vehicle To Get It Out
................... 4-28
Running Your Engine While You Are Parked
....... 2-31
Restraint Systems
Replacing Parts
........................................... 1-71
Safety Belt
Safety Belts
Reminder Light
... .................................. 3-26
Care
of ...................................................... 5-86
Center Passenger Position
............................ 1-27
Driver Position
............................................ 1-1 8
How to Wear Safety Belts Properly ................ 1-18
Questions and Answers About Safety Belts
........ 1-1 7
Rear Safety Belt Comfort Guides for
Children and Small Adults
......................... 1-32
Rear Seat Passengers
................................. 1-29
Right Front Passenger Position
...................... 1-27 Safety Belts
(cont.)
Safety Belt Extender
.................................... 1-34
Safety Belts Are for Everyone
....................... 1-13
Safety Belt
Use During Pregnancy
................. 1-26
Safety Chains
................................................. 4-36
Safety Warnings and Symbols
.............................. III
Sealed Beam Headlamp .................................. 5-55
Seatback Latches ............................................. 1-6
Seats Bench Seat
.......... ..........., ........ 1-11
Bucket Seats, Rear
................... ........ 1-12
Head Restraints
............................................ 1-5
Manual
........................................................ 1-2
Manual Lumbar
............................................. 1-3
Power Seat
.................................................. 1-3
Rear Seat Operation
...................................... 1-7
Reclining Seatbacks
...................................... 1-4
Seatback Latches
.......................................... 1-6
Center Seat Position
.................................... 1-57
Designed for the LATCH System
................... 1-54
Rear Outside Seat Position ........................... 1-54
Right Front Seat Position
.............................. 1-59
Security Light
................................................. 3-35
Selecting the Right Schedule, Maintenance
.......... 6-5
Selecting the Fan Speed
.................................. 3-20
Service
........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle
.............................................. 5-4
All-Wheel-Drive Light
.................................... 3-35
...
Securing a Child Restraint
11