2003 CHEVROLET ASTRO CARGO VAN spare tire location

Removing the Flat Tire and Installing
the Spare Tire
1. Before you start, block the front and rear of the tire
farthest away from the one being changed. Then
put your compact spare tire near the ¯at tire.
{CAUTION:
Getting under a vehicle when it is jacked up is
dangerous. If the vehicle slips off the jack you
could be badly injured or killed. Never get under
a vehicle when it is supported only by a jack.
{CAUTION:
Raising your vehicle with the jack improperly
positioned can damage the vehicle and even
make the vehicle fall. To help avoid personal
injury and vehicle damage, be sure to ®t the
jack lift head into the proper location before
raising the vehicle.2. With the DOWN side facing you, turn the ratchet
and socket to loosen all the wheel nuts
counterclockwise. Don't remove them yet.
3. The jack has a bolt on the end. Attach the socket
end of the extension to the jack bolt.
5-76

A. Rear Jack Location
B. Jack
C. Ratchet and Extension7. Raise the vehicle by turning the ratchet clockwise.
Make sure the UP mark faces you. Raise the
vehicle far enough off the ground so there is enough
room for the compact spare tire to ®t underneath
the wheel well.
8. Remove all the wheel nuts and take off the ¯at tire. Rear Position
5-78

Storing a Flat or Spare Tire and Tools
{CAUTION:
Storing a jack, a tire, or other equipment in the
passenger compartment of the vehicle could
cause injury. In a sudden stop or collision,
loose equipment could strike someone. Store
all these in the proper place.
1. Put the ¯at tire on the ground at the rear of the
vehicle with the valve stem pointed down.
2. Tilt the retainer plate downward and through the
wheel opening. Make sure it is fully seated across
the underside of the wheel. Attach the ratchet,
with the UP side facing you, to the extension.3. Put the ¯at end of the extension on an angle
through the hole in the rear door frame, above
the bumper.
The compact spare is for temporary use only.
Replace the compact spare tire with a full-size tire
as soon as you can. SeeCompact Spare Tire
on page 5-82. See the storage instructions label to
restore your compact spare properly.
4. Raise the tire fully against the underside of the
vehicle by turning the ratchet/wheel wrench until
you hear two clicks or feel it skip twice. The spare
tire hoist cannot be overtightened.
5. Make sure the tire is stored securely. Push, pull,
and then try to rotate or turn the tire. If the tire
moves, use the ratchet/wheel wrench to tighten
the cable.
Return the jacking equipment to its proper location.
5-81

Checking Brake Fluid......................................5-43
Checking Coolant............................................5-29
Checking Engine Oil........................................5-15
Checking Things Under the Hood......................5-11
Checking Your Restraint Systems......................1-71
Check...........................................................3-30
Engine Light...............................................3-30
Gages Warning Light...................................3-36
Chemical Paint Spotting...................................5-89
Child Restraints..............................................1-44
Child Restraint Systems...............................1-44
Infants and Young Children...........................1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-52
Older Children.............................................1-35
Securing a Child Restraint Designed for the
LATCH System........................................1-54
Securing a Child Restraint in a Center Seat
Position..................................................1-57
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-54
Securing a Child Restraint in the Right Front
Seat Position...........................................1-59
Top Strap Anchor Location............................1-50
Top Strap...................................................1-48
Where to Put the Restraint...........................1-47
Cigarette Lighter.............................................3-17
Cleaning Aluminum Wheels..............................5-88
Cleaning Exterior Lamps/Lenses.......................5-86Cleaning Fabric/Carpet....................................5-83
Cleaning Glass Surfaces..................................5-85
Cleaning Interior Plastic Components.................5-85
Cleaning Leather............................................5-85
Cleaning the Top of the Instrument Panel...........5-85
Cleaning the Windshield and Wiper Blades.........5-87
Cleaning Tires................................................5-88
Cleaning Vinyl................................................5-85
Cleaning........................................................5-83
Inside of Your Vehicle..................................5-83
Outside of Your Vehicle................................5-86
Underbody Maintenance...............................5-89
Weatherstrips..............................................5-86
Climate Control System...................................3-18
Rear Air Conditioning System........................3-20
Rear Heating System...................................3-19
Rear..........................................................3-21
Compact Disc Messages..................................3-45
Compact Spare Tire........................................5-82
Composite Headlamps.....................................5-56
Control of a Vehicle.......................................... 4-6
Convenience Net............................................2-45
Coolant.........................................................3-30
Engine Temperature Gage............................3-30
Heater, Engine............................................2-22
Cooling System..............................................5-33
Cruise Control................................................3-10
Current and Past Model Order Forms................7-12
3

Tires.............................................................5-63
Buying New Tires........................................5-66
Chains.......................................................5-70
Changing a Flat Tire....................................5-71
Compact Spare Tire.....................................5-82
If a Tire Goes Flat.......................................5-70
In¯ation Ð Tire Pressure..............................5-64
Inspection and Rotation................................5-64
Uniform Tire Quality Grading.........................5-67
Wheel Alignment and Tire Balance.................5-69
Wheel Replacement.....................................5-69
When It Is Time for New Tires......................5-66
To Use the Engine Coolant Heater....................2-22
Top Strap Anchor Location...............................1-50
Top Strap......................................................1-48
Torque Lock...................................................2-29
Total Weight on Your Vehicle's Tires..................4-35
Tow/Haul Mode Button.....................................2-25
Tow/Haul Mode Light.......................................3-36
Towing..........................................................4-29
Recreational Vehicle.....................................4-29
Towing a Trailer..........................................4-31
Your Vehicle...............................................4-29
Trailer Brakes.................................................4-36
Trailer Wiring Harness.....................................4-41
Trailering Package..........................................4-31
Transfer Case................................................5-52Transmission Operation, Automatic....................2-23
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-11
Transmission..................................................5-25
Fluid, Automatic...........................................5-25
Transportation Options...................................... 7-9
Trip Odometer................................................3-25
Turn and Lane Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
Turn Signals When Towing a Trailer..................4-38
U
Underbody Flushing Service.............................6-29
Underhood Fuse Block....................................5-96
Understanding Radio Reception........................3-50
Uniform Tire Quality Grading............................5-67
United States ± Customer Assistance.................. 7-4
Unlocking the Theft-Deterrent Feature After a
Power Loss................................................3-49
Used Replacement Wheels..............................5-70
Using Cleaner on Fabric..................................5-84
Using HomeLink
ž...........................................2-37
14